Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
I've had the Yoder for about 4 years now. Never looked back. It made my old Traeger look like a dime-store trinket. Thick metal. Built like a tank. Hold temps perfectly. I used to monitor grill temp. Realized quickly there was no need. Not even in the wind and cold. Eats less pellets than my old Traeger. Don't get me wrong, the Traeger works great when conditions are perfect, but in Omaha, NE, things are rarely perfect. It's true that compared to an offset you won't realize as strong of smoke flavor. That's good and bad, depending on what you're going for. When you're after dense smoke flavor, a simple smoke tube is all you need to get it to where you need.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
The Memphis Pro Wood Fire Pellet Grill is one of the best pellet grills on the market. It combines high-quality construction and engineering with versatile cooking capabilities that will let you "grill" almost anything. Able to reach temperatures out to 650 degrees F. this pellet grill can sear a steak while also being able to hold temperatures down to 180 degrees F. so it can smoke, low and slow, any kind of BBQ. Add to this the convection fans and temperature control precision this wood pellet grill can rival the best indoor ovens. This truly is a grill that can do it all and give you an authentic wood flavor.
Cooking a lot of food is easy when using Camp Chef’s Flat Top Grill. The large surface area will enhance your cooking experience giving you plenty of room to work so cooking is done efficiently. Included is an interchangeable flat top griddle making it easy to cook pancakes, bacon and eggs, sausage, and hash browns - all at once. Then switch to grilled burgers, kabobs, and chicken for the next meal. Four individual burners provide heat in specific areas creating heat zones that will help you manage hot foods. Built in matchless ignition knobs control the heat and flame. Fold-down side shelves and roller wheels are added for convenience.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
As people learn about pellet grills, they quickly realize that there are a number of brands offering a variety of models. So how are they different? And how do you know which pellet grill is right for you? With more options than ever, shopping for a pellet grill can be confusing. In a market filled with grills that claim similar capabilities, it can be difficult to discern what separates one from another. However, if you know which factors to consider and what features to look for, choosing the best pellet grill for you is a whole lot easier.
There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.
I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods! 🙂
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
Tech geeks: A tech geek will also prefer a Pellet smoker grill and some of the latest grills including Green Mountain Grills came up with some exciting tech functionality like Wi-Fi! Just imagine, hanging with friends and monitoring your pork with your smartphone? You can increase and decrease temperature and control pellet feed without even touching the grill. This gives you the ability to cook while you work!
Pellet grills preheat quickly, so you can start cooking almost immediately, and the pellets are available in a number of woods, for different smoke flavors. The smoke has a subtle wood-fired flavor with less of the acrid flavor that comes from standard wood or charcoal. For the maximum smoke flavor, it’s best to cook at a temperature lower than 250 degrees, while higher temperatures cook faster with less smoke.