Choosing the one perfect pellet grill that could change your cooking experience is easier said than done. There is just so know you have to know before committing to it. Though I did give you a run-through of all the basic and important things to look for in a pellet grill before buying one, it is still a scratch on the surface. It is tiring to have to go from store to store to find the quality ones that you can choose from. So, to come to your rescue once again, I will now give you the some pellet grill review.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.

REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).

The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.

Now, jump ahead to my actually trying to get my Traeger replaced.  Per the email, I called Traeger customer service expecting the same service I received right after Christmas.  NOPE!    I spoke with Frank (Carson) I believe.  He did everything from accuse me of shutting my grill off and turning it back on incorrectly (impossible since I was in the house) to not cleaning my grill.   Neither of which were correct.    He basically made me feel like my grill was unsafe!  His attitude was HORRIBLE!  He was rude and condescending.   A nightmare to work with!


Some products feature the wood-pellet fuel system as a bonus, but the Camp Chef SmokePro SG makes its wood-fired function the star of the show. Using 100% real hardwood pellets, recreating 5-star-cuisine level dishes on a large scale is now made convenient. Though it still has limited reviews, it wouldn’t be a surprise if this smoker quickly becomes a best-selling choice. It’s the kind of smoker that you need if you want hassle-free and fast cooking.
-Warranty-(Forgive my soapbox here, folks.) I'd give it 5 stars if Camp Chef would give it a real warranty. One year is pathetic and WAY below the industry standard. Camp Chef, I know you are reading this because you guys are too excited about your great new product to not pay attention to feedback like this. Nut up and stand behind your awesome product. Why would anybody buy a product from an industry newcomer with no track record when you yourself are only willing to stand behind it for 1 lousy year?... Especially when the "industry leader" will guarantee their product for 3 years?!?! You are communicating that you have 1/3rd the amount of trust in your product that Traeger does. That's terrible! You should exceed what they are offering just to make the point in the industry! At a minimum, you should at least match their warranty just so it doesn't become a stumbling block to potential customers. Look, you basically took the lil tex and said "ok boys, so how can we make this better?!?" You did that! You totally knocked it out the park! Why cheap out with the warranty?!? As a customer, it makes me nervous that you know something I don't.
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
I did a lot of research, and ended up buying the Camp Chef DLX24. It was at a price that fit my budget, (under $500) and had a lot of features the others didnt. The pellet trap door for quick dumping of the pellet hopper into a bucket, and the ash cleanout under the drum was a clincher. Being able to pull a lever and dump the ashes into an easily removable cup is a great feature that all grills should include.It has a digital temperature controller, and dual probes (one inside the smoker for grill temp, one for the meat) and overall good quality construction. The second shelf inside is standard (you pay extra for that on other grills). If your budget allows, would suggest purchasing the propane powered sear box ($199) which attaches to the side of the grill and allows for reverse searing meat..
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!

This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.
And of course, it’s definitely a plus when the company that makes your grill includes a multi-year warranty and top notch customer service. Pellet grills are finicky compared to gas or charcoal grills simply because there are so many more parts that require electronics or that have electrical components… which means there is a fair bit more that can actually go wrong or require service at some point.
For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Kevin: I have a gas smoker but would like a wood pellet smoker. I’m looking at Traeger Lil Tex (due to price) but I read about Blazn Grill Works, Grand Slam, made in USA, stainless steel grates and a control unit that is very good. Cost about $1195, can’t find dealers so called and talked with the owner. What I read on web site sounds good. He claims on his short video that his auger is the best and doesn’t put torque on the drive due to the design. Any thoughts on this unit? Any advice would be appreciated. Still looking at the Yoder YS640 as price is very similar.
For me, I don't care where it is built; it could be Oregon, China or the moon. But I want a smoker that is reliable. As a businessman, I don't understand this company. It is going to be a lot more expensive for the company when I return this thing to Costco and Costco makes Traeger take it back. Just being responsive and sending a new controller under warranty would seem to be easier and cheaper. Of course, if this was a normal company, they would fix the root cause (poor reliability) and make lots of money selling to happy customers. Read more
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.

My wife and I purchased this over the weekend. Been wanting this grill for a while. $349.99 includes cookbook, 3 years warranty +costco visa warranty. They also had the lil tex and the other bigger grills at reasonable prices. Links are for the locations for their "roadshow" in order to capture the prices. Technically doesn't come with the cover but I convinced the rep to throw one in.
The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.

Designed specifically to heat quickly this little outdoor Designed specifically to heat quickly this little outdoor cooker is a powerhouse when it comes to boiling brewing or frying. With its high-pressure burner system this stove is a great addition to anyone’s gear and works perfectly for all types of canning. The small size and portability also makes this ...  More + Product Details Close

The Green Mountain Grills Davy Crockett is a versatile, wood-pellet grill that is intended for portability. Regardless of its weight, it’s about as minimized as you can get, and takes care of business. Contrasted with more costly wood pellet barbecues, it appears to hold its own on performance, while the one of a kind Wi-Fi usefulness needs some finish.
With that said, we can guarantee that all of the grills on this list are designed from the best quality materials and design elements to ensure that it not only lasts the test of time, it is safe to use, easy to set up, and also designed to cook the best meals possible. With that said, let’s talk about a pillar that has added to the quality criteria, the material design.
As more pellet grills enter the market, they are forced to differentiate themselves from the competition. One way of doing that is through innovative technology and advanced abilities. When comparing pellet grills, look at the whole package, including its capabilities, as well as which features are available and whether they come standard or are optional. Some of the more popular features to look for include:
Yeah it seems like no one is providing any input on it…I was interested in having them review it and do a direct comparison to some of these other grills. I made the mistake of getting a Myron Mixon pitmaster Q3 at sears. It turned out to be a waste of money and the slight humidity I had caused the pellets to burst and seize up the Auger. Anyway I had narrowed my search down to a rec tech or silverback but none of the reviewers seems to be giving it any attention.
Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:
Set it and forget it. It does not require you to stay while the food is being cooked as you can set a timer and temperature so you can do other things, like prepare the side dishes or drink beer with friends while the grill is doing its job. Most pellet grills use electronic controls to regulate the grilling according to your preferences. You have a choice to choose the level of smoke aside from choosing your desired temperature.
Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.

If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.


For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.
The hopper capacity is the same as the Traeger Lil’ Tex Elite 22, but what sets it apart is the “Pellet Hopper Drain Chute Technology”. So if you are looking to try a different wood or just storing the grill for a long time, then all you need to do is hang a bucket on the chute and pull out the knob to catch the pellets… and before you know, the tedious task will be over, leaving you with nothing but love for your Camp Chef Grill.
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
Whether you call them pellet grills or pellet smokers (the terms are interchangeable), there's no denying the impact these do-everything cookers are having on BBQ. In the past year alone, interest in pellet grills has grown at an astounding rate, with the number of online searches nearly doubling. Although they've been around for over thirty years, it's only recently that they've earned the title of the Hottest Product in BBQ.
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.
Right off the bat I could tell this smoker was made in America! While putting it together the holes actually matched up! ATBBQ- beat the 5-6 week lead time and delivered in two weeks out to California. This thing is a beast- the heavy weight I was looking for in a smoker and it has the most consistent temp I have ever had with a pellet grill. I messed up on the first pellet grill that starts with a "T" and should have started out with the Yoder YS640. If you are on the fence or wondering if it's truly worth the cash. All I can say is yes...YES it is. Pull the trigger and order this now- you won't be disappointed. I don't work for Yoder or ATBBQ- I'm just a experienced BBQ'r that could not be happier! Thanks Yoder and ATBBQ,
Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?

Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!

To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.

I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.

×