Consumer-level Traeger grills are considered a mid-range type of pellet grill, so they’re good for those wanting to try pellet grills for the first time. Traeger models like the Lil’ Tex Elite 22 or the Tailgater cost several hundred dollars and can grill about 12 to 16 burgers at a time. Larger Traeger grills will generally carry low four-figure prices, such as the Pro Series 34 or the Select Pro, which can hold 32 to 40 burgers between the upper and lower grilling racks.

Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.
Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.

Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.

With the internal temperature sensor, meat temperature probe, and a digital temperature readout, the PG24 pellet smoker takes the guesswork out of your cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The patented Ash Can Cleanout System makes clean up the easiest out there.


Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.

This heavy-duty top-notch grill and smoker has a total cooking area of 429 square inches, which is large enough for cooking around twenty burgers at once. If that’s not enough, it comes with a secondary rack of 144 square inches that you can use for smoking or warming. With a height of 32.5 inches, you can cook a variety of meats and foods to your heart’s desire.

The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.
© Copyright 2005 to 2018 by AmazingRibs.com. All text, recipes, photos, and computer code are owned by AmazingRibs.com and protected by US copyright law unless otherwise noted. It is a US Federal crime to publish or distribute anything on this website without permission. But we're easy! We usually grant permission and don't charge a fee. To get permission, just click here. And you don't need permission to link to us.
I purchased a Traeger Select Elite from Costco for both my personal residence as well as for my vacation home. I am now on the third grill at my residence. Traeger will tell you that they expect to offer Awesome customer service. I have replaced the auger assembly, the controller and now the fan. I can't get the grill up to temperature. Awesome customer service says it should be no problem. Just replace the _______ (fill in the blank). I don't think these people have ever seen a grill let alone use one. Costco (love their return policy) is about to get another one back. Am I too harsh to expect the product to perform as they say it will? I would think when you pay as much as Traeger thinks their grills are worth, that they should work out of the box. Well, quality control under the new management has gone to hell. Then they expect you to "try" all the fixes that might work on your own. This is self service, not customer service.
Like with e-cigs and their gimmick of flavorful e-liquids, pellets for pellet grills and smokers also have different flavors added to their pellets, and they include bourbon, maple, apple, cherry, mesquite, alder, pecan, and hickory. You can mix flavors, change flavors, or use different flavors for every day of the week if you do everyday barbecues and grills for your restaurant or something.
Hi Brad! Thanks for your comment. I’d give Grilla Grills a hard look. Their Silverbac model is as solid as they come. The sear box on the Camp Chef is an interesting addition. Given that it’s propane powered, it would be pretty much light, turn and go. So, as you said, low maintenance. Still… with a set of grill grates, you should be able to get a sear at top temps on most pellet grills that would meet your expectations.

I am a pellet grill newby and a recent convert from the backyard charcoal grill to the Yoder YS640. After a ton of research on pellet grills, I jumped in the deep end with this grill and have won raving Family fans after four grilling adventures. I have never cook ribs...tried three racks using a special rub and several ours on the Yoder...and my wife who isn't fond of ribs was eating the left overs the next day! This grill is easy to use and creates fantastic tasting food. My only regret is that I didn't purchase the grill a lot sooner.


The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
You now know more about the perplexing pellet predicament, but where do you actually buy them?  Afterall, none of this matters if you cannot get them when you need them.  If you are lucky you have a local store that sells one of the brands mentioned above.  Definitely take the time to visit the web pages of these manufacturers and see what is available in your area.  If you are not one of the fortunate grill owners who live near an Academy Sports, Dicks Sporting Goods, Rural King, etc there is a chance your local Wal-Mart, Lowes or Home Depot may carry a reputable brand.
Final Verdict: If you have the capability to cook on this full-time, then I recommend doing so. You will save your kitchen and house from excess grease and smell. It can cook most items relatively fast and easy once you get accustomed to cooking on a flat top. The only thing it can't do is cook sauces or bake items. I even recommend it to folks who don't eat typical greasy foods. This requires very little oil and can use all sorts of cooking oil. All of my food dishes have been cooked well and I constantly have people asking about this flat top. Clean up is a breeze and will save you from needing to clean skillets and pans. This is an essential cookware that every household should have.
Compared with charcoal and other wood-fired grills, pellet smokers are simpler and cleaner and easier, giving more control than traditional smokers. Wood pellets are dense, burn hot and smooth, and can be easily fed into the flame with an automatic auger, allowing for consistent temperature with minimal effort. Many modern smokers let you practically set it and forget it, thanks to their digital controllers. Pellet grills are also efficiently cheap, often using as little as 1lb of pellets an hour.

Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.

Need Help?  Have a question or comment?1-888-827-4223Email UsGet Exclusive Offers & Expert TipsJOINTerms of UsePrivacy PolicyInterest Based AdsFor U.S. Residents Only © 2018 Ace Hardware. Ace Hardware and the Ace Hardware logo are registered trademarks of Ace Hardware Corporation. All rights reserved. For screen reader problems with this website, please call 1-888-827-4223 or email CareCenter@acehardware.com.
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
Therefore, for a reliable and consistent meal/ grill every time, go for the Traeger grill. It is easy to set and control the temperatures, thus the results are always as expected. Besides, a novice griller can master its use immediately, as it is a complete digital experience. On the same note, it can do a lot more than just grilling. You can use it to smoke, barbecue, braise, roast, and bake, all through the digital control system.
Whenever you want to smoke with a pellet smoker, you will have to make a choice: What type of wood pellets should I use? Well, the answer may sound simple – whichever flavor you like the best – but might be pretty difficult if you’re smoking for the first time. Unfortunately, the only way to know which flavor you like most is to try them all at least once and then decide upon which one floats your boat.

Craft amazing wood-fired creations with the Traeger Lil' Tex Elite 22 pellet grill. From grilled steak, to smoked ribs, and even a freshly baked apple pie, the set it and forget it ease of use allows any home chef to cook it all. Swap the gas and charcoal barbecue for 100% pure hardwood pellet flavor and grill, smoke, bbq, bake, roast, or braise a masterpeice.
As both a fuel source and flavor enhancer, wood pellets can affect everything from how well your pellet grill performs to how good the food tastes. And while one might assume that because all wood pellets look alike that they’re all the same, which pellets you use can make a big difference. These 6 tips will help you choose quality smoker pellets that will keep your pellet grill performing its best and producing great wood-fire flavor.

Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
Thanks Kevin. I am about to buy both a 5 burner gas grill and a smoker for a new bbq island. Rather than buy both, will one of these higher end pellet grills take the place of a traditional propane grill? I can apply the funds for the gas grill to a higher end pellet if it can really do double duty. It has to be able to cook burgers and dogs and steaks etc. Just like a gas grill though. Thoughts?
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.
12 Month Financing: For a limited time, purchase $599 or more using the Amazon.com Store Card and pay no interest for 12 months on your entire order if paid in full in 12 months. Interest will be charged to your account from the purchase date if the promotional balance is not paid in full within 12 months. Minimum monthly payments required. Subject to credit approval. Apply now.
The simplicity with which you can use this product is outstanding. From the time that you put it together to the time you smoke meat to the time you clean it, the entire process is extremely simple. It has a power failure restart and a dump tray that can easily be cleaned out. The cooking surface is so large that it is possible to smoke two turkeys at once.
Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.
A portable offering from Green Mountain Grills, the Davy Crocket is the most affordable pellet grill on our list, and the only one with WiFi capability. It’s compact, weighs only 57 pounds, and has folding legs so you can pack it up and bring it camping, tailgating, or to the beach. That’s something you can’t do with the Traeger Pro 22, and something we’re really excited about.
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.

Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.

I did a lot of research, and ended up buying the Camp Chef DLX24. It was at a price that fit my budget, (under $500) and had a lot of features the others didnt. The pellet trap door for quick dumping of the pellet hopper into a bucket, and the ash cleanout under the drum was a clincher. Being able to pull a lever and dump the ashes into an easily removable cup is a great feature that all grills should include.It has a digital temperature controller, and dual probes (one inside the smoker for grill temp, one for the meat) and overall good quality construction. The second shelf inside is standard (you pay extra for that on other grills). If your budget allows, would suggest purchasing the propane powered sear box ($199) which attaches to the side of the grill and allows for reverse searing meat..
The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.

An attractive option for many people are stainless steel pellet grills, which are rust-resistant, more durable, and easier to maintain. While pellet grills made from commercial-grade 304 stainless steel are the most desirable, they come at a higher. However, there are also some pellet grills made from 430 stainless steel, which is more affordable and still incredibly durable.
They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
Manufacturers advertise this piece of equipment as both a smoker and a grill, but it's best to think of it as a superb indirect-heat convection smoker, not a grill. Most models just don't do as good a job of searing a steak as a charcoal grill or even a gas grill with a sear burner can. You'll sear steaks better on a $20 hibachi than on most pellet smokers.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
×