Revising Product review to include photos! Excellent size and performs better than hoped for. Doe great job of smoking meats. Did a 12hr Pork Butt last weekend, tasty. Ran into a snag lately with the smoke stack though. Installed a aluminum patio cover over our deck $5,000. Now when I use my Traeger, the smoke has only a few feet to rise due to new roof over it. If windy, smoke billows in circles, trying to escape. And smoke will race into sliding door when opened. Experimented and came up with cure that works 100% excellent! Home Depot for 25ft roll of 6" Flexible Aluminum Duct. The 6" size goes over the hat on top of Traeger stack, pull down a few inches, wrap aluminum foil around bottom to seal. Other end over end of deck rail. Tried to keep as straight as possible, then trimmed to fit when expanded. Works like a charm and solved problem. Now smoke goes out end of 8ft long alum tube and out from under roofline, up into the air. No more smoke trapped under deck. With the flex alum tube, I can place it on East, West or North deck rails for smoke direction. Just thought I would pass this along as it did not effect the Traeger at all. Actually most likely helps with keeping air draft from entering thru smoke stack.
The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.

Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.
First, it’s really easy to use, with an electric auto ignition and shutdown system, plus LED controls that make setup idiot proof. Once it’s up and burning, the built in temperature sensor and meat probe make knowing what’s going on inside simple, especially considering that the thermometer is one of the most accurate I’ve seen, with only around 10 degrees variance. It’s got multiple settings if you’re using it as a meat smoker, as well, so you can control your flavor.

One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
Joe Traeger first introduced the concept of Pellet Grill in 1980’s. Pellet grills are a rage amongst backyard grillers because they can grill, roast and smoke all in one. Since it uses indirect electric heat, there are no chances for it to burn into flames, unlike a gas grill. It is the perfect cooking appliance for a novice chef, looking to experiment with different dishes. Which is actually one of the primary reason for its unbelievable popularity.
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
After owning this grill for six months I can honestly say I don't regret my purchase. I was waiting for low temp weather to really test this grill and i must be honest i was very surprised. I grilled 400 degrees with the outside temp at 38 degrees and the grill came up to temp within 20 minutes. Last night I started a brisket in 31 degree weather cooking at 225. No problem at all, and I haven't use a thermal jacket. We have done every thing from low and slow to baking and just have been amazed at outcome. Got a couple of more tests that i want to do, but six months, it's great. Stop thinking about it, stop worrying about the price, and prepare to make some great wood fire food.

This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
In addition, due to the wood pellets used in the Traeger grill, it is easy to cook different food products even pies, something that is impossible with charcoal or propane fired grills like the big green egg grill and the camp chef grill, respectively. Moreover, it is hard to get consistent results with the big green egg grill, as some food might come out good while others will just burn. It is a great challenge to use the big green egg grill.

Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.

One-Touch Non-PID Controller - Featuring a LCD display and one-touch buttons for setting the cooking temperature in 5° or 10° increments, these controllers allow you to more accurately set a desired cooking temperature. However, like multi-position controllers, they use fixed cycles for delivering pellets and so are limited in accuracy to +/-15–20°F. These controllers may have inputs for meat probes that monitor the internal temperature of food.
Accurate Temperature Control: The Davy Crockett has better temperature control that permits us to program a great deal more correct temperatures (one-degree changes possible) using their application (the control board permits us to alter temperatures 5 degrees at any given moment). It uses a PID controller […] controller to expect and fine micromanage the temperature by controlling the wood screw speed and the fan speed.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
Well, if you get yourself a wood pellet smoker not only you can enjoy such an event in the summer, but also continue doing the same in the winter. Today, pellet smokers often come with the “turbo heating technology” that can help you fire up the grill even in the winter. Go get yourself a pellet smoker and don’t let something as trivial as seasons, limit your enjoyment. Because a smoking warm piece of marbled, top quality fatty meat is best enjoyed on a cold night.
just received my new YS-640 two weeks ago and I absolutely love it. The shipping process and delivery was just as described. The delivery guy unloaded it off the truck, and wheeled the pallet into my garage. Everything was perfect. I am very impressed with the build quality...this thing is a tank. So far have smoked ribs and a brisket, and grilled chicken breasts. The grill heats up much faster than I expected. Temperature holds very steady over the long cooks. I love having the built in probe ports. Still figuring out and tweaking the baffle to control different cooking zones. Only negative thing I say is it can be difficult to manouver in tight quarters because it's so heavy and only the small caster wheels turn. So if you need to move your smoker around a lot, consider the comp cart.
So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
I store it in the Camp Chef cover. It takes about a minute to pull the cover off, install the gas cylinder and side tables, move it into cooking position on my deck, and light the burners. It doesn't take much longer to clean up. After getting the griddle back up to high temperature for cleaning, the active work of squirting, scraping and wiping down takes just a couple of minutes. After cool down, removing the gas tank and side tables (which fit nicely on top of the griddle for storage) and putting the cover on takes another a minute.

Any retail store that you visit, regardless of the product you are intending to purchase, has a supply chain that these products go through before reaching their final destination. There are certain costs associated with getting the product from the manufacturer to you that get tacked onto the price tag of the product. These additional costs can include aspects such as transport fees, warehouse handling, packaging, and display. Therefore, the price tag you see when the product reaches you isn’t just covering a small margin on top of the absolute base price of the product. It has been marked up to cover the additional costs listed above in order to reach you.
Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
I called Treager the next day just to find out what happened.  The customer service guy way REALLY nice.  He said, "Don't worry.  We stand behind our product 100%."   Wow was I impressed!   He told me he would email me instructions on how to make a claim.   He even told me he would send me a new thermometer ( my Christmas present one was destroyed by the fire).   He did everything as promised!
When you are looking for a smoker, one of the features that you want is to be able to control the temperature. This means that you will be able to use both a high and low temperature for smoking everything from poultry to fish to beef to vegetables to cheese. This is exactly what you get with the Camp Chef. It has an LED digital temp control system that comes with a food probe made from stainless material.
With the summer right around the corner, it’s about that time of the year that consumers are thinking about hosting outdoor picnics and having their friends and family in the backyard. Now, to make this year special, many people are flocking towards purchasing pellet grills. In efforts to assure our readers that each grill on today’s list is the absolute best, we performed an update on this buying guide. Included in this update, readers will get to learn about the criteria that we used to evaluate each grill and a list of answers to some commonly asked questions. Before the summer arrives, check out this update!
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
I spent a lot of time researching smokers before committing to the 640. I wanted something that can basically be left alone, produce good results and be durable. The 640 meets and exceeds those goals. It is built like a tank, and weighs about as much. I needed two people to help me assemble and move it. Assembly was straiightforward and took about 90 minutes. I have about 4 cooks on it and cannot be happier with the results.
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.
A: As one of the most frequently asked questions, consumers want to know if the grill comes with a grill cover to protect the grill. With that said, most brands do have a grill cover when it comes to the grill. However, it is important to always as the manufacturer if they include a grill cover with the purchase. In most cases, the grill cover is made from some of the best materials in the industry for durability and functionality.
When people talk about pellet flavors, they're referring to the type of wood used to make the pellets. Smoker pellets come in an array of wood flavors, from the usual BBQ suspects like mesquite, hickory, apple, and cherry to less celebrated woods like peach, pecan, , and sugar maple. Each variety has its own unique taste—from the mild sweetness produced by cherry to the nutty hints imparted by pecan—and can be paired with specific foods to highlight and complement their natural flavors. You can also create complex layers of flavor by mixing and matching different woods.
Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.
I am a pellet grill newby and a recent convert from the backyard charcoal grill to the Yoder YS640. After a ton of research on pellet grills, I jumped in the deep end with this grill and have won raving Family fans after four grilling adventures. I have never cook ribs...tried three racks using a special rub and several ours on the Yoder...and my wife who isn't fond of ribs was eating the left overs the next day! This grill is easy to use and creates fantastic tasting food. My only regret is that I didn't purchase the grill a lot sooner.
A: As one of the most frequently asked questions, we can see why individuals are interested in this question. The lid material depends on the manufacturer. However, we have commonly seen that most brands use a steel lid that is powder coated or a stainless steel lid that is reflective. With that said, individuals can expect that the will be very durable and hold in the heat of the grill very well.
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
Yes, no one likes to read the instruction manual. But there are many advantages of learning the specifics of your grill and reading the manual is key. Generally, you should not use water to clean your pellet smoker, so keep your hose pipe far away. These smokers have digital controllers, a motorized auger, a fan and an igniter rod for the fire pot. These parts will get destroyed if they come into contact with water. You should gently dry scrub the dirt off these parts, making sure not to disassemble any parts. Cleaning the thermostat will also prove to be essential; otherwise, it may read internal temperatures inaccurately.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.
Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more

Professionals: the pellet smoker has emerged as the best option for beginners. However, that does not mean that a top grilling expert will not benefit from using it. Using a pellet smoker, the professional can turn normal pork into a mouth-watering dish with any kind of flavor. The precise temperature control will help any professional make the dish more accurate. A top pellet smoker can display some delicious magic that will prove unforgettable.
Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.
Do not confuse a pellet grill for gas grills. Like the name suggests, a pellet grill obviously uses pellets for cooking its food. But do not doubt its competence with any other gas or convection appliances. It cooks just as well, if not better. And the secret to this are in its pellets. While pellets vary from brand to brand, the best ones have more wood and less binders like sawdust etc.
A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
×