My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.


Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
Or the fact that it lives up to its “Ultimate Tailgating Grill” moniker for all you campers out there. You need to watch your roast closely so you won’t have to finish your pork butt in the oven. It’s not quite a “set it and forget it” kind of smoker grill because you still have to make sure that there’s a steady supply of pellets so that it won’t shut down.
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
Recently bought portable Traeger ptk+ smoker as camp a lot. Food is amazing though grill size better suited for 2-4 ppl and you can’t fit a large roast. However cooked a rack of ribs, several chickens and burgers. Food comes out amazing. You do need electricity hookup camping and it drains too much power to run off cars dc socket. $300 and of you call them to order v online they will throw in free weather cover free shipping and some rub. It does take up some room in car so beware if you have tiny vehicle. Buyer beware racoons love smoked food so remove your trash bag with bones from campsite before retiring, as we found out the hard way
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?
My brother said his Traeger blanket saved pellets in cold weather, so after talking to him I decided to order one. Used it for the first time today. The blanket went on easily & fit the grill perfectly. The temps this a.m. was below 0 when the meat started smoking. So far so good! The grill hasn't extinguished itself, a problem we always had when cooking in the cold, the temp of the grill is cooking like it does in the summer, & the meat is smoking beautifully. If you Traeger in cold winters this accessory is a must have!
So which pellet smoker is worth your hard-earned dough? We've put together a list of the ones we think make the cut, organized from lowest to highest price. Sorry for the sticker shock—even a low-priced pellet smoker will cost more than many grills, and our first selection lists at $333. These motorized, digitally controlled devices just plain cost more, but believe you me, they are worth it! And all of these selections have won the AmazingRibs.com Best Value Gold or Silver Medal.

At Grilla Grills we know it’s important that our customers get bang for their buck. That’s why you never see a Grilla pellet smoker on sale – because we can’t price them any lower! Keep that in mind when you’re comparing prices for your next grilling purchase. We don’t deal with a middleman so we can offer the highest quality grills for sale that are half the price and every bit as good as some of our competitors. That’s how you know you’re getting a good value when you decide to purchase a pellet grill Jungle Direct from Grilla Grills. The best part? Shipping is free and we’ll deliver your new pellet grill right to your front door. It really can’t get any better than that.
Yoder pellet smokers maintain a very strong reputation for quality and precision. Based out of Hutchinson, KS, the company prides itself on producing a 100 percent Made in America product that is one of the sturdiest and most reliable brands of smokers available. Check out this Yoder Smokers promo video to get an idea of how they are branding themselves.
The Memphis Pro Wood Fire Pellet Grill is one of the best pellet grills on the market. It combines high-quality construction and engineering with versatile cooking capabilities that will let you "grill" almost anything. Able to reach temperatures out to 650 degrees F. this pellet grill can sear a steak while also being able to hold temperatures down to 180 degrees F. so it can smoke, low and slow, any kind of BBQ. Add to this the convection fans and temperature control precision this wood pellet grill can rival the best indoor ovens. This truly is a grill that can do it all and give you an authentic wood flavor.
The Camp Chef SmokePro is probably the best pellet grill on this list by rating and by performance. It has a decently large area for cooking at 19.2 inches by 22 inches plus its smoking or warming rack is also 6 inches by 24 inches in size. This is one of the best pellet smoker for home use because of its combination of quality features that are never superfluous and works as advertised.
Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.
On the better models, a temperature probe in the oven area tells the controller what the temperature is and if it is below the target it tells the controller to feed more pellets and air. The best manufacturers, like MAK and Memphis, have designed their own versatile custom controllers that are easy to use and can hold a temperature within 5°F, tighter than many indoor ovens.

If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.

Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
Convert your stove into a powerful barbecue grill. Convert your stove into a powerful barbecue grill. This barbecue grill box is sure to win you over to Camp Chef's savory outdoor flavor. Features a reverse-louvered plate to vaporize grease drippings while distributing heat evenly over the cooking surface to create a more flavorful cooking experience. Cast iron grates ...  More + Product Details Close
The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile cooking options and thorough heat distribution in a compact space. The removable middle section offers grilling and smoking functionality. This smoker offers a maintenance free cooking experience with a high capacity galvanized steel charcoal and ash chamber. For easy internal access simply ...  More + Product Details Close

For a large-sized smoker, the Camp Chef SmokePro SE delivers excellent, smoky-tasting flavor that even beginners can accomplish. This is largely due to its automatic temperature control features and grease management system, allowing you relax while it cooks for you. With minimal cons (only weight and pellet price), this is a definite hit among professionals and newbies. The SmokePro SE is an unquestionable bang for your buck kind of purchase.

Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
There is no party like a backyard grill and BBQ party on a hot summer weekend with some good music on the back, and of course the centerpiece: the food. You see, food is a universal language. It is a way to say how much you appreciate and care for one another; a way to people’s hearts. And there is nothing more comfortable, warm and heart than some good old open grill and BBQ cooking on your pellet grill. And this is the reason you need an expert pellet grill review. 

PID Controllers - The most sophisticated type of pellet grill controller, PID controllers use complex algorithms to achieve and maintain the desired temperature within a few degrees. They, too, feature LCD display and one-touch buttons for setting the temperature in 5° increments. However, unlike controllers that use fixed cycles, a PID controller continuously measures the grill’s temperature then adjusts its cycle, adding pellets when necessary to hold the correct cooking temperature throughout the cook. Because they’re more sophisticated, PID controllers can accommodate programmable meat probes that have the ability to automatically lower the grill’s temperature when food is done.

The hook rack works great and is a must. The Towel holder works ok but does not work well if there a some wind blowing by. Wants to unroll the towel just enough to make it a possible fire hazard by the gind unwinding the towel rool enought that it can flip up over the wind gaurd and get in the flames. I have to remove it from the camp stove if there is any wind to avoid this problem.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
Competition: If you are buying a smoker for participating in any competition, then pellet smokers are your best choice. Gas or electric smoker grills are not allowed in any competition as they are using automation. Though you are getting temperature control and electronic start in pellet smoker it is accepted in competition. This pellet smoker review will point out the ones best for a competition.
After looking at a lot of pellets smoker grill reviews, it is easy to see that this is a pretty decent model. It is just so functional. So if you are looking to purchase something that is more than a pellet smoker, this is the product for you. Make sure to follow the instructions carefully when assembling it and be sure to gauge cooking time since this is a fast one.
If you can use an indoor slow cooker If you can use an indoor slow cooker you can easily amaze everyone with authentic smoked recipes. This Stainless Steel Double Grid Electric Water Smoker from Meco includes a 5.5 Qt. hydration pan to fill with beer juice wine soda sake water or other beverage so your smoked delicacies stay ...  More + Product Details Close
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.
I bought this directly from Traeger. Beware that this model is now discontinued. They replaced it with the Traeger Renegade Pro without notice. The new model has an updated saw horse design and a new digital controller with probes. It does not come with the handy spice rack however. To each their own but I'd check with Traeger prior to purchase. That said, I paid more from them so if this is discounted, grab it. I love mine!
The online research, the model comparisons, the pricing—choosing the right pellet grill can be challenging, so much so that, by the time you settle on a grill, choosing smoker pellets often becomes an afterthought. While some people simply default to the wood pellets sold by their pellet grill manufacturer, too many others settle for the cheapest pellets available. Because, really, how much difference can the pellets make? A lot, actually.
How much food are you going to smoke? This is important because some of the top pellet smokers are relatively large. And if you’re not looking at smoking a lot of meat, you might purchase a unit that’s too big. Conversely, if you buy a unit that’s too small, you are going to be frustrated because you’re going to make some delicious meat just not as much as you need.
What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).
We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
One final word of caution when it comes to pellet pricing.  If you see a price on pellets that seems too good to be true, there’s probably a reason for it. If the pellets you got an amazing deal on creates twice as much ash, doesn’t burn as well, generates wild temp swings and ends up ruining a $65 brisket were they worth it?  What about if that flame out or temp swing cost you a whole pit full of meat and ruined the family reunion the next day?  We are all for saving money as much as anyone, but perspective is key here.  We are in no way saying that great pellets cannot be had for pennies per pound, but we are definitely saying, that if those pennies saved are not on a proven brand that you can trust then it’s probably not a bet worth taking.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.

A: This may be considered the million-dollar question for many reasons. When it comes to a pellet grill, individuals have to clean it out a bit different than a regular grill because there are unique elements to clean. Many individuals recommend cleaning a grill after every use depending on the size. However, for larger grills, it is recommended to clean it after four or five bags of wood pellets. Now, what you do is vacuum out the ashtray. Some brands do have an automatic ashtray cleaner. If not, then you have to vacuum it out with a vacuum. Other aspects to clean include removing the grease drain pan, removing the porcelain grills, the heat baffle, and properly washing with warm water and a bit of soap. Most brands will have cleaning instructions in the guidelines.
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
×