I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
Bought a Traeger Timberline 850. A lot of money but it's a great smoker. It has WiFire so you can cook based on their recipes right from your iPhone. The problem is with their recipes that aren't built into their app. Nobody proofreads the things so many of them are useless. Just one example - Santa Maria Tri-Tip: smoke for 4-5 hours. At what temperature? 165 F, 250 F, or 500 F? It makes a bit of a difference ! I suspect they pay people to write, and post recipes so the can say they have thousands of (what are actually useless) recipes.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
The initial design by Mr. Traeger consisted of a “classic” drum barrel shaped grill design with a chimney on top. Instead of the firebox, the grill contained a pellet hopper. It used a fan to distribute the heat evenly over the pellets. Unlike the modern pellet grills, the original design didn’t include any auto-ignition features and the pellets had to be lit manually.
Operation of your Pit Boss Deluxe Wood Pellet Grill is easy. Simply load the pellet hopper with your favourite all-natural hardwood pellets and turn the dial to your desired pre-set temperature. Within minutes, the grill automatically lights the pellets, and adjusts itself to your desired cooking temperature between 180° to 500°F. The grill can maintain that temperature all day, granted there’s always pellets. It’s that easy. Experience real wood-fired flavor with Pit Boss.
It offers 700 sq. in. of cooking space and a powerful thermostat for a higher price, but makes up for it as soon as you start cooking on it. Also, it has a stunning design with the bull horns, which sets it apart yet again. But if you find yourself not spending as much and could do with a lesser cooking space, then the Camp Chef PG24 is a no-brainer for you.
As a new and nervous cook or just a busy one, it is always a struggle to get the results you want without having to tend to a grill or stovetop all day long. Luckily, Pellet Grills offer a convenient solution. These foolproof devices allow you to truly set it and forget it. Whether you crave perfectly grilled spare ribs or smoked pork butt, Pellet Grills allow you an unprecedented degree of control over the temperature and cooking style you want. What’s more, Pellet Grills are a terrific way to infuse your food with the real flavor of wood smoke, whether it be hickory, mesquite or maple. Unlike gas grills, the flavor is right there in the fuel with wood-pellet grills.
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
It doesn’t matter what it is that you’re buying, you want to get the best bang for your buck and not pay more than you have to. We all have this same mentality when it comes to making a purchase. This is why when we see price tags that indicate something is “on sale’, we immediately think we are getting a good deal. But is that really the case? The answer is no. When it comes to buying your new pellet grill “on sale” from a distributor or retailer, it means that they are essentially reducing the markup that you have to pay. Aside from the rare instances where a retailer is selling a product as a loss leader where they are intentionally losing money on a product to get you into the store and buy other more profitable products, you will still be paying more money in the end than what the manufacturer would price the grill at if they were to sell it to you directly.
Hi Brad! Thanks for your comment. I’d give Grilla Grills a hard look. Their Silverbac model is as solid as they come. The sear box on the Camp Chef is an interesting addition. Given that it’s propane powered, it would be pretty much light, turn and go. So, as you said, low maintenance. Still… with a set of grill grates, you should be able to get a sear at top temps on most pellet grills that would meet your expectations.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.
Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
†Advertiser Disclosure: Many of the card offers that appear on this site are from companies from which CreditDonkey receives compensation. This compensation may impact how and where products appear on this site (including, for example, the order in which they appear). CreditDonkey does not include all companies or all offers that may be available in the marketplace.
I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods! 🙂
Second, It would be just my wife and me BBQing so I’m looking small. I’m considering the REC TEC Mini Portable Wood Pellet Grill (RT-300) after reading your reviews. Having only ever BBQed with hard wood coals on a Webber, is there going to be a taste fall-off going to the pellet grill as far as charring and/or smoke? I’d hate to spend that kind of money and get bland steaks. Really, steak is all we ever cook outside, though that would probably change with a nice grill.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~
What’s more, as Pellet Grills are electric-powered and regulate their own fuel intake, they are a far more foolproof option than other smokers and grills which may require a large amount of maintenance and care during the cooking process. Wood pellets themselves are also incredibly versatile. Aspiring smokers can experiment with a whole array of wood varieties in order to explore the flavors that each lends to meat.
The original Traeger Grill was invented 30 years ago and was every bit as impressive then as it is now. Although it developed a cult following, the early Traeger never grew beyond a niche product. In the past two years, however, Traeger has stepped up its game, redesigning and upgrading its grills while doing everything it can to build a buzz around its amazing do-everything cookers.
And #3, good bbq or grilled meats should taste great without a ton seasonings or sauce. Beef especially can be excellent with simple salt! Make sure your seasonings enhance flavor. Another great read, the late (and much grieved at our house) Paul Prudhomme’s ‘Louisiana Kitchen’ again available on Amazon used for a couple of bucks and a masterpiece! Paul was a master of seasoning. Don’t kill it with seasonings and sauce, enhance the foods flavors. Barks on meat are great if they are right. However burnt, sugar and many other seasonings detract from the meats natural flavor. I personally love a meat you can eat without a sauce and then sauce if you want some added flavors going on!
I id not purchase this item from Amazon, a local retailer had them on sale but none the less this a great smoker at any cost. I have compared it to the far more expensive smokers and I have found that this one has a much stronger, better built main body. The metal is of a heavier gauge of steel. Cheap smokers are separated from more expensive ones a lot by the electronic controls. Tis model has a control from 160 degrees up to 500 in 25 degree increments. It maintains a constant temp within a few degrees of where it has been set, always a problem on other smokers not of the pellet design I have used. Pellet consumption is modest and the Camp Chef brand pellets are the cheapest I have found. and work extremely well The ash cleaning system is a matter of dumping a cup after use with very little ash left over. The grease trap system is perfect. I see no reason to spend more for a pellet smoker that couldn't perform any better than this one. I would recommend it to anyone in the market for one. They are a set it and forget way to do your smoking.
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
Speaking of competition cooks, you’ll find that many competition BBQ pitmasters who use Pellet grills as their primary means of cooking are among the more well rested come Saturday. The next step we’ll cover in this selection of Pellet Grill Reviews is getting your pellet grill / smoker up and running. Again, what you may not see in may Pellet Grill Reviews is repeated mention that you’re not going to get that “deep smoke” flavor profile using a pellet smoker. Though, this can be achieved by using something like the Amazen Pellet Tube Smoker 12″.