Purchased the YS640 about a month ago. So far I have cooked nine pork butts, three racks pork back ribs, one beef brisket and four thick cut New York steaks on it. I am very pleased with the results of these cooks. I have an upright propane smoker, Weber kettle, propane grill and so far the YS640 has out performed all three of those in ease of use and flavor performance. I can get almost the same flavors with my others, but takes more work and babysitting. Also want to mention that the YS640 is built to last. I noticed the ruggedness and excellent USA craftsmanship immediately upon arrival. Some reviewers think maybe the YS has a steep price, but I think its justified due to its construction and craftsmanship. It would be difficult to make something of this caliber for any less. A couple minor things to note is you will have to play with the damper a bit to learn the heat distribution, but after learning it, its not a problem. Doesn't put quite as strong as a wood flavor on the food as my upright propane smoker, but it puts the right amount and I have no complaint here. I would and have already recommended the YS640 to friends and acquaintances. If you have spent long hours smoking foods and know the correct flavors that they should be, your not going to be disappointed with this cooker!

This grill is mounted on a bracket with a sawhorse design with wheels that provide it mobility in all terrains. It has a steel construction with a powder-coated finish, giving it a great look and a sturdy body. It has a hopper capacity of 18 pounds but it’s enough to continuously cook and smoke food in its 380 sq. inches of cooking area. Its porcelain-coated grill grates give you a no-rust and non-stick cooking experience that you won’t forget.


Built from substantial stainless steel, the SmokePro looks bombproof and weighs a hefty 140 lbs – so it’s not portable like the Z Grills or Traeger Junior Elite. It has a stainless-steel probe to directly monitor meat, and a sensor for the grill’s internal temperature. Both read out on the LED display next to the digital controller, which goes from 160F to 500F in 25-degree increments.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
There is no doubt that grilled food tastes better, especially if it is done with wood pellets. This is because it retains the smoky flavor of the wood pellets. However, there are always health concerns when it comes to meals that are grilled. The main issue is always the animal fat, which burns, resulting in the formation of heterocyclic amines, HCAs. This harmful chemical is a known cause of cancer as it easily fills the smoke that permeates into your food.
Now, for the good stuff: do not hesitate to spend an extra or even two bucks for a feature that you will use and appreciate. Consider your pellet grill as an investment, something you are going to buy, and be using and enjoying for years and years to come. Features like meat probes to check the internal temperature of foods are excellent for taking the guess work away from cooking meat to a particular doneness. You will never end up with an overcooked and rubbery, or undercooked and raw steak ever again! Features like smartly designed grills that consume and spread heat evenly are also great for cooking food to perfection without having to move it from side to side to find the right temperature spot.
If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.
Traeger Junior Elite Pellet Grill is a great model for those who want to start up the smoker, add some meat, and let the work be done for them. It is also extremely versatile, allowing you to grill, smoke, roast, and bake. It is perfect for individual households, college students, and even tailgating. And it’s a great option for first timers as well as those who have experience using pellet smokers.

As far as backyard cookers go, Pellet Grills are the newest products on the market. With their roots in the 1970’s, these versatile outdoor grills combine the capabilities of a traditional grill, with the wood-fired flavor of a smoker, and even the convenience of a modern oven. The “Pellet” in the name refers to the specific variety of fuel used. These are specially made cylinders constructed of compressed sawdust. The grill is powered by electricity and doles out specific amounts of pellets to maximize fuel efficiency. The primary benefit of these types of grills is their versatility. Wood pellets can be burned at all different temperatures and volumes, making it possible to sear, smoke, or slow cook a whole array of meats in an infinite variety of styles.
While the Traeger Lil-Tex does offer similar features as our top pick, such as a digital LED temperature control system and an auto-dispensing auger, there was one missing feature which we thought was necessary. This product has a smaller grilling area and lacks a removable upper rack, which gives you less grilling and prep space. I should mention that the unit does come in a bigger 700 square inch version for $200 more, as well as a smaller version that costs less. If this smoker is too big or too small for you, there are always other options available. Compared to our top pick, it’s also more expensive despite offering similar specs. Aside from that, this is a very efficient and reliable smoker – might even have been the best if our top pick wasn’t available on the market.
Due to having such features and being the best Lousiana Grills Product, the Louisiana Grills LG Pellet Grill 1100 could not escape our vigilant gaze when we did our research. However, it had some shortcomings, mainly due to its build and price that did not allow it to make it into our pellet smoker review. Regardless, we could compare it with some of our products that it had tied with. But as always, we could only choose the top 10 products for this review and this had to go. Regardless, this still is a great product, worth mentioning.
Final Verdict: If you have the capability to cook on this full-time, then I recommend doing so. You will save your kitchen and house from excess grease and smell. It can cook most items relatively fast and easy once you get accustomed to cooking on a flat top. The only thing it can't do is cook sauces or bake items. I even recommend it to folks who don't eat typical greasy foods. This requires very little oil and can use all sorts of cooking oil. All of my food dishes have been cooked well and I constantly have people asking about this flat top. Clean up is a breeze and will save you from needing to clean skillets and pans. This is an essential cookware that every household should have.

Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.
Hey DS – You’re dead on correct re: Grilling vs. Smoking. Most to nearly all Pellet Smokers are used as “smokers” in the truest sense. Louisiana Pellet Smokers boast a direct fire feature for grilling, as do Yoder smokers. However, I’m with you in that a grill is a grill and a smoker is a smoker. GMGs are very popular down here on the FBA circuit. However, most folks do find that they don’t produce the amount of smoke preferred for competition meats (which, in truth is a complaint about many pellet smokers). This is why stick burners and “some” gravity feds get a boost in rep among competition cook teams. That said, I do see folks happily using pellet smokers, and some win with them. One “trick” I see used now and again to boost the smoke output on a pellet smoker is to use one of those smoke tubes… like the A-maze-n Tube Smoker. Thanks for your comment, and for stopping by to read this blog post! – Kevin
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
It may have taken a few years to catch on, but it’s hard to dispute that pellet grills are here to stay.  Pellet grills are easily the fastest growing segment in the grilling industry.  This has left many new pellet grill owners with a few questions concerning pellets.  Chief among them “what constitutes a good pellet?”   Second, “where can they find pellets to fuel their prized grill?”
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.

Featuring a cast-aluminum rust resistant burner this stove Featuring a cast-aluminum rust resistant burner this stove is a versatile all around cooker. Perfect for any of your cooking needs from boiling and frying to Dutch oven cooking. Its compact size and portability make this stove a great side companion to add cooking space to your outdoor kitchen. Great ...  More + Product Details Close
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
If you’ve ever wanted an 8 in 1 wood pellet grill that you can just “set and forget”, then this grill makes a perfect unit for you. It was the best smoker we’ve used in terms of hassle-free use which is why it had to be one of our top picks. Digitally-controlled, this smoker ignites the unit and uses a Smart Smoke Technology™ to heat it up from 160 to 450 degrees F. This pellet smoker comes with 513 square inch grilling area, plus a 2nd cooking rack! While it doesn’t have any auto/one-touch cleanup system, its auto-shutdown feature makes it worth the value.
Second, It would be just my wife and me BBQing so I’m looking small. I’m considering the REC TEC Mini Portable Wood Pellet Grill (RT-300) after reading your reviews. Having only ever BBQed with hard wood coals on a Webber, is there going to be a taste fall-off going to the pellet grill as far as charring and/or smoke? I’d hate to spend that kind of money and get bland steaks. Really, steak is all we ever cook outside, though that would probably change with a nice grill.
I've had it for right at a year as of the time of this review, and I absolutely LOVE IT. Normally I am of the opinion that you should overspend to get the better product, but I am 100% satisfied with the SE. I've gone through almost 200# of pellets in a year and I've successfully smoked three briskets, pork in various forms, a bunch of whole chickens, salmon, and probably some other thing I'm not thinking of. The show-stopped for me is bacon-wrapped dove breasts. I smoke them for an hour and then finish them on my grill. They are out-of-this-world amazing.

The Camp Chef PG24S lets you set the smoker to your desired settings so you can leave it to relax while it does the rest for you. With an advanced digital temperature chip, it steadily monitors the temperature, achieving a constant cooking temperature at all times. Dual LED temperature displays allow you to easily check the temperature of the food kept inside your smoker without losing any heat. With an auto-dispensing pellet hopper that can hold around 18 pounds, your pellets are used efficiently. The grill can work in temperatures that range from 160F to 400F.
The Green Mountain Grills Davy Crockett is a versatile, wood-pellet grill that is intended for portability. Regardless of its weight, it’s about as minimized as you can get, and takes care of business. Contrasted with more costly wood pellet barbecues, it appears to hold its own on performance, while the one of a kind Wi-Fi usefulness needs some finish.
A: As one of the most frequently asked questions, we can see why individuals are interested in this question. The lid material depends on the manufacturer. However, we have commonly seen that most brands use a steel lid that is powder coated or a stainless steel lid that is reflective. With that said, individuals can expect that the will be very durable and hold in the heat of the grill very well.
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
"The Camp Chef transaction aligns with Vista Outdoor's strategy to deliver long-term value through acquiring complementary, market-leading brands that will benefit from Vista Outdoor's balance sheet, distribution network, and sales and marketing expertise," said Chairman and Chief Executive Officer Mark DeYoung. "Led by an entrepreneurial management team, Camp Chef has a nimble and responsive product development process. Camp Chef continues to grow its market share in the outdoor cooking category, and the brand serves many of our current consumers who are engaged in a wide variety of outdoor pursuits. Acquiring Camp Chef strengthens our leadership position in outdoor recreation, allows us to enter the growing camping and outdoor cooking market, and the brand's effective multi-product, multi-channel strategy increases our presence across both brick-and-mortar and ecommerce distribution platforms."
Keep your Pellet Grill and Smoker fired up Keep your Pellet Grill and Smoker fired up with Camp Chef’s Premium Hardwood Pellets. Made of 100% natural hardwood these food grade pellets are an excellent way to add that unique smoky flavor. Choose from 4 distinct flavors. Smokehouse Hickory impart a rich and smoky bacon-like flavor to all meats ...  More + Product Details Close
×