Most pellet smokers have a flat drip plate under the cooking grate that diffuses heat and catches grease and gunk. Louisiana uses a curved "Arched Flavor Guard" that mirrors the shape of the lid. The company claims that this design presents a larger surface for meat drippings to sizzle and enhance flavor. The Flavor Guard also has a section over the fire pot that can slide out of the way to expose large, slotted openings, which allow meats to sear over open flame.
Very often pellet grill manufacturer instruct you to use their pellets, with some going so far as to state that failure to do so will void the warranty. Why? Well, there’s the obvious reason that they want you buy their pellets. However, it really has more to do with ensuring that the grill runs properly, and that starts with using quality pellets. The easiest way for pellet grill makers to guarantee you’re using good pellets is to have you use theirs, which they know meet the desired quality standards. They can’t make that guarantee about another brand of pellets.

There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.
A pellet grill is an outdoor cooker that runs on electricity. It uses wood pellets as fuel to cook as well as smoke and flavor the meats. A pellet grill is a combination appliance of grills, smoker, oven and more. It can be used to sear, smoke, grill, roast and even bake! A pallet grill can be used to cook almost all types of meats and proteins. It also accommodates larger quantity and size than a normal indoor appliance. This is what makes a pellet grill so special, its versatility and convenience of use.
I id not purchase this item from Amazon, a local retailer had them on sale but none the less this a great smoker at any cost. I have compared it to the far more expensive smokers and I have found that this one has a much stronger, better built main body. The metal is of a heavier gauge of steel. Cheap smokers are separated from more expensive ones a lot by the electronic controls. Tis model has a control from 160 degrees up to 500 in 25 degree increments. It maintains a constant temp within a few degrees of where it has been set, always a problem on other smokers not of the pellet design I have used. Pellet consumption is modest and the Camp Chef brand pellets are the cheapest I have found. and work extremely well The ash cleaning system is a matter of dumping a cup after use with very little ash left over. The grease trap system is perfect. I see no reason to spend more for a pellet smoker that couldn't perform any better than this one. I would recommend it to anyone in the market for one. They are a set it and forget way to do your smoking.
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
I bought this grill in May 2018. Had to return it to Ace 9 days later because it wouldn’t keep temp or would go out and fill up with pellets. I had to have the GM of Ace fight for me to get a new grill from Traeger. Once I did the new one seemed to work for about a month. Since then this one does the same thing as far as heat and pellets. I thought this thing was supposed to be a set and forget grill. If I don’t watch the heat it will be 200+ degrees over the set heat or sometimes be at ambient temperature and I have to pull me meat, grill and grease tray out so I can empty the heat pot of all the Unburned pellets. This thing is nothing but trouble. Does it cook great meat? Yes! When it works and you babysit it the whole time. On top of that customer service is about as useless as ** on a boar! They will try and tell you it’s something you’ve done wrong. I will be buying another brand smoker and giving this one to someone who like to deal with troubles.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.
Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
Convert your stove into a powerful barbecue grill. Convert your stove into a powerful barbecue grill. This barbecue grill box is sure to win you over to Camp Chef's savory outdoor flavor. Features a reverse-louvered plate to vaporize grease drippings while distributing heat evenly over the cooking surface to create a more flavorful cooking experience. Cast iron grates ...  More + Product Details Close
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)

I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 


12 Month Financing: For a limited time, purchase $599 or more using the Amazon.com Store Card and pay no interest for 12 months on your entire order if paid in full in 12 months. Interest will be charged to your account from the purchase date if the promotional balance is not paid in full within 12 months. Minimum monthly payments required. Subject to credit approval. Apply now.
Today, all serious players in the pellet smoker market have switched to digital thermostatic controllers that dictate pellet-feed commands based on a temperature sensor inside the cooking box. Just like with the oven in your kitchen, you set the desired cooking temperature, and the heating system kicks on and off to maintain that set point. An LED display shows your set temp, and most models allow you to toggle between set temp and actual temp readings from the internal thermostat. Actual temperatures will fluctuate a bit as the controller switches on and off to hover around your set temp, but many sophisticated touch-pad controllers can maintain tighter tolerances than your indoor oven. Some pellet controllers also have integrated probes that let you monitor the internal temperature of whatever you're smoking. Wireless remote control and monitoring from your smartphone or tablet are also increasingly common. (You can learn more about pellet smokers on AmazingRibs.com.)

If you have faced or currently face the problem with common things like pellet feed jamming or wear and tear of your smoker, then replacing the exact component will solve your problem. Thus, without changing your whole smoker you can continue with some $40 – $50 changes. It might seem complicated for you if you face a problem with your digital control system. Adding the element of professional knowledge will help tremendously. Solving problem with $150 is much better than spending $500, right?

Traeger wood pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger’s wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
So what about the question of blends versus 100% pure species pellets?  Should you avoid blends?  Should you only use 100% pure?   That is a web to unweave and depends greatly on what you are cooking as to the correct answer.  Through our testing we found many blends to work very well.  We liked them so much that we incorporated them into what we offer.  Not all blends are created equal though and the amount of hardwood versus flavor wood varies widely across brands.  We also found that some 100% pure pellets such as cherry and apple had harder times reaching higher grilling temperatures and lacked the harder core flavor punch of hickory or mesquite.  Coming from the world of stick burners many new pellet grill owners assume that going 100% cherry or apple is going to work for them since that is what they have grown accustomed to.  At the end of the day, they end up moving to a pellet with a deeper flavor like hickory or mesquite to get the results they are used to.
I’m not sure of the dates on the above replies, its now Oct.2017, and I’ve had enough of the Bradley dig. smoker. I live on Long Island NY and the Bradley has trouble getting up to and holding temp. I’ve added a PID to it but have decided to take it up a level. I’ve done a bunch of research and I’m leaning toward the Yoder 640 with Comp. cart. unless you take me out of it. What would you be spending your money on today? I did buy a book though your site, I hope that helps.
I have always been a believer: “do what you love and you’ll never work a day in your life”. I’ve been lucky enough to use my professional experience in the meat industry over the past 20 years to create a business where I love to go to work. Smoking Meat Geeks is all about bringing people together that enjoy food as much as I do. We provide a place for everyone to share thoughts, ideas, and recipes; to be a go-to spot for cooking inspiration. Feel free to leave a comment, say hello, or provide any tips. There is no right or wrong input, as long as you’re engaging, you’re a Meat Geek!
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
×