The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at firstname.lastname@example.org. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
I ordered a thermostat for my Junior Elite grill because service said that was most likely the problem with my 4-year-old Traeger grill. I was promptly charged on my credit card. The order did not get to me and 2 weeks later, I emailed them. They said they would send out another thermometer. That thermometer has been making the rounds in 1/2 dozen post offices:
Ease Of Use – Check if the unit is anything but difficult to setup and work. A few units are a breeze to gather, and you should simply to take after the manual of guidelines that accompany it. And after that, you ought to likewise discover how to work the grill and it ought to offer you easily of operation. For the most items I have evaluated here, they can be worked with the push of a catch, so they will let you simply set the clock and temperature and forget about it.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
One of the fun features this grill offers is that it’s WIFI enabled (controlled or monitored through an iOS or Android app). Sense-Mate, a thermal sense that constantly monitors the grill temperature, keeps you up to date on the status of your grill and your food! The digital controlling really lets you micro-manage your cooking, as you can adjust it a degree at a time. You can also program a series of temperatures and then sit back and enjoy your day while your food cooks! (Yes, you can also control it manually as well.)
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
Thanks for the quick response and advice. I see a pellet pro hopper assembly is around $250 compared to the Memphis pro at over $2000. I didn’t realize that drafting isn’t important for the sake of temp regulation but what about how the smoke travels from the firebox towards the meat? I also would like to include an element of humidity, is simply putting a pan of water in the cooker or is there a better way?
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.
Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
So back to the Internet for one last attempt on making a decision on the smoker that is of great quality and can also fill my need grilling needs as well. I am almost sold on the Rec Tec, but I’m curious about the Grilla Grill Silverbac. It’s a little smaller than RT and metal is a gauge off from the RT. It doesn’t run off a PID system but a digital controller and is priced at $699. I do like the underneath storage of the Grilla and the second tier cooking grates.
I am a pellet grill newby and a recent convert from the backyard charcoal grill to the Yoder YS640. After a ton of research on pellet grills, I jumped in the deep end with this grill and have won raving Family fans after four grilling adventures. I have never cook ribs...tried three racks using a special rub and several ours on the Yoder...and my wife who isn't fond of ribs was eating the left overs the next day! This grill is easy to use and creates fantastic tasting food. My only regret is that I didn't purchase the grill a lot sooner.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
PID Controllers - The most sophisticated type of pellet grill controller, PID controllers use complex algorithms to achieve and maintain the desired temperature within a few degrees. They, too, feature LCD display and one-touch buttons for setting the temperature in 5° increments. However, unlike controllers that use fixed cycles, a PID controller continuously measures the grill’s temperature then adjusts its cycle, adding pellets when necessary to hold the correct cooking temperature throughout the cook. Because they’re more sophisticated, PID controllers can accommodate programmable meat probes that have the ability to automatically lower the grill’s temperature when food is done.
For example, many grills use and charge for collaborating with a software application on it. I, personally, think this is an absolutely silly feature to include on a pellet grill. Yes, it does start on and off from your phone and change temperatures while you are at Switzerland enjoying Swiss cheese on a lake, but really, is it even logical? I mean, pellet grills have already made the cooking experience as easy as a dream, the least you can do is set the temperature by the click of a button on the appliance yourself! You can’t possibly be that lazy!
Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.
A charcoal unit is going to provide a more powerful authentic smoke flavor when compared to a pellet smoker.Electric pellet smoker reviews show that gas smokers and pellet smokers are comparable in that they both can be set to a particular temperature and left alone. The one advantage that a pellet smoker has over a gas smoker is that with a pellet smoker, you can actually say that you are cooking with wood because the pellets are compressed wood.
Spent thousands on Traeger, they are ok. Wouldn’t have an issue if they were only $500. But the last one I bought, (Timberline 850) cost $2500 Canadian. Almost burnt my house down because it got over 600F and was still climbing. All Traeger does is mail you more Chinese parts to fix your China made grill. By the end of it you will know your Traeger in and out because you WILL have to take it apart to repair! Overpriced for a smoker with many issues. Timberline lower grill has a portion of the grill removed for some kind of design. They added a 1/4 lip to justify this Grand Canyon of a hole in the back of the grill. Well needless to say if you cook wings or something small and toss them around you will for sure lose the wings to this big stupid hole. But they said they pit the little lip to stop the food from falling... Do they not test these products?
As people learn about pellet grills, they quickly realize that there are a number of brands offering a variety of models. So how are they different? And how do you know which pellet grill is right for you? With more options than ever, shopping for a pellet grill can be confusing. In a market filled with grills that claim similar capabilities, it can be difficult to discern what separates one from another. However, if you know which factors to consider and what features to look for, choosing the best pellet grill for you is a whole lot easier.
Z Grills is a lesser known manufacturer and a great low-cost alternative to the more expensive Traeger grills. Their pellet grill is a sturdy, heavyweight model with a roomy 500 square inches of cooking space and an electronic feeding system for fuel pellets. An additional warming rack provides additional space for cooking at lower temperatures. Furthermore, Z Grills also ensures their product with a generous 3 years warranty.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
While the exterior is certainly whimsical, this smoker is serious business, with a proprietary Digital Pro Controller that maintains even cooking temperature, just like an oven. Dual meat probes let you monitor the pork and the chicken at the same time, and 425 square inches of grilling space means you can easily feed a crowd. The 11.5-pound hopper holds plenty of pellets, so you won’t need to refill for many hours.
Editor's Note: If you're looking to upgrade your backyard cooking setup this summer, you're probably in need of a little advice. We're longtime admirers of the folks behind AmazingRibs.com, the site dedicated to unraveling the science of barbecue and grilling. Please welcome back Max Good, the only person in the world whose full-time job is testing, rating, and reviewing grills and smokers. The database he maintains includes over 500 grills and smokers, ranging in price from $30 to $50,000. When it comes to barbecue equipment, nobody knows it better.
At present, I am sponsored by and continually use pellets produced by CookinPellets.com. There are two versions of pellets – the Perfect Mix (Hickory, Cherry, Hard Maple, and Apple Woods) and 100 Percent Hickory. In each of these versions, CookinPellets uses all wood, no bark, no filler woods like oak or alder and no flavor oils. Just 100% of what is on the bag. I get consistently great flavor using these two varieties of pellet smoker pellets from CookinPellets.com, and I think you’ll enjoy them very much as well.