Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.
When you purchase this smoker, the cost is a bit more then some and less then others. Yet, I believe a great deal! One get's what they pay for. I believe this grill is a bargain at the price you pay. From the way it is shipped to me, I was throuoghly impressed with the attention to detail in packing and my receiving the smoker in perfect condition. It is a tank and the people I dealt with at All Things Barbeque, were first rate. If you have any questions, they would answer them. I plan on using the smoker in the next few days and can hardly wait. If the smoker works anything like the staff does at ATBBQ, it will be a grand slam! Kudos to everyone there and thank you for everything!

With that being said, it’s necessary to understand how much wood pellet would last you and for how long. A 40-pound bag of wood pellets would last you for approximately 24 hours if burned at 250 F. Therefore, if you’re trying to slow-cook a large piece of brisket for 14 hours straight, your 6-9 lb hopper capacity just won’t cut it. You’re going to have to refill it in the middle if you wanted to continue cooking.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
The first thing we have to understand is the anatomy of a pellet smoker. Check the related section on this page to get the idea. Once we know which part goes where, the bigger battle will be won. Next, we’re going to have to be able to analyze the problem if we are to solve it. What seems to be the issue? Are the pellets not lighting up? Are the pellets getting stuck and not working properly? Weird noises coming out from the hopper? Are foods not cooking well? Let’s take a look at these problems and how to solve them:
This post was EXACTLY what i was looking for! Have been longing for the ability to make the gooey delicate saucy brisket that we get out here at the chain Armadillo Willies, which i realize is not aiming for the stars… At Orchard Supply House last weekend saw a Traeger or two, and was thinking placing a smaller version $499 range (although $439 on the Traeger website) next to my gas Weber Spirit.

Hey Dan – I think you’d really up your versatility with a good pellet smoker. Smoke profiles seem to depend largely on the quality of pellets used and then also on the burn consistency of the fire pot. What I mean here is that many pellet smoker users tell me that they prefer models that cycle over faster with frequent temp checks rather than those with longer wait times between temp checks. Cycling faster means that pellets burn more consistently and do not rest to a “charred” state and they “reactivate” This latter problem sometimes results in less than optimal flavor. Yoder smokers cycle very fast and are preferred by many due to this and their thicker metal construction.
It’s capable of many of the same feats as its sibling grill and other top-rated competing grills, but its piece de resistance is its Smart Grill Technology that allows you to control the temperature as easily as conventional ovens. Just don’t let it sit in direct sunlight and muck up its temp. The bottom line with this “smart” grill is that it has more pros than cons.
As people learn about pellet grills, they quickly realize that there are a number of brands offering a variety of models. So how are they different? And how do you know which pellet grill is right for you? With more options than ever, shopping for a pellet grill can be confusing. In a market filled with grills that claim similar capabilities, it can be difficult to discern what separates one from another. However, if you know which factors to consider and what features to look for, choosing the best pellet grill for you is a whole lot easier.

As you can see in this selection of pellet grill reviews, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet grills use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
With their portable model, Traeger has their own version of the classic 'tailgater'. Still fairly hefty at a little over 60 pounds, this grill is still far and away the most lightweight model Traeger offers. The legs fold up for ease of storage and transportation. As with all other Traeger products, temperature controls allow grillers to use the Tailgater as either a conventional grill or a smoker.
I've had the Yoder for about 4 years now. Never looked back. It made my old Traeger look like a dime-store trinket. Thick metal. Built like a tank. Hold temps perfectly. I used to monitor grill temp. Realized quickly there was no need. Not even in the wind and cold. Eats less pellets than my old Traeger. Don't get me wrong, the Traeger works great when conditions are perfect, but in Omaha, NE, things are rarely perfect. It's true that compared to an offset you won't realize as strong of smoke flavor. That's good and bad, depending on what you're going for. When you're after dense smoke flavor, a simple smoke tube is all you need to get it to where you need.
If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.
In the second year, the grill quit working. The auger turns and the heating rod gets hot but the grill shuts itself off within minutes. I think it is the controller but I've had the same experience as others: emails and phone calls to Traeger's customer service are unanswered. My wife just wants to return it to Costco but I'd rather fix it. Given the lack of response and the poor quality of the electronics, I'm starting to come around to my wife's point of view.
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
Accurate Temperature Control: The Davy Crockett has better temperature control that permits us to program a great deal more correct temperatures (one-degree changes possible) using their application (the control board permits us to alter temperatures 5 degrees at any given moment). It uses a PID controller […] controller to expect and fine micromanage the temperature by controlling the wood screw speed and the fan speed.
The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile cooking options and thorough heat distribution in a compact space. The removable middle section offers grilling and smoking functionality. This smoker offers a maintenance free cooking experience with a high capacity galvanized steel charcoal and ash chamber. For easy internal access simply ...  More + Product Details Close
WiFi capability - It shouldn't be surprising that as our lives become ever more connected, so are our grills. Because they already have an electronic control board, pellet grills are a natural fit for WiFi. With a connected pellet grill, you can remotely monitor and control your cooking and meat temperatures from a phone, tablet, or computer...no matter where you are. It's the ultimate set-it and forget-it feature. Currently, there are a few pellet grills with WiFi capability, but many more are on the way. Every Memphis Grills model, as well as the Traeger Timberline, have cloud-based WiFi that's easy to connect, reliable, and offer a host of features on free downloadable app.
For me, I don't care where it is built; it could be Oregon, China or the moon. But I want a smoker that is reliable. As a businessman, I don't understand this company. It is going to be a lot more expensive for the company when I return this thing to Costco and Costco makes Traeger take it back. Just being responsive and sending a new controller under warranty would seem to be easier and cheaper. Of course, if this was a normal company, they would fix the root cause (poor reliability) and make lots of money selling to happy customers. Read more
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?
I talk with a lot of teams out there, and I know for certain that some of them have turned to my buddy Fred Grosse’s MojoBricks to boost their smoke profile when using pellet grills. In fact, of the teams who win with Pellet Smokers – I’d wager at least a quarter of them to maybe half have used MojoBricks to round out their final product. I really like Fred as well – which makes it a pleasure to include his products in this grouping of pellet grill reviews.
×