According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Of all the different smoker designs available, pellet smokers are the easiest to use, because they're thermostatically controlled, like your kitchen stove. You just select a cooking temperature, and a controller maintains it by feeding wood pellets to a fire pot as needed to maintain your set temp. Set it and forget it. You can throw a brisket in a pellet smoker, set it for 225°F (105°C), go to bed, and sleep like a baby, knowing you'll wake up to delicious smoked meat.
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
This pellet smoker will bring your outdoor cooking experience to an entire new level with its massive 560 cubic meter cooking area that comes with one removable rack. It can reach temperatures of up to 500 degrees F which makes it an excellent choice for grilling, smoking, braising, baking, BBQ and roasting. Reasonably priced, it’s a great investment. It’s made of high-quality materials and superior digital controls, including LED controls and auto pellet feeder. Cleanup is also 60% less demanding because the convenient trap door is for burn pot cleaning. With this efficient pellet smoker, the money you spent will be worth it.
Coming over to the cooking area, you will find 2 stainless steel grill grates that give you 702 sq. in. of cooking space with an option of the second shelf that makes it 1054 sq. in. Its tall enough for turkeys and large enough to fit 6 large-sized racks of ribs. So, hosting a bunch of people for a BBQ party, and cooking delicious meat for them, would be as easy as it could get.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more
Explicitly designed as a tailgate smoker with maximum portability and accessibility, the Davey Crockett does what it does really well. It’s small, but it’s so easy to move and runs off of damn near any power source, so if you want a wood pellet smoker you can take literally anywhere with maximum portability and style, this is the one. That’s why in my opinion, this is the best pellet smoker out there for the money.
However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
Consumer-level Traeger grills are considered a mid-range type of pellet grill, so they’re good for those wanting to try pellet grills for the first time. Traeger models like the Lil’ Tex Elite 22 or the Tailgater cost several hundred dollars and can grill about 12 to 16 burgers at a time. Larger Traeger grills will generally carry low four-figure prices, such as the Pro Series 34 or the Select Pro, which can hold 32 to 40 burgers between the upper and lower grilling racks.
Background: I've had this flat top for a month now and do 99% of my cooking on it. I have it set up next to my kitchen balcony which allows me to cook outside in most weather conditions and allows me to keep my kitchen clean for the most part due to a natural gas hook-up that I have outside. I purchased the Natural Gas Kit Hose (NGKIT) and converted the flat top to only intake natural gas. Please note that once you make the conversion then you cannot convert it back to propane unless you get new orifices. I had to drill all 4 orifices with a #45 drill bit to ensure that sufficient gas will be funneled through to the flat top. This process took a couple hours and will take more if you don't have the proper tools.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.
Hi Jennifer, the Traeger grill you purchased should serve you well. You can see a picture of one of them installed here. I think this is the grill style you bought. One thing the sites you’ve researched (including my own article above) might not have stressed is that Traeger recently hired a new CEO and is actively working to attain the name, reputation, and reputation for quality that they once had. I’m confident should you have any problems with your unit that they will stand behind it and take care of them for you.
Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
I was so excited to get this grill for the weekend. It was easy to assemble and get going. It has a great place for me to keep my bbq tools and a front rack to set stuff down so I am able to easily put things on and off the grill. We made steak and lobster tails and they could not have turned out better and it came with a cookbook to know exactly how to do it!
For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
It may have taken a few years to catch on, but it’s hard to dispute that pellet grills are here to stay. Pellet grills are easily the fastest growing segment in the grilling industry. This has left many new pellet grill owners with a few questions concerning pellets. Chief among them “what constitutes a good pellet?” Second, “where can they find pellets to fuel their prized grill?”
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.
Yo, Kevin! Hope that you can soon review one of my all-time favorite purchases, the Traeger Li’l Tex Elite Smoker/Grill. After using it for a couple of months, I gave away my two year old gas-grill to my grandson. We’ve done chicken, turkey, pheasant, lamb, all kinds of beef, pork and sausages including some wonderful ribs and brisket. Our Easter Rib Roast turned out terrific as did the chunks of assorted sausages that we did for another family get-together. I was never a big fan of grilling until we got our Traeger. Both Traeger and the web-sites like yours are full of great recipes and ideas.
The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.