It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
Today, all serious players in the pellet smoker market have switched to digital thermostatic controllers that dictate pellet-feed commands based on a temperature sensor inside the cooking box. Just like with the oven in your kitchen, you set the desired cooking temperature, and the heating system kicks on and off to maintain that set point. An LED display shows your set temp, and most models allow you to toggle between set temp and actual temp readings from the internal thermostat. Actual temperatures will fluctuate a bit as the controller switches on and off to hover around your set temp, but many sophisticated touch-pad controllers can maintain tighter tolerances than your indoor oven. Some pellet controllers also have integrated probes that let you monitor the internal temperature of whatever you're smoking. Wireless remote control and monitoring from your smartphone or tablet are also increasingly common. (You can learn more about pellet smokers on AmazingRibs.com.)
The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.

So that brings me to the one thing I have learned in all this that I basically read when I was getting started. One of the biggest keys is “Temperature Control”! If you want consistent food make sure you get that under control. It is the key to solid consistent food! Once you get your food consistent you can experiment with a lot of other things. But if you can’t get that down, you will always be looking for another magic bullet. The number one magic is temperature!
The “Smart Smoke” controller goes from 160-450F, with an internal sensor and electric auger maintaining that heat. The hopper holds a good 20lbs of pellet - enough for 10-20 hours of smoking. And it’s built from a sturdy stainless steel that feels solid and looks fantastic, with locking caster wheels keeping it secure while in use. It’s also backed up by a 3-year warranty.
A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs.

Personal review of the Traeger: The auger fed the pellets after the fire pot went out making a large pile up which caused it to catch fire and burn up my grill. I had to use a fire extinguisher to put out the flames and prevent my house from catching fire. I sent Traeger the description of damages with photos. After much waiting and no response from the management team regarding my Traeger grill we gave up. The service team was very responsive but lacked any authority to make decisions to fix the grill. We worked with the service team for awhile having a different person each time respond and request information and photos that were already provided. Then, we got passed up to the management which is highly ineffective because we never heard from them, even after an email requesting an update. We really did like our Traeger grill and had high hopes that since it was under warranty and caught fire due to a failure we would have the grill repaired. Because of the terrible unresponsive service of Traeger we took our money and purchase a Green Mountain Grill.

The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.

The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.

Hey Corry – GMG and Traeger have shown that they support their brands very well of late. In many cases, they both provide parts support even when warranty limits run out. If you’re considering a Traeger, I’d urge you to go with their Pro Series 22 or 34. Sounds like that’s what you’re probably looking at where they are concerned if you’re looking at a dealer.
What’s more, it has an LED display with a Digital Elite Controller for temperature control. Judging by its ratings, unlike the other grills on this list, its temperature and quality controls work just fine. This grill also has an electronic auto-start ignition and easy-to-clean grill gates to boot. Its quality control isn’t perfect though, and some faulty units slipped through the cracks.
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.

Hi i would like to buy my boyfriend a good quality smoker but can’t seem to find one that’s small for people just starting out with smoking for our small backyard. Does anyone have any suggestions? I don’t want to invest too much to start incase it’s too difficult to use or we find we don’t like it. I’ve read some reviews on little smokers that catch on fire and that worries me since we live in a townhouse. I figured someone on here would know of a well made brand that is on the smaller/less expensive side.
A charcoal unit is going to provide a more powerful authentic smoke flavor when compared to a pellet smoker.Electric pellet smoker reviews show that gas smokers and pellet smokers are comparable in that they both can be set to a particular temperature and left alone. The one advantage that a pellet smoker has over a gas smoker is that with a pellet smoker, you can actually say that you are cooking with wood because the pellets are compressed wood.
This maker of top-quality wood and pellet grillers is the company spearheading the digital revolution in the pellet smoker industry like its digital controller that manages pellet flow to control internal temperature and WiFi that connects your phone to the grill, allowing you to use it to control your grill for good measure. It’s the more gimmicky of the different pellet grill makers.
If you’re a BBQ fan and you cherish cooking meat, then you may require a grill or a smoker. Similarly, as a kitchen won’t be finished without a microwave, a porch/cultivate/lawn/kitchen won’t likewise be without it. With a Traeger smoker, you can cook sound gourmet sustenance for your children and friends and family. Utilizing it, you likewise spare cash for not expecting to request nourishment and have it conveyed to you now and again.
Hey Boyd, it’s really great hearing from you here. I am becoming a much bigger Traeger fan then I was in the past. They have done some excellent work of late on their Grill models. I really think they’re doing a lot of work too improve and restate their original value proposition. Their Pro Series models are excellent, and I believe that the directions the company is taking especially with getting back into the competition world will benefit both it and its customers… Like you… Long into the future.
The Woodwind is a Pellet Grill for the connoisseur. Along with a high price tag come all sorts of fancy extras, from a specially constructed 'sear box' to a lever-operated cleaning system for removing wood ash. It's roomy too, with over 500 square inches of cooking space so whether you're cooking for one or smoking several racks of ribs at the same time, the Woodwind will get the job done.
I id not purchase this item from Amazon, a local retailer had them on sale but none the less this a great smoker at any cost. I have compared it to the far more expensive smokers and I have found that this one has a much stronger, better built main body. The metal is of a heavier gauge of steel. Cheap smokers are separated from more expensive ones a lot by the electronic controls. Tis model has a control from 160 degrees up to 500 in 25 degree increments. It maintains a constant temp within a few degrees of where it has been set, always a problem on other smokers not of the pellet design I have used. Pellet consumption is modest and the Camp Chef brand pellets are the cheapest I have found. and work extremely well The ash cleaning system is a matter of dumping a cup after use with very little ash left over. The grease trap system is perfect. I see no reason to spend more for a pellet smoker that couldn't perform any better than this one. I would recommend it to anyone in the market for one. They are a set it and forget way to do your smoking.
The great part about this smoker is that it is fairly light-weight, weighing in at 69 lbs, and its legs double as handles: all you have to do is fold the legs up and carry the smoker wherever you need to! Furthermore, this smoker comes with a 12V connector that you can plug into the cigarette lighter of your car, and a 12-foot alligator clips that you can connect to your car’s battery if necessary. You can take this smoker anywhere!

Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.


Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
Ok, so where do I start..... Last September or so, I bought my Traeger at the local Costco during one of the Traeger road shows. I heard wonderful things about them. Did the research, they are pricey, but decided to take the plunge and plop down the $750.00 for a new grill and a couple of bags of pellets. Assembly was way harder than the Traeger rep told me it would be. It took me about 4 hours start to finish to get it assembled. Once assembled, I did all the break in "burning" and we made our first meal, a whole chicken. I have to admit, it truly was yummy! Then over the next couple of months we made 4 or five other meals with it and we we actually very happy with the results. Then came the holidays...... We made one of the Ham recipes from a Traeger cookbook. About half way through the process I looked outside to see my grill totally engulfed in flames. I shut the grill down and fortunately salvages most of the ham for Christmas dinner. The grill itself was about 60% destroyed. I called Treager the next day just to find out what happened. The customer service guy way REALLY nice. He said, "Don't worry. We stand behind our product 100%." Wow was I impressed! He told me he would email me instructions on how to make a claim. He even told me he would send me a new thermometer ( my Christmas present one was destroyed by the fire). He did everything as promised! Now, jump ahead to my actually trying to get my Traeger replaced. Per the email, I called Traeger customer service expecting the same service I received right after Christmas. NOPE! I spoke with Frank (Carson) I believe. He did everything from accuse me of shutting my grill off and turning it back on incorrectly (impossible since I was in the house) to not cleaning my grill. Neither of which were correct. He basically made me feel like my grill was unsafe! His attitude was HORRIBLE! He was rude and condescending. A nightmare to work with! I did not get my grill issues resolved until I spoke with his boss Andrew. Way more than I felt was necessary. Fast forward to today. Finally got my new Traeger running again. Had an issue with the smoker temperature. So I called the toll free Traeger customer service line. Low and behold, who answers my call at Traeger customer service? Frank! He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!" Nice guy! Dude, being a smart aleck didn't exactly earn you any points. You should be ashamed of your self! Bottom line: Love my Traeger. But customer service person Frank is HORRIBLE to work with! Everyone else there is so nice. Why on earth do they keep someone who is supposed to be helping customers, when he has such a horrible and nasty disposition. I will keep my Traeger but hope I NEVER have to speak with Frank again. One star for him!

Each grill is porcelain coated, like you’d find on professional grills, for exceptional heat transfer and easy wipe cleaning. This attention to excellence is extended over the whole machine, with everything made out of heavy gauge steel and top quality material. The only real let down is the wheels, which are kind of low quality, but they’re real simple to switch out.

Depending on your budget and grilling needs, there are a variety of Traeger options ,including the Renegade. With the Traeger Pro Series 22 you get a bigger Traeger with more advanced features at about the same price, while the Junior Elite, Tailgater, and Bronson also offer an incredible value. Or, if you prefer a pre-set package deal, the Outlaw Package comes with upgraded accessories and and costs less than the Renegade.
Pellet grills have a couple of very distinct advantages and disadvantages. The best can hold a constant temperature more or less indefinitely, provide even smoke at low temps, cook w/o smoke at high temps, make it possible to evenly cook several different meats and do a good job at two zone cooking. The Yoder excels at these. It is built like a tank, easy to use and I love it. One drawback for some pellet grills is the inability to reach high temps and sear. With the GrillGrates I have reached almost 600F and can sear with the best of them. Drawbacks. Well, it is a bit tricky to clean, but I guess I am keeping it cleaner than I did my previous grills!

I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!
Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.
When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.
Camp Chef is a leading manufacturer of camping stoves, dutch ovens, and other outdoor cooking equipment. If you want quality cookware to take on your next camping trip or barbecue in the park, Camp Chef has the solutions - from camp stoves to cast iron dutch ovens. Camp Chef makes cooking gear for campers, hunting, for traveling by RV, even for your next tailgate party. Camp Chef was built around the idea of finding better ways to cook outdoors - no matter the location, from woods to parking lots to campgrounds - and from that philosophy has come a whole line of outdoor cooking equipment, made to let you go gourmet in the wild!
One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
×