Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
This is definitely our top pick for a Traeger grill, due to its level of versatility. It can grill, bake, smoke, braise, roast, and barbecue. It is consistent in its cooking, making it ideal for use with large gatherings. Moreover, it is easy to auto-start and has a digital control. In addition, cleaning it is not that hard, as it has non-stick grill grates.
We love recommending and reviewing wood pellet smoker grills, but we also want you to get the most out of them once you purchase. Without proper care and maintenance, even the best pellet smoker is bound to have a shorter lifespan. Therefore, how you use your smoker and how you maintain it after use greatly determines how long it will serve you. A little bit of work will go a long way toward extending the life of your smoker. A thorough cleaning of the smoker should occur at least once a year. If you frequently use it, you should have it done at least three times a year. Buying quality pellets will extend its life as well.
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.
DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork

I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.

Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.
From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.

The control panel is simple, uncomplicated and easy to use, no codes of crazy steps to remember. Turn the switch on, set the temp once it lights and you are ready to go. On the outside the controls may look simple but behind the scenes it is working to constantly monitor feed rates and temperatures to lock into your set temperature as close as possible. The longer you cook the smaller the adjustments , making this one of he most consistent cookers on the market.


Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
So which pellet smoker is worth your hard-earned dough? We've put together a list of the ones we think make the cut, organized from lowest to highest price. Sorry for the sticker shock—even a low-priced pellet smoker will cost more than many grills, and our first selection lists at $333. These motorized, digitally controlled devices just plain cost more, but believe you me, they are worth it! And all of these selections have won the AmazingRibs.com Best Value Gold or Silver Medal.
This smoker offers a massive 560 cubic inches of grilling area with a large-capacity pellet hopper. Even though it’s the perfect starter grill, it’s still packed with plenty of extras that even the pro chefs will enjoy. If the grilling space isn’t enough, the removable upper racks can be turned into extra cooking space. The smokestack behind the unit can also be converted into a prep area.
The grill is plated with beautiful stainless steel that gives the grill a refined and impressive look. The huge cooking area includes 570 square inches of surface area. That’s enough to hold 20 burgers or 4 rib racks! It also contains a second warming rack and bottom shelf that provides the grill stability and extra storage. This version comes with a sear box that can reach temperature of up to 900 degrees Fahrenheit, which caramelizes your food. There’s a cheaper version without a sear box that costs around $200 less if a sear box isn’t a necessity for you. Additionally, the legs are built with extreme thickness giving the grill a grounded base. The caster wheels add portability to the grill so you can find that perfect place in the backyard.
As another one of the most important criteria to consider, we read a lot of the reviews that individuals had to say about the controller system and how simple they are to use. With that said, we can say that all of the grills we have shared have a simple digital controller design that makes the grill simple to use and easy to adjust. Now, the digital controller is the way in which an individual will be able to adjust the temperature of the grill, which can range from an incredibly low temperature to as high as 450 degrees. Now, another really cool aspect of a digital temperature reader is that most brands have an LED display that makes it easy to read the temperature of the grill.
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.

Hey Dan – I think you’d really up your versatility with a good pellet smoker. Smoke profiles seem to depend largely on the quality of pellets used and then also on the burn consistency of the fire pot. What I mean here is that many pellet smoker users tell me that they prefer models that cycle over faster with frequent temp checks rather than those with longer wait times between temp checks. Cycling faster means that pellets burn more consistently and do not rest to a “charred” state and they “reactivate” This latter problem sometimes results in less than optimal flavor. Yoder smokers cycle very fast and are preferred by many due to this and their thicker metal construction.
The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.

It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.

Built from substantial stainless steel, the SmokePro looks bombproof and weighs a hefty 140 lbs – so it’s not portable like the Z Grills or Traeger Junior Elite. It has a stainless-steel probe to directly monitor meat, and a sensor for the grill’s internal temperature. Both read out on the LED display next to the digital controller, which goes from 160F to 500F in 25-degree increments.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.

What’s more, it has an LED display with a Digital Elite Controller for temperature control. Judging by its ratings, unlike the other grills on this list, its temperature and quality controls work just fine. This grill also has an electronic auto-start ignition and easy-to-clean grill gates to boot. Its quality control isn’t perfect though, and some faulty units slipped through the cracks.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
This will work using one burner only on the stove when connected to our RV exterior grill connection port. Our camp chef portable stove has one large and one standard burner. It would only operate on the standard burner due to the low pressure regulated on the RV piping system. Be prepared to break out the standard propane tank & regulator hose set if you plan on running a two or three burner camp chef stove. Rating is 4 stars due to the price and short length at $35 price tag, it could have been longer.
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazon https://tinyurl.com/amazingribs
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.
You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
Accurate, powerful, with a lot of options, good build quality and a nice set of features, all at an excellent price, the Camp Chef PG64 is our best overall pellet smoker. Of course, the RecTec still offers more options, but it’s more expensive, so if you want the absolute most for your money, without breaking the bank, you’re going to want to look closely at this.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
REC TEC Grills was born in Augusta, Georgia in 2009 by lifelong friends Ray Carnes and Ron Cundy. The pair made it their commitment to build high quality grills and sell them at reasonable prices. But that was only the beginning of their story. The rest of the promise was to treat everyone like family and provide them with world-class customer service. With those two fundamentals in place, the REC TEC Family was born and the REC TEC Lifestyle started to flourish. Your feedback as members of the REC TEC Family and your living the REC TEC Lifestyle has helped this family grow and become that special bond that binds us all together. Thank you to all of our current and future REC TEC Family members. It just would not be the same without you all.

The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.

Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
The built-in cords on outdoor cooking devices are often not long enough, and although regular household extension cords will work for rotisserie kits, they will not carry enough juice to keep you pellet smoker or electric smoker going. They could become a fire hazard as they heat up trying to deliver power to the unit. To extend the cord you need a large capacity cable as measured in amps. Here's how to figure out what you need:
As we started to learn more about pellet grills we realized that we had to take different aspects into consideration when it comes to the quality of the grill. With that said, we are eager to share with our readers the criteria that we used to come up with this top ten list. With this, we can say that all of the grills we share are made of the best quality materials and craftsmanship to be able and withstand the test of time and provide a delicious meal. Other than that, we share this criterion so individuals can find the best pellet grill that suits there needs.

Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
Lauded for its amazingly accurate cook temperatures and times and for affording cookers a real “unfair advantage” at competitions (according to those who lose to them)  – Fast Eddy’s Cookshack Pellet Smokers rank among the very best available on the market today. I love the history of Fast Eddy’s pellet grills. In 1986, Ed Maurin (Fast Eddy) – a retired KCMO Fire Fighter – cooked his first American Royal event. From that point on he was hooked on BBQ and on coming up with the very best way to ensure its production. By 1998 the first of his Fast Eddy’s pellet smokers was released to the market, and he was off to winning competitions and helping those who bought his cookers do so as well.
×