According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.
What are your thoughts about the Kalamazoo hybrid grills? From what I’ve found online, you have the choice of gas, charcoal and wood for cooking or combinations of all. I have no first hand experience with Kalamazoo but it seems very versatile? At the moment after a month of researching, I’m leaning towards a Mac/Yoder or a Webber spirit & egg or a Memphis….so in other words, I’m no closer to a decision than when I started. I currently have a 9 yr old treager that won’t break, seriously, I’ve only repainted once with rustolium….dang thing won’t break so I can get a new toy. I sear in a skillet in the kitchen. My treager has the smoke/med/high switch and I want more control, I’ve maxed what I can do and it’s a challenge in cold weather and wind but it was a great start when they were made to last, more than got my money’s worth. I cook at all levels from smoking to grilling. I do love pellets and don’t want an egg but enjoy the food as much as the process of preparing it. Ok probably to much info but money aside, will you list your recommendations of what you think is best for me?
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue). Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
I bought this grill in May 2018. Had to return it to Ace 9 days later because it wouldn’t keep temp or would go out and fill up with pellets. I had to have the GM of Ace fight for me to get a new grill from Traeger. Once I did the new one seemed to work for about a month. Since then this one does the same thing as far as heat and pellets. I thought this thing was supposed to be a set and forget grill. If I don’t watch the heat it will be 200+ degrees over the set heat or sometimes be at ambient temperature and I have to pull me meat, grill and grease tray out so I can empty the heat pot of all the Unburned pellets. This thing is nothing but trouble. Does it cook great meat? Yes! When it works and you babysit it the whole time. On top of that customer service is about as useless as ** on a boar! They will try and tell you it’s something you’ve done wrong. I will be buying another brand smoker and giving this one to someone who like to deal with troubles.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at firstname.lastname@example.org. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
An electric smoker and a pellet smoker, according to the reviews, both allow you to set the temperature and walk away. However, the flavor that you’re going to get from a pellet smoker is a lot stronger as compared to an electric one. Pellet smokers allow you a little bit more versatility than an electric smoker, whereas electric smokers are better at maintaining and controlling the temperature inside the cook box.
The Green Mountain Grills Davy Crockett is a versatile, wood-pellet grill that is intended for portability. Regardless of its weight, it’s about as minimized as you can get, and takes care of business. Contrasted with more costly wood pellet barbecues, it appears to hold its own on performance, while the one of a kind Wi-Fi usefulness needs some finish.
A smoking piece of juicy pork butt will just make your day. Not only does it smell good and taste good, the excitement of grilling and the anticipation of a good meal makes the experience even greater. But if you’re new to cooking and grilling, gathering the correct ingredients for a pork butt might be difficult. So, we’d rather simplify it for you with off the shelf products. If you’d rather make the rub yourself, check out our detailed guide.
SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
Of course, we recommend our pellets and have proven them to work fantastically with all of our grills, but we would never be short-sighted enough to say that our owners must only use our pellets. That just seems a bit, well, wrong. From our testing and customer feedback, the following brands all worked very well: B&B, BBQrs Delight, Cooking Pellets.com, Lumberjack and Smoke Ring.
With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.