You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
I have used mine Traeger 15 times and it hasn't worked once. I will not hold the temp within 15 degrees as they state. I can set mine to 225 and will go between 180-370. It also consistently shutting itself off with the same error. I have spoken to cust service 12 times and they are worthless. I have had new controller sent and other various parts. I have been on the phone with them for hours. I always have to take my meat off and finish it on my Weber. They refuse to send me a new one. They still demand to go back through the same damn steps as the last 12 times to debug it. Never again. If you see my post on Craigslist, don't buy it, it's a lemon that Traeger will not support.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you! 

You want even grilling: One of the downsides of using a charcoal grill is ensuring that the entire grilling area is evenly heated. Spreading the charcoal evenly and avoiding hot spots is difficult. Traeger’s pellet grilling system overcomes this problem with a fan that evenly distributes the heat throughout the grilling area, much like a wood-fired oven would have.
Revising Product review to include photos! Excellent size and performs better than hoped for. Doe great job of smoking meats. Did a 12hr Pork Butt last weekend, tasty. Ran into a snag lately with the smoke stack though. Installed a aluminum patio cover over our deck $5,000. Now when I use my Traeger, the smoke has only a few feet to rise due to new roof over it. If windy, smoke billows in circles, trying to escape. And smoke will race into sliding door when opened. Experimented and came up with cure that works 100% excellent! Home Depot for 25ft roll of 6" Flexible Aluminum Duct. The 6" size goes over the hat on top of Traeger stack, pull down a few inches, wrap aluminum foil around bottom to seal. Other end over end of deck rail. Tried to keep as straight as possible, then trimmed to fit when expanded. Works like a charm and solved problem. Now smoke goes out end of 8ft long alum tube and out from under roofline, up into the air. No more smoke trapped under deck. With the flex alum tube, I can place it on East, West or North deck rails for smoke direction. Just thought I would pass this along as it did not effect the Traeger at all. Actually most likely helps with keeping air draft from entering thru smoke stack.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.
There is information overload when it comes choosing a pellet grill. This makes it very difficult for most people to make up their mind on a single grill. Getting back to why you can trust us then to get you the best grill? because our backyard grillers have based their unbiased opinion on these different Traeger grill reviews after months of experimenting and research on customer reviews and satisfaction.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
When a product is listed as Pre-Order, such product is not yet in stock but is available for advanced purchase on our site, prior to the manufacturer's public release date. Pre-Order items are shipped once in stock and the public release date arrives. You will be notified of a product's updated status by email. The expected shipment time is listed on the Product Detail page.
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!

So that brings me to the one thing I have learned in all this that I basically read when I was getting started. One of the biggest keys is “Temperature Control”! If you want consistent food make sure you get that under control. It is the key to solid consistent food! Once you get your food consistent you can experiment with a lot of other things. But if you can’t get that down, you will always be looking for another magic bullet. The number one magic is temperature!


At the peak level of outdoor cooking, the Champion Competition Pro is a rugged grill and smoker with extensive features that come standard. Clean-up is a breeze with the heavy-duty, porcelain-coated cast-iron cooking grids. Known for superior heat retention, cast-iron makes searing easy. Other features include the stay-cool handle, side shelf with tool hooks and bottle opener, bottom cabinet for storage, robust locking caster wheels for easy movement, and a heavy-duty 14-gauge powder-coated steel finish. Sear or smoke, bake or roast: discover the taste of real wood-fired flavor with the Champion Competition Pro. Comes complete with a weatherproof grill cover.


Remote Accessibility: This level of control and observing is critical on the grounds that the container does not generally sustain the pellets into the wood screw accurately and the fire in the firepot can go out. The Davy Crockett will tell you that the container is not sustaining wood pellets and that the temperature is dropping. The Davy Crockett application will reveal to you something isn’t right.
With that being said, it’s necessary to understand how much wood pellet would last you and for how long. A 40-pound bag of wood pellets would last you for approximately 24 hours if burned at 250 F. Therefore, if you’re trying to slow-cook a large piece of brisket for 14 hours straight, your 6-9 lb hopper capacity just won’t cut it. You’re going to have to refill it in the middle if you wanted to continue cooking.
This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
There is no party like a backyard grill and BBQ party on a hot summer weekend with some good music on the back, and of course the centerpiece: the food. You see, food is a universal language. It is a way to say how much you appreciate and care for one another; a way to people’s hearts. And there is nothing more comfortable, warm and heart than some good old open grill and BBQ cooking on your pellet grill. And this is the reason you need an expert pellet grill review. 
For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only picnic time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ...  More + Product Details Close
With that said, depending on the size of the green an individual may need more pellets to fuel the food. However, a bigger sized pellet grill allows the cook to grill for a large number of people. While a compact grill can easily be taken anywhere. With that in mind, one important criterion that we wanted to take into consideration is how easy the item is to set up.
On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.

Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.

Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.


To be sure, there are pure “smoker” and pure “grills” but there are some exceptionally well-designed hybrids. I bought a Memphis Elite last year, and it is AWESOME! I made a pulled-pork masterpiece two months ago that was absolutely delicious… 8 hours on low temperature (225) then an hour on open flame (switching from a “smoker” insert to an “open-flame’ insert at 700 was easy) and it was awesome!
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®.
This maker of top-quality wood and pellet grillers is the company spearheading the digital revolution in the pellet smoker industry like its digital controller that manages pellet flow to control internal temperature and WiFi that connects your phone to the grill, allowing you to use it to control your grill for good measure. It’s the more gimmicky of the different pellet grill makers.

PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.

The range of dishes that can be prepared is unlimited, and the large surface provides a lot of flexibility in adjusting quantities to match the number of folk who will be eating. I generally prepare an extra portion or two to be frozen and used for lunch when I'm working. The money I've saved by preparing daily lunches and not buying lunch at local restaurants has more than paid for my Camp Chef Flat Top Grill.


We at Grills Forever have used many kinds of pellet smokers in the past 4 years and come up with different strategies to find the best functioning pellet smoker. All of our reviews are so detailed because they come from the first-hand experience. After 72 hours of researching and testing numerous products, our team of outdoor cooking enthusiasts has decided to crown the PG24 by Camp Chef Pellet Smoker as the best. It emerged as the perfect choice for rookies and experts, always delivering that rich BBQ flavor and fragrance.
Today I grilled up a T-Bone steak. And I used the Grill Grates. I upped the temps to 600 degrees. The T-Bone came out FABLULOUS!!! Actually, it cooked faster than I expected, and the sear marks were way better than I expected. I have been using Weber Gas Grill for many years and way satisfied with the results, but the Yoder smoker kicks ass...BRAVO YODER!!
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
Sometimes an inexpensive, less efficient pellet blend might be just fine for burgers or chicken breasts. Other times, you may want to step it up with a premium flavored pellet where whole turkeys, prime rib roasts, or a nice brisket can really shine. No matter what you read in any grouping of pellet grill reviews, know this: pellets are not all made equally. You will wind up with one or two “go to” brands over time that you simply prefer – sometimes for their efficiency (leaving little ash), others for their flavor.
×