Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.

A pellet grill is an outdoor cooker that runs on electricity. It uses wood pellets as fuel to cook as well as smoke and flavor the meats. A pellet grill is a combination appliance of grills, smoker, oven and more. It can be used to sear, smoke, grill, roast and even bake! A pallet grill can be used to cook almost all types of meats and proteins. It also accommodates larger quantity and size than a normal indoor appliance. This is what makes a pellet grill so special, its versatility and convenience of use.
Whether it's smoking a rack of ribs or grilling a wood-fired pizza, to even baking a homemade apple pie, do it all with Traeger's 6-in-1 versatility. No matter what you grill, smoke, bake, roast, braise, or BBQ, it all gets flavored with amazing Traeger wood-fired taste. Don't settle for a grill that can only grill or smoke when you can do it all with a Traeger.
Got my Camp Chef Smoke Pro SE four days ago. My son and I put it together, it is a two person job because it's heavy. Seasoned it and smoked two chickens that turned out awesome! Today I have hamburgers on. Smoking on low smoke for half an hour, take them off and crank it to 450 put em back on and grill till done. Easy to use. Very happy so far. Just hoping it holds up!
I also was a certified KCBS judge but never judged at an event. Their judging system was flawed in my opinion because if you truly follow their system it is possible that them best tasting piece of meat might not win. In cutting horses (not a judge but read all the rules as I showed a fair amount back then) you were always supposed to judge the best overall horse to win. I asked about leaving a process to make sure the piece of meat you feel is best to win and was told absolutely not you have to judge presentation points, tender points & etc. and not place based on your opinion of the best piece of meat! Not that KCBS is a bad organization, it’s rules didn’t fit my thought process. Passed their class and got the t-shirt just never agreed, was always a spectator.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!

Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
A quality pellet grill is built to last and will provide years of reliable performance. Bargain pellet grills not only lack the capabilities of better grills, they’re more likely to break down. No matter your price range, look for a pellet grill that’s built well and offers consistent performance. Fortunately, if price is a major consideration, there are quality pellet grills for under $500, as well as high-end pellet grills for under $1,000.
One-Touch Non-PID Controller - Featuring a LCD display and one-touch buttons for setting the cooking temperature in 5° or 10° increments, these controllers allow you to more accurately set a desired cooking temperature. However, like multi-position controllers, they use fixed cycles for delivering pellets and so are limited in accuracy to +/-15–20°F. These controllers may have inputs for meat probes that monitor the internal temperature of food.

Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
A pellet grill is an outdoor cooker that runs on electricity. It uses wood pellets as fuel to cook as well as smoke and flavor the meats. A pellet grill is a combination appliance of grills, smoker, oven and more. It can be used to sear, smoke, grill, roast and even bake! A pallet grill can be used to cook almost all types of meats and proteins. It also accommodates larger quantity and size than a normal indoor appliance. This is what makes a pellet grill so special, its versatility and convenience of use.

Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.

Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
Never worry about overcooking or burning your food. Masterful control of airflow throughout all chambers allows you to skillfully prepare food with savory natural hardwood flavor. Our propriety exhaust system makes for even grilling and smoking in the main grilling chamber, and sliding damper vents allow great versatility and control when using the upper and lower smoke cabinets. The fan-forced convection airflow in the main barrel allows the grill to work like a convection oven with indirect flame cooking, while the sliding plate on the flame broiler gives the option to sear a steak using direct flame cooking when desired. The removable upper cooking racks in the main barrel adds additional cooking space: cook dinner on the bottom and prepare vegetables and dessert at the same time on the top racks.
Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
Or the fact that it lives up to its “Ultimate Tailgating Grill” moniker for all you campers out there. You need to watch your roast closely so you won’t have to finish your pork butt in the oven. It’s not quite a “set it and forget it” kind of smoker grill because you still have to make sure that there’s a steady supply of pellets so that it won’t shut down.
In the second year, the grill quit working. The auger turns and the heating rod gets hot but the grill shuts itself off within minutes. I think it is the controller but I've had the same experience as others: emails and phone calls to Traeger's customer service are unanswered. My wife just wants to return it to Costco but I'd rather fix it. Given the lack of response and the poor quality of the electronics, I'm starting to come around to my wife's point of view.

The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
Everyone has their price range, but don’t confuse cheap for affordable. As with other types of grills, there are plenty of inexpensive pellet grills that seem attractive at first glance, especially if you're looking to save a little money. However, while a cheap pellet grill might save you a little money up front, it's going to cost you more in the long run. Parts will rust, components will break down, and you will likely find yourself replacing some or all of that affordable grill within five years. Ultimately, you're better off investing a little more money up front and get a quality grill that will keep years to come.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only Picnic Time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ...  More + Product Details Close
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
With the summer right around the corner, it’s about that time of the year that consumers are thinking about hosting outdoor picnics and having their friends and family in the backyard. Now, to make this year special, many people are flocking towards purchasing pellet grills. In efforts to assure our readers that each grill on today’s list is the absolute best, we performed an update on this buying guide. Included in this update, readers will get to learn about the criteria that we used to evaluate each grill and a list of answers to some commonly asked questions. Before the summer arrives, check out this update!
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
You then simply select your desired temperature via the digital controls and relax, safe in the knowledge that the temperature will stay steady and there won't be any dreaded hot or cold spots. This consistence is achieved through the efficient temperature control system and automated auger. This ensures a deep smokey flavor is embedded in your meat every time.

Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
Worst purchase of a product that I have ever made. After same issues the first and second cookings, I will use my good ole Brinkmann smoker from here on out. Shuts off with errors and after setting it on 250 will climb to over 400-450 degrees. They say you can set it and forget it, but I'm afraid that my home would burn down if I was not here watching over this junk. When you call customer service same old story. Take everything out, clean firepot put it all back together, then fire it back off. Take your screen out of pellet box and rake them. If you want to smoke meat you don't want to do this every 20 minutes or so. I gave over 600.00 dollars for this and have no more than 50.00 in my Brinkmann. Please read all problems with these before wasting your money!!!

My traeger has had some good moments but it very unreliable. I really do not enjoy cooking with it. I have no confidence in the temp readings and the smoke control. Every time I open the lid the temp drops like 200 degrees. I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf? I thought this POS was supposed to be a set it and forget it type smoker. Very unreliable. Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down. The pellet feeder is garbage. It will all the sudden just start smoking like crazy because the pellets have jammed into the burner. Completely ridiculous smoker. I use it still but only when I can sit and watch the feeder. The guys comment below is true about the feeder always just using the middle pellets. I always have to check it and push the pellets to the center. Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.

With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?


It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.
Designed specifically to heat quickly this little outdoor Designed specifically to heat quickly this little outdoor cooker is a powerhouse when it comes to boiling brewing or frying. With its high-pressure burner system this stove is a great addition to anyone’s gear and works perfectly for all types of canning. The small size and portability also makes this ...  More + Product Details Close
Remote Accessibility: This level of control and observing is critical on the grounds that the container does not generally sustain the pellets into the wood screw accurately and the fire in the firepot can go out. The Davy Crockett will tell you that the container is not sustaining wood pellets and that the temperature is dropping. The Davy Crockett application will reveal to you something isn’t right.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
I have a pro series Traeger. Both casters broke with minimal use. Bought new casters from Traeger. Neither one fits correctly and were very difficult to install. Casters came without instructions, so I had to guess. I went to u tube and found that people had to build a whole new leg assembly just to fit on new wheels that were not made for this smoker. I do not want to spend four hours of metal work to simply replace the casters that Traeger should have gotten right in the first place. Can of worms! Take that Traeger!
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.

When a product is listed as Pre-Order, such product is not yet in stock but is available for advanced purchase on our site, prior to the manufacturer's public release date. Pre-Order items are shipped once in stock and the public release date arrives. You will be notified of a product's updated status by email. The expected shipment time is listed on the Product Detail page.

Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.

Of all the different smoker designs available, pellet smokers are the easiest to use, because they're thermostatically controlled, like your kitchen stove. You just select a cooking temperature, and a controller maintains it by feeding wood pellets to a fire pot as needed to maintain your set temp. Set it and forget it. You can throw a brisket in a pellet smoker, set it for 225°F (105°C), go to bed, and sleep like a baby, knowing you'll wake up to delicious smoked meat.
"Camp Chef is excited to join the exceptional family of Vista Outdoor brands," said Ty Measom, Camp Chef President. "The opportunity to be part of this dynamic company will provide for the future growth and success of Camp Chef as a leader in our market. The hard work and dedication of Camp Chef employees, past and present, has made Camp Chef what it is today. We look forward to the opportunities ahead."

When you purchase this smoker, the cost is a bit more then some and less then others. Yet, I believe a great deal! One get's what they pay for. I believe this grill is a bargain at the price you pay. From the way it is shipped to me, I was throuoghly impressed with the attention to detail in packing and my receiving the smoker in perfect condition. It is a tank and the people I dealt with at All Things Barbeque, were first rate. If you have any questions, they would answer them. I plan on using the smoker in the next few days and can hardly wait. If the smoker works anything like the staff does at ATBBQ, it will be a grand slam! Kudos to everyone there and thank you for everything!
While the exterior is certainly whimsical, this smoker is serious business, with a proprietary Digital Pro Controller that maintains even cooking temperature, just like an oven. Dual meat probes let you monitor the pork and the chicken at the same time, and 425 square inches of grilling space means you can easily feed a crowd. The 11.5-pound hopper holds plenty of pellets, so you won’t need to refill for many hours.
Joe Traeger first introduced the concept of Pellet Grill in 1980’s. Pellet grills are a rage amongst backyard grillers because they can grill, roast and smoke all in one. Since it uses indirect electric heat, there are no chances for it to burn into flames, unlike a gas grill. It is the perfect cooking appliance for a novice chef, looking to experiment with different dishes. Which is actually one of the primary reason for its unbelievable popularity.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
Now, the best pellet grills come with more advanced features like auto-ignition using igniting rods, Wi-Fi Support, automatic turn on/off, and much more. One of the key safety features added by pellet smokers (designed by Green Mountain Grills), is a cooling fan to cool off the grill after it has been turned off. Even the shape of the body has been changed to have peaked lids so that it can accommodate turkeys and other kinds of roasts. Some come with multiple levels of racks for warming and cooling.
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.
There are other options, KBQ for one, but I want it to look like a grill. Not a refrigerator, although I’m sure they make great Q I have narrowed my search to Pellet poopers or the Primo or Egg. The Pellet poopers will have more capacity than even the XL Primo/Egg. But are they one trick ponies? Smoking and baking. WIth limited smoke profile. I wish I could taste the Que off of one to know for sure. I got rid of my gasser because of the limited flavor it produced. Rec-Tec’s tag line is Do you cook with wood. But does it produce enough smoke flavor for most people? How do your neighbors respond to your Que? Do they like the smoke profile of the Que? Sorry for all the questions. Just trying to figure out what the next smoker will be at Mi Casa.
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
Competition: If you are buying a smoker for participating in any competition, then pellet smokers are your best choice. Gas or electric smoker grills are not allowed in any competition as they are using automation. Though you are getting temperature control and electronic start in pellet smoker it is accepted in competition. This pellet smoker review will point out the ones best for a competition.
The moment we found this as one of our most desired articles, we had to conduct extensive research on what a pellet grill is. With that said, if you are new to the pellet grill industry and want to know what it is, here we go! Pellet grills are often considered, ‘pellet smokers’, due to the construction quality and design. The reason is that pellet grills combine different cooking elements such as charcoal, gas grills, and a conventional kitchen oven. Now, they are fueled by wood pellets, hence the name. With that said, pellet grills can smoke, cook, and grill all in one simple mechanism and design. With an electronic control panel, an individual can control the wood pellets that fuel the fire to regulate airflow and maintain the proper cooking temperature. Did you get that? We hope so because it is time we share with you the criteria to evaluate the best pellet grills.

For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.

The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...

Whether you enjoy smoking, or if grilling is your passion, the Camp Chef® SmokePro Deluxe helps create the perfect meal! From the backyard to the campsite, this pellet grill and smoker cooks up your favorite dish. Durable and heavy-duty, this smoker/grill boasts outstanding temperature sensor gauges to eliminate the guessing associated with smoking. The SmokePro provides internal cooking temps and internal food temps for delicious results.
To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
This pellet smoker will bring your outdoor cooking experience to an entire new level with its massive 560 cubic meter cooking area that comes with one removable rack. It can reach temperatures of up to 500 degrees F which makes it an excellent choice for grilling, smoking, braising, baking, BBQ and roasting. Reasonably priced, it’s a great investment. It’s made of high-quality materials and superior digital controls, including LED controls and auto pellet feeder. Cleanup is also 60% less demanding because the convenient trap door is for burn pot cleaning. With this efficient pellet smoker, the money you spent will be worth it.
Thanks for the quick response and advice. I see a pellet pro hopper assembly is around $250 compared to the Memphis pro at over $2000. I didn’t realize that drafting isn’t important for the sake of temp regulation but what about how the smoke travels from the firebox towards the meat? I also would like to include an element of humidity, is simply putting a pan of water in the cooker or is there a better way?
The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.
It’s capable of many of the same feats as its sibling grill and other top-rated competing grills, but its piece de resistance is its Smart Grill Technology that allows you to control the temperature as easily as conventional ovens. Just don’t let it sit in direct sunlight and muck up its temp. The bottom line with this “smart” grill is that it has more pros than cons.
One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you! 
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.
Wood pellet grills look like standard barbecue grills but some with a separate firebox for making smoked meats that will also let you smoke vegetables and other ingredients. As Traeger and Pit Boss both get good reviews from customers, it’s important that you look at the top features of this grills and how each company compares in relation to those features.
CAMP CHEF: for over 25 years Camp Chef has been making quality cooking gear for all of your outdoor cooking needs. Our products include Outdoor Cookers, Emergency preparedness stoves, Pellet Grills, Smokers, Pizza Ovens, Cast Iron Dutch Ovens, Flat Top Grills, Griddles, Fire Pits, Outdoor Movie Screens, and many more. Camping, Catering, Tailgating, Hunting, Dutch Oven cooking or even just on your deck at home. Cooking is our passion.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.

Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.

Or the fact that it lives up to its “Ultimate Tailgating Grill” moniker for all you campers out there. You need to watch your roast closely so you won’t have to finish your pork butt in the oven. It’s not quite a “set it and forget it” kind of smoker grill because you still have to make sure that there’s a steady supply of pellets so that it won’t shut down.

A good pellet grill can hit high temperatures for that perfect steak and still hold a steady low and slow temperature for great barbecue. All the while adding great smoke flavor from hardwood pellets. These pellet grills cost more but do so much more while being highly efficient, precise in temperature and widely capable. Among these, you will find cookers large enough for a whole hog as well as units with full network interfaces for controlling from a distance. These are the best of the best in Pellet Grills.
Now, for the good stuff: do not hesitate to spend an extra or even two bucks for a feature that you will use and appreciate. Consider your pellet grill as an investment, something you are going to buy, and be using and enjoying for years and years to come. Features like meat probes to check the internal temperature of foods are excellent for taking the guess work away from cooking meat to a particular doneness. You will never end up with an overcooked and rubbery, or undercooked and raw steak ever again! Features like smartly designed grills that consume and spread heat evenly are also great for cooking food to perfection without having to move it from side to side to find the right temperature spot.
I also was a certified KCBS judge but never judged at an event. Their judging system was flawed in my opinion because if you truly follow their system it is possible that them best tasting piece of meat might not win. In cutting horses (not a judge but read all the rules as I showed a fair amount back then) you were always supposed to judge the best overall horse to win. I asked about leaving a process to make sure the piece of meat you feel is best to win and was told absolutely not you have to judge presentation points, tender points & etc. and not place based on your opinion of the best piece of meat! Not that KCBS is a bad organization, it’s rules didn’t fit my thought process. Passed their class and got the t-shirt just never agreed, was always a spectator.

Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
The little cooking space is sufficiently sizeable to help you cook meat for a little gathering of individuals or a family. It can without much of a stretch hold 12 burgers, 2 chickens, 18 wieners and 3 rib racks advantageously. Generally on the off chance that you’ll be grilling for a bigger gathering, then you might need to consider a greater BBQ. Traeger BBQ 155.01 is composed of a side table for comfort when you have to place things on a surface. This grill is among many grills with a front mounted rack, yet in the event that you like a grill with a front shelving, simply ahead and get it.
Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship.
Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.
!function(e){function n(t){if(r[t])return r[t].exports;var i=r[t]={i:t,l:!1,exports:{}};return e[t].call(i.exports,i,i.exports,n),i.l=!0,i.exports}var t=window.webpackJsonp;window.webpackJsonp=function(n,r,o){for(var s,a,l=0,u=[];l1)for(var t=1;tf)return!1;if(h>c)return!1;var e=window.require.hasModule("shared/browser")&&window.require("shared/browser");return!e||!e.opera}function a(){var e=o(d);d=[],0!==e.length&&u("/ajax/log_errors_3RD_PARTY_POST",{errors:JSON.stringify(e)})}var l=t("./third_party/tracekit.js"),u=t("./shared/basicrpc.js").rpc;l.remoteFetching=!1,l.collectWindowErrors=!0,l.report.subscribe(r);var c=10,f=window.Q&&window.Q.errorSamplingRate||1,d=[],h=0,p=i(a,1e3),m=window.console&&!(window.NODE_JS&&window.UNIT_TEST);n.report=function(e){try{m&&console.error(e.stack||e),l.report(e)}catch(e){}};var w=function(e,n,t){r({name:n,message:t,source:e,stack:l.computeStackTrace.ofCaller().stack||[]}),m&&console.error(t)};n.logJsError=w.bind(null,"js"),n.logMobileJsError=w.bind(null,"mobile_js")},"./shared/globals.js":function(e,n,t){var r=t("./shared/links.js");(window.Q=window.Q||{}).openUrl=function(e,n){var t=e.href;return r.linkClicked(t,n),window.open(t).opener=null,!1}},"./shared/links.js":function(e,n){var t=[];n.onLinkClick=function(e){t.push(e)},n.linkClicked=function(e,n){for(var r=0;r>>0;if("function"!=typeof e)throw new TypeError;for(arguments.length>1&&(t=n),r=0;r>>0,r=arguments.length>=2?arguments[1]:void 0,i=0;i>>0;if(0===i)return-1;var o=+n||0;if(Math.abs(o)===Infinity&&(o=0),o>=i)return-1;for(t=Math.max(o>=0?o:i-Math.abs(o),0);t>>0;if("function"!=typeof e)throw new TypeError(e+" is not a function");for(arguments.length>1&&(t=n),r=0;r>>0;if("function"!=typeof e)throw new TypeError(e+" is not a function");for(arguments.length>1&&(t=n),r=new Array(s),i=0;i>>0;if("function"!=typeof e)throw new TypeError;for(var r=[],i=arguments.length>=2?arguments[1]:void 0,o=0;o>>0,i=0;if(2==arguments.length)n=arguments[1];else{for(;i=r)throw new TypeError("Reduce of empty array with no initial value");n=t[i++]}for(;i>>0;if(0===i)return-1;for(n=i-1,arguments.length>1&&(n=Number(arguments[1]),n!=n?n=0:0!==n&&n!=1/0&&n!=-1/0&&(n=(n>0||-1)*Math.floor(Math.abs(n)))),t=n>=0?Math.min(n,i-1):i-Math.abs(n);t>=0;t--)if(t in r&&r[t]===e)return t;return-1};t(Array.prototype,"lastIndexOf",c)}if(!Array.prototype.includes){var f=function(e){"use strict";if(null==this)throw new TypeError("Array.prototype.includes called on null or undefined");var n=Object(this),t=parseInt(n.length,10)||0;if(0===t)return!1;var r,i=parseInt(arguments[1],10)||0;i>=0?r=i:(r=t+i)<0&&(r=0);for(var o;r
Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?
This is a great pellet smoker! With a few minor tweaks, this thing would be perfect. Ribs, brisket, chicken, pulled pork, sausage, you name it and it comes off of the grates awesome. I've had mine since 2012 and would recommend that you purchase a spare thermocouple in case your's bites the dust in the middle of a smoke (replaced my thermocouple twice since 2012). This thing is built solid with longevity as a guarantee. The customer support at Yoder is unbelievable as well. I have gotten phone calls from them at 8am on Sunday morning when my first thermocouple gave up in 2014. Made in the USA with a commitment on customer support that has been incomparable to anything I've ever purchased! It's a bit pricey compared to the competition but does an amazing job. "The Sauce", with Chef Tom, is a huge help for those just getting their feet wet in pellet smoking. He does an amazing job by keeping it simple and flavorful!

-Warranty-(Forgive my soapbox here, folks.) I'd give it 5 stars if Camp Chef would give it a real warranty. One year is pathetic and WAY below the industry standard. Camp Chef, I know you are reading this because you guys are too excited about your great new product to not pay attention to feedback like this. Nut up and stand behind your awesome product. Why would anybody buy a product from an industry newcomer with no track record when you yourself are only willing to stand behind it for 1 lousy year?... Especially when the "industry leader" will guarantee their product for 3 years?!?! You are communicating that you have 1/3rd the amount of trust in your product that Traeger does. That's terrible! You should exceed what they are offering just to make the point in the industry! At a minimum, you should at least match their warranty just so it doesn't become a stumbling block to potential customers. Look, you basically took the lil tex and said "ok boys, so how can we make this better?!?" You did that! You totally knocked it out the park! Why cheap out with the warranty?!? As a customer, it makes me nervous that you know something I don't.

The Fast Eddy by Cookshack is an American designed and manufactured Pellet Grill with a riveted stainless steel body and solid digitally controlled system to maintain the consistent temperature. The name of the game here is sturdy reliability. What it lacks in little extras like wifi controls it makes up for inconsistency. Whether you're smoking, grilling, or searing, the Fast Eddy performs.

This pellet smoker will bring your outdoor cooking experience to an entire new level with its massive 560 cubic meter cooking area that comes with one removable rack. It can reach temperatures of up to 500 degrees F which makes it an excellent choice for grilling, smoking, braising, baking, BBQ and roasting. Reasonably priced, it’s a great investment. It’s made of high-quality materials and superior digital controls, including LED controls and auto pellet feeder. Cleanup is also 60% less demanding because the convenient trap door is for burn pot cleaning. With this efficient pellet smoker, the money you spent will be worth it.

In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?


Now that we have covered the most important criteria to take into consideration when it comes to quality pellet grills, we wanted to share the cost and the value criteria and why we have included this on this list. Now, It is evident that the more costly the grill is, the better quality designed it will be and the better functions it will have. With that said, most grills that are costly have some of the top of the line premiere features available such as high-quality construction that is rust resistant and up to 600sq in. of grilling space.
When you are looking for a smoker, one of the features that you want is to be able to control the temperature. This means that you will be able to use both a high and low temperature for smoking everything from poultry to fish to beef to vegetables to cheese. This is exactly what you get with the Camp Chef. It has an LED digital temp control system that comes with a food probe made from stainless material.
Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.

Pellet grills come in various sizes from the portable types for tailgating to the extra-large units for commercial use. If you are someone who wants to be able to take your smoker on the go, be it camping, partying or any other event you’ll want something that’s easy to lift and has wheels to facilitate movement. If you have lots of parties and gatherings at home, then you might want something bigger. Its all up to what your needs are.

Hey Bill! I think you’d be very happy with a Yoder pellet smoker. From a product and manufacturing standpoint, they’re great pellet smokers. If you’re looking at spending $1,700 and can perhaps go a little higher, you can then consider either a MAK grill or a Memphis Grill Pro Series. These are fantastic pieces of equipment. They are insulated at the point where the lid touches the body at closing, and provide superior convection cooking. Anytime you feel you want some extra smoke, you can always throw in an Amazn Pellet Tube or use a Mojo Cube. These will amp up your smoke profile in a manner you can predict and keep under control. I would NOT recommend adding anything foreign to your burn pot ever. Just keep things from the main pellet smoker function working as per the manufacturer’s design.