I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
In 1982 Traeger Heating in Oregon began experimenting with a furnace that would burn wood pellets made from compressed sawdust, a byproduct of the area lumber mills, and before long introduced a home heating system that they sold mostly locally. Since furnaces sold mostly in cold months, before long they began experimenting with a grill that would burn pellets, too. Eventually they created a device with an auger to feed the pellets and a blower to help them burn.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
You now know more about the perplexing pellet predicament, but where do you actually buy them?  Afterall, none of this matters if you cannot get them when you need them.  If you are lucky you have a local store that sells one of the brands mentioned above.  Definitely take the time to visit the web pages of these manufacturers and see what is available in your area.  If you are not one of the fortunate grill owners who live near an Academy Sports, Dicks Sporting Goods, Rural King, etc there is a chance your local Wal-Mart, Lowes or Home Depot may carry a reputable brand.
I also was a certified KCBS judge but never judged at an event. Their judging system was flawed in my opinion because if you truly follow their system it is possible that them best tasting piece of meat might not win. In cutting horses (not a judge but read all the rules as I showed a fair amount back then) you were always supposed to judge the best overall horse to win. I asked about leaving a process to make sure the piece of meat you feel is best to win and was told absolutely not you have to judge presentation points, tender points & etc. and not place based on your opinion of the best piece of meat! Not that KCBS is a bad organization, it’s rules didn’t fit my thought process. Passed their class and got the t-shirt just never agreed, was always a spectator.
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?
Compared with charcoal and other wood-fired grills, pellet smokers are simpler and cleaner and easier, giving more control than traditional smokers. Wood pellets are dense, burn hot and smooth, and can be easily fed into the flame with an automatic auger, allowing for consistent temperature with minimal effort. Many modern smokers let you practically set it and forget it, thanks to their digital controllers. Pellet grills are also efficiently cheap, often using as little as 1lb of pellets an hour.
There is no doubt that grilled food tastes better, especially if it is done with wood pellets. This is because it retains the smoky flavor of the wood pellets. However, there are always health concerns when it comes to meals that are grilled. The main issue is always the animal fat, which burns, resulting in the formation of heterocyclic amines, HCAs. This harmful chemical is a known cause of cancer as it easily fills the smoke that permeates into your food.
The first thing to consider before purchasing a pellet smoker is your budget. This will allow you to buy the best pellet smoker for the money. If you are a beginner, you do not need to get an expensive unit in order to produce results. However, if you have some experience and you want to take your smoking to the next level, you may look into a more expensive model with the goal of getting some of the features you want.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.
I store it in the Camp Chef cover. It takes about a minute to pull the cover off, install the gas cylinder and side tables, move it into cooking position on my deck, and light the burners. It doesn't take much longer to clean up. After getting the griddle back up to high temperature for cleaning, the active work of squirting, scraping and wiping down takes just a couple of minutes. After cool down, removing the gas tank and side tables (which fit nicely on top of the griddle for storage) and putting the cover on takes another a minute.
The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.
Hey Corry – GMG and Traeger have shown that they support their brands very well of late. In many cases, they both provide parts support even when warranty limits run out. If you’re considering a Traeger, I’d urge you to go with their Pro Series 22 or 34. Sounds like that’s what you’re probably looking at where they are concerned if you’re looking at a dealer.
With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.

Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.


Though the Memphis Pro works great as a high heat, sear, and direct flame grill, I chose to do some IBP ribs and a couple all natural pork loins I picked up from the store. I won’t go into too much detail on the pork loin and rib prep here, suffice it to say that I was very impressed with the smoke output I got from this unit, which I filled with a full compliment of CookinPellets Perfect Mix Pellets.
Final Verdict: If you have the capability to cook on this full-time, then I recommend doing so. You will save your kitchen and house from excess grease and smell. It can cook most items relatively fast and easy once you get accustomed to cooking on a flat top. The only thing it can't do is cook sauces or bake items. I even recommend it to folks who don't eat typical greasy foods. This requires very little oil and can use all sorts of cooking oil. All of my food dishes have been cooked well and I constantly have people asking about this flat top. Clean up is a breeze and will save you from needing to clean skillets and pans. This is an essential cookware that every household should have.
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
I called Traeger to discuss their 10k Commercial smoker. The fellow who answered was polite but not helpful. He said, "You need to call our commercial division. They can answer any question you might have," and gave me the number. This is literally how the conversation went when phone was answered. Me: "Hello I was hoping to talk to someone there about your 10k commercial smoker." Him: "What state you live in?" Me: "Texas." Him: "We don't ship direct to Texas anymore, you will need to call one of our dealers." CLICK. So I am thankful I found out now as there is no way in hell I will spend 10k with Traegar.
The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
If you are looking for the perfect spacious grill for home cooking, then this Traeger grill is yours for the taking. This is the most sold and famous model of Traeger grill in the market currently. It uses different kinds of hardwood pellets to smoke, grill, braise, bake, roast and barbecue different flavored dishes. Besides, it has a compact design that saves on storage space. It is built to last with sturdy steel construction with a powder coat finish. Additionally, it has a non-stick surface that makes it easier to clean and maintain the grill grates. Moreover, it is 418 square inches, enough for 16 burgers, 5 racks of ribs and 4 whole chickens.
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
Hey Corry – GMG and Traeger have shown that they support their brands very well of late. In many cases, they both provide parts support even when warranty limits run out. If you’re considering a Traeger, I’d urge you to go with their Pro Series 22 or 34. Sounds like that’s what you’re probably looking at where they are concerned if you’re looking at a dealer.
I was able to put this to use for the first time this past weekend. It was awesome! Worked exactly as expected. Very easy to cook on and clean. I see us breaking this out on every camping trip. Just a bit of warning though...our first meal on the griddle side was scrambled eggs (which cooked up super fast) and we forgot to make sure the stove itself was level and the eggs almost slid over the not so tall edge. Once the stove legs were leveled, everything was perfect.
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
It can be said often enough: the best pellet grill is the one that's best for you. Ultimately, you're the one paying for it and you're the one who will be cooking on it, so make sure whatever pellet grill you choose is the one you'll be happy with. Just because you're friend has no qualms paying top dollar for the most advanced grill on the market doesn't mean you should feel bad about spending half as much on a grill that does the things you want it to do. The best advice: do your research, be informed, and know what you're purchasing. If you can do that, you're unlikely to experience buyer's remorse.
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
The major issue is the size. It’s the smallest smoker at this price range, and barely bigger than the Junior Elite. Considering the price difference in the two, it’s hard to justify the extra expense, and when you compare it to the other smokers at this level, the Lil Tex seems more than a little lackluster. There’s less cleaning options, less automation, less cooking space. Just less of everything.
Regarding your question about a decrease in smoke flavor when using the pellet grill / smoker, I do believe you will experience a little bit of a drop off. This said, many people find the flavor from pellet grills / movers to be adequate. If you require a stronger smoke profile, you can always use one of the tube smokers that sits inside of the cooking chamber.
The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
I only just learned about “wood pellets” recently when my husband and I were researching ways to heat the small mountain cabin we just moved into a few months ago, and I had no idea there were so many options for pellet grills. Wow! I hadn’t even know these existed to consider them, and now your reviews have me wanting to try one out. You’ve offered amazingly detailed and positive information on each model listed to help buyers make an informed decision. Your writing style is so fun and upbeat, I can only imagine that your backyard and backyard gatherings rock! Thanks for giving me food for thought on our next grill, Nate. (And for making me hungry, too! lol)
I have used this cooker at least once a week for two years. I recently had a couple of issues with it going out and was thinking it was having a serious issue. Quite frankly as much as I use it it should be worn out by now. Here is what I discovered. Carbon had built up on the tempeture probe and the grill wasn't getting accurate readings. Suspecting the temp probe I checked it with an external one and it was off 50 degrees or more. I am assuming that the readings were off enough that the grill controller just shut it off kind of a fail safe? 30 seconds with steel wool and we are back in business.
The rest of the product we reviewed offered 6-in-1 features, but this one surprised us with its 8-in-1 cooking versatility. If an efficient smoker that can do multiple things is what you’re after, then there’s no need to look further. This could just be your top choice! The pit Boss Pellet Grill with Flame Broiler cooks almost all kinds of food with 100% genuine wood pellets. Talk about quality and quantity!
Something you may not have read in other Pellet grill reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average.
×