The Silverbac and the Silverbac original models of the Grilla Grills come with a good build. It has a stainless steel burn grate and a stainless steel firebox with a rugged exterior. It is painted with a high-temperature powder coating on a heavy-duty steel body. The seams are welded, caulked and powder coated for a three-layer weather resistance. Its lid and all the internal components are made of stainless steel, greatly improving this product’s life.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
A quality pellet grill is built to last and will provide years of reliable performance. Bargain pellet grills not only lack the capabilities of better grills, they’re more likely to break down. No matter your price range, look for a pellet grill that’s built well and offers consistent performance. Fortunately, if price is a major consideration, there are quality pellet grills for under $500, as well as high-end pellet grills for under $1,000.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.
Pellet grills are every lazy man’s dream appliance. These grills need absolute zero to minimal maintenance. You just need to lightly wipe through it after every use, and maybe thoroughly clean it 2 to 3 times a year! All pellet grills now come with a drip pan that catch the accumulating oils that drops from the food. They are also made with good quality raw materials that enable them to withstand the outdoor atmospheres all year round. If this does not entice your lazy bones, no other appliance will, and that is a fact. Period!
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.

Background: I've had this flat top for a month now and do 99% of my cooking on it. I have it set up next to my kitchen balcony which allows me to cook outside in most weather conditions and allows me to keep my kitchen clean for the most part due to a natural gas hook-up that I have outside. I purchased the Natural Gas Kit Hose (NGKIT) and converted the flat top to only intake natural gas. Please note that once you make the conversion then you cannot convert it back to propane unless you get new orifices. I had to drill all 4 orifices with a #45 drill bit to ensure that sufficient gas will be funneled through to the flat top. This process took a couple hours and will take more if you don't have the proper tools.

My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.


Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.


Bake, braise, grill, smoke, and sear – all of these cooking techniques can be fully experienced by just using one unit of backyard cooker! Yes, you can definitely do different kinds of cooking to your pork, beef, fish, pizza, or pie by just using the Camp Chef Smokepro STX Pellet Grill without burning charcoals and woods to start the cooking process.
First off, in general I was a huge Traeger fan due to my brother-in-law smoking up meat and fish for us for the past 3 years and it was just damn delicious. He also just raved about his Traeger, so finally I took the plunge and purchased a Century 34 model during one their Costco road shows. Customer Service - In general I will give them 4 stars because I am talking with a human, they were seemingly very thorough when I spoke with them and didn't appear to be reading from a knowledge base article when I described the problems. I also grilled them to ensure that the Costco specific model wasn't being manufactured with subpar parts since the price was so much less than retail and seemingly more bells and whistles. More than one representative confirmed that was not the case. This is where it stops being good news.
Traeger's, unlike other models, have a temperature probe, these sensors tell it if the temperature is too low and automatically feeds more pellets to the fire. You can set up the temperature in 5-degree increments. Other brands and cheaper versions only offer three settings low, medium and high. There is no sensor to monitor the temperature. If you are purchasing a pellet grill it is because you can set it and forget it. If you plan to hoover then it makes more sense to use a standard smoker or to transform your grill into a smoker.
Normally you will get 1- 3 years of warranty for the top pellet smokers from different companies. Traeger will serve you with a 3-year warranty while Camp Chef will give you only 1 year of warranty. Considered this the safe period for your pellet grill, so take advantage. If you own a top quality smoker then you may need not to think of any replacement within 5 years of buying.
Temperature range is an important factor. What you’ll need will depend on what kind of cooking you want to do. Top pellet grills can hit temperatures between 180 F to 425 F, enough for baking, smoking, roasting, and grilling. On the other hand, ioif you want to sear meat you need something that reaches the 500-550 F range. A functioning thermometer is a must. You’ll need a precise and accurate reading so you’ll know you’re cooking your meat at the right temperature.
However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
Pellet grills come in many different sizes that accommodate food as per those sizes. However, even the smaller kinds are able to cook up a meal for a large family of 4 to 5 at a time! The larger ones are obviously able to accommodate large portions of meat and other food in it. In fact, some large pellet grills are used to cook up a whole baby lamb or large fishes at a time! This is one appliance that has been proven ideal for feeding a lot of heads at a time without the stress and the hard work of course, making it great for small to medium parties and get-together.
First, it’s really easy to use, with an electric auto ignition and shutdown system, plus LED controls that make setup idiot proof. Once it’s up and burning, the built in temperature sensor and meat probe make knowing what’s going on inside simple, especially considering that the thermometer is one of the most accurate I’ve seen, with only around 10 degrees variance. It’s got multiple settings if you’re using it as a meat smoker, as well, so you can control your flavor.

If you have an older smoker and need a lot of physical maintenance like changing the hopper and the digital control, then changing those two parts may not help. These two changes may cost you $200 – $250 and with a rusty hopper, you will continuously lose the smoke you produce. This is not safe for your health, so in this situation, you should definitely opt to get a new pellet smoker grill.


Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
You have some solid reviews out there. I have been in pursuit of getting exactly what I want for about 25 years now LOL. Started with a Weber Kettle cooked some great meals on it and made that tasted more like eating a chunk of lump coal 🙁 Over the years I have built a couple 55 gal barrel smokers they were challenging to hold the temp, an old Kenmore stove oven into a propane starter wood smoke unit, a monster 24″ pipeline pipe 5′ long and a warming oven, a 40″ stainless grill made from an industrial engine catalyst that I could direct and indirect cook on and a few other small grills. Working in the oil & gas business and having poor welding skills with a good welding machine in the garage made for some great experiences. Most generally have cooked for 2 to 4 people but have fed up to 70 a time or two.
Igniter: An igniting rod, heated up to a red hot level, ignites wood pellets as they fall inside the firebox. A cooling fan blows air into the pellet smoker from behind the pellet auger to prevent heat backdraft, while the fan underneath the firebox fans the flame – distributing heat evenly throughout the smoker. This heat is used to smoke and slow cook food in the smoker to give it the best flavors possible.

Nothing says “you are welcome to my home” than some delicious and succulent baby back ribs; some beer can whole chicken cooked your special spice mix, and some wood smoked salmon. There is no better way to wins the appreciation of your favorite people than cooking up some wood grilled steaks and baked potatoes. But there is a catch, there always is.
Everyone has their price range, but don’t confuse cheap for affordable. As with other types of grills, there are plenty of inexpensive pellet grills that seem attractive at first glance, especially if you're looking to save a little money. However, while a cheap pellet grill might save you a little money up front, it's going to cost you more in the long run. Parts will rust, components will break down, and you will likely find yourself replacing some or all of that affordable grill within five years. Ultimately, you're better off investing a little more money up front and get a quality grill that will keep years to come.
Now we come to the part no one likes and that’s cleaning. This smoker won’t clean itself but it does make the process a lot easier. PG24 by Camp Chef Pellet Grill is created in a way that gives you easier access to the fire pot making cleaning out the ash effortless. It also has trap door that allows you to clean the unit without scouring through grease and ash. Anyone who has ever had to clean a smoker grill knows how time-consuming and enormous the task can be. This trap door is only present in expensive units, but you’ll be glad you paid a little more when cleaning becomes effortless. You could also buy the other version that could come with cover (which is $50 more expensive) to make sure the smoker is in the best condition at all times.
The rest of the product we reviewed offered 6-in-1 features, but this one surprised us with its 8-in-1 cooking versatility. If an efficient smoker that can do multiple things is what you’re after, then there’s no need to look further. This could just be your top choice! The pit Boss Pellet Grill with Flame Broiler cooks almost all kinds of food with 100% genuine wood pellets. Talk about quality and quantity!
This post was EXACTLY what i was looking for! Have been longing for the ability to make the gooey delicate saucy brisket that we get out here at the chain Armadillo Willies, which i realize is not aiming for the stars… At Orchard Supply House last weekend saw a Traeger or two, and was thinking placing a smaller version $499 range (although $439 on the Traeger website) next to my gas Weber Spirit.
Now that we have covered the most important criteria to take into consideration when it comes to quality pellet grills, we wanted to share the cost and the value criteria and why we have included this on this list. Now, It is evident that the more costly the grill is, the better quality designed it will be and the better functions it will have. With that said, most grills that are costly have some of the top of the line premiere features available such as high-quality construction that is rust resistant and up to 600sq in. of grilling space.

Fast forward to today.   Finally got my new Traeger running again.  Had an issue with the smoker temperature.   So I called the toll free Traeger customer service line.   Low and behold, who answers my call at Traeger customer service?  Frank!   He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!"   Nice guy!   Dude, being a smart aleck didn't exactly earn you any points.  You should be ashamed of your self!
Although pellet smokers already have their own custom-made wood pellets with different flavor and blends, if you choose to moonlight your smoker as a charcoal smoker for some reason (maybe for a different experience or a cooking experiment), you can use it as a regular smoker using wood chips. Under such circumstances, it’s going to be worth learning a bit about the types of wood chips out there.
Whether it's smoking a rack of ribs or grilling a wood-fired pizza, to even baking a homemade apple pie, do it all with Traeger's 6-in-1 versatility. No matter what you grill, smoke, bake, roast, braise, or BBQ, it all gets flavored with amazing Traeger wood-fired taste. Don't settle for a grill that can only grill or smoke when you can do it all with a Traeger.

The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.

Craft amazing wood-fired creations with the Traeger Lil' Tex Elite 22 pellet grill. From grilled steak, to smoked ribs, and even a freshly baked apple pie, the set it and forget it ease of use allows any home chef to cook it all. Swap the gas and charcoal barbecue for 100% pure hardwood pellet flavor and grill, smoke, bbq, bake, roast, or braise a masterpeice.
Hey Vernon – Yoder warranty is is 1-year on the igniter, 3-years on the control system and 10-years on the cooking body. Products manufactured by Memphis Wood Fire Grills carry a seven (7) year Limited Warranty from the date of purchase by the original owner against defects in material and workmanship. Electronic and electrical components carry a three (3) year replacement warranty when subjected to normal residential use. Limited Warranty does not apply to burn pot, meat probe, grill cover gaskets or damage caused by corrosion. The meat probe is under Warranty for 30 days from the date of purchase. (Both warranty blurbs were pulled from the respective company websites) Yoder: http://www.yodersmokers.com/pellet-frequently-asked-questions.html Memphis Grills: https://memphisgrills.com/warranty/

Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
After looking at a lot of pellets smoker grill reviews, it is easy to see that this is a pretty decent model. It is just so functional. So if you are looking to purchase something that is more than a pellet smoker, this is the product for you. Make sure to follow the instructions carefully when assembling it and be sure to gauge cooking time since this is a fast one.
Hello John. Thank you for your comment and questions here! In short, you will not get the same smoke profile on a pellet smoker that you do with your BGE or PBC. That said, I do think there are some ways to mitigate this. Yes, I do feel the Smoke Tube and Mojo Cubes add smoke flavor that is detectable. Fred at Mojo Bricks does good work, and I recommend his products without reservation. This said, I have been happy with the smoke level I see in the pellet smokers I’ve used. Starting low does and ramping up later is a technique I’ve used with success when extra smoke is desired. The Rec-Tec grill gets high reviews across the board. I have no hesitation backing them, along with Green Mountain Grills. Both are made in China, but the companies have great customer service support and strong user communities. I believe each has a well-contributed Facebook group or two.
If you’re a BBQ fan and you cherish cooking meat, then you may require a grill or a smoker. Similarly, as a kitchen won’t be finished without a microwave, a porch/cultivate/lawn/kitchen won’t likewise be without it. With a Traeger smoker, you can cook sound gourmet sustenance for your children and friends and family. Utilizing it, you likewise spare cash for not expecting to request nourishment and have it conveyed to you now and again.
Since wood chips are by-products of carpentry and woodwork, they are not only inexpensive but are also helpful for the environment since you’re using up all the parts of a tree. Its death wouldn’t go in vain! If you’re looking to learn more about the types of available wood chips and what kind of flavors they impart with, feel free to check out our post on that topic.

We all know about Davy Crockett and Daniel Boone, but Traeger is the true pioneer of pellet smoking. This company introduced the first pellet smokers, and it remains the best-known brand, although competition is growing. There's nothing fancy here. Instead of a touch-pad controller, Traeger employs an older-style digital dial controller. No WiFi or meat probes; just no-frills schmokin' from the industry leader.
I don’t know how many meals I cooked on that thing, but it’s been enough to make me a hero and de facto camp chef among my friends. I seared up a tri tip large enough to feed four hungry kayaking buddies at the Salmon River Festival one year, then covered it with foil and cooked it on indirect heat for one of the best steaks of my life, which we happily consumed in the middle of nowhere. The grill also perfectly charred onions and peppers to deliver a mountain of chicken and beef fajitas to a crowd of ten. I still get compliments on that one. 
Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.
Ever since my visit(s) to All Things BBQ in Wichita, my heart has belonged to the Yoder Smokers. I had researched many comparable size smokers, and guess what - they really are not comparable. The smoker started first time, quickly, and heated up well. I did ribs as my first foray and they were as perfect as my meager talents could get them. The fact that this smoker weighs in at almost 360 pounds speaks volumes as to how well built and how heavy gauge the metal is( something severely lacking in most other smokers). I had the extra shelf put in and the cooking space is easily double what I had seen in other smokers about the same dimensions. Hats off to All Things BBQ for the high quality Yoder smokers they so proudly distribute!!
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Although these are marketed as grills, they do much more, including baking or roasting. Because they heat by convection, you might not get the grill marks that a gas or charcoal grill will give you, but you also won’t have the flame-up problems. While many pellet grills offer high cooking temperatures, the maximum depends on ambient temperature and wind. Many users wrap their grills in special insulating covers to help maintain heat, reduce fuel use, and reach the higher temperatures they desire.
×