I’ve had the chance to use one the the Traeger Grills Pro Series grills now for some time, and I find it to be a great pellet grill. They really beefed up the chassis of this model, with a stronger, wider-stance sawhorse base, larger wheels, a nice strong side lift bar, and an upgraded Digital Pro Controller with Advanced Grilling Logic that keeps temps steady, but allows for a temp swing of about 15 degrees. I mention the temp swing here as a positive, rather than a negative. By allowing a tiny bit of temperature fluctuation, I find the grill actually puts out a bit more smoke throughout the cook as pellets are fed in to regulate temps.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
What we loved most is that it has a trap door to allow burn pot cleaning after every cooking. It lessened our job of cleaning this pellet smoker by 60%. It is more than amazing because from our research we know that a feature like this will cost twice as much as the Camp Chef. Honestly, this has emerged as our key point when we selected this smoker to be the best in our review.
I have the Expedition 2x stove I purchased from Costco a few years ago and upgraded it with these side shelves. These are really nice and very useful. Easy to install (only took about 10 minutes) and they fold right on top of the stove so the whole works still fits into the carry bag. They are sturdy, but NOT meant to support heavy items like a cast iron pan or griddle! A little common sense here will go a long way. Happy cooking!
I did a lot of research, and ended up buying the Camp Chef DLX24. It was at a price that fit my budget, (under $500) and had a lot of features the others didnt. The pellet trap door for quick dumping of the pellet hopper into a bucket, and the ash cleanout under the drum was a clincher. Being able to pull a lever and dump the ashes into an easily removable cup is a great feature that all grills should include.It has a digital temperature controller, and dual probes (one inside the smoker for grill temp, one for the meat) and overall good quality construction. The second shelf inside is standard (you pay extra for that on other grills). If your budget allows, would suggest purchasing the propane powered sear box ($199) which attaches to the side of the grill and allows for reverse searing meat..
Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
Camp Chef has already been mentioned several times on this list. It's a venerable company that makes up in quality what it lacks in the name recognition of a Traeger or Weber. Their Deluxe Pellet Grill is built to reach and hold ideal temperatures for smoking. An internal system syncs pellet delivery to temperature instead of simply feeding in fuel when it begins to run out. This ensures a clean, consistent cooking experience. A removable ash can makes clean-up a snap as well.
On the better models, a temperature probe in the oven area tells the controller what the temperature is and if it is below the target it tells the controller to feed more pellets and air. The best manufacturers, like MAK and Memphis, have designed their own versatile custom controllers that are easy to use and can hold a temperature within 5°F, tighter than many indoor ovens.
Novices: Do you consider yourself a novice with a smoker grill? If so have no shame, in fact, look at me, I started as a novice too! Realistically, no one becomes a geek in 2 weeks of studying or research. So as a beginner you must look for an easy to use smoker grill. Well, the primary concept of a pellet smoker lies in its easy to use features. Set it and forget represents the motto and the main aspect you crave, right?
If you get it that BBQ is more than burning hotdogs on a propane grill, you could likely benefit from The BBQ Beat podcasts. Kevin interviews the best Pitmasters in the country. They share their knowledge, stories, and experiences. There is something to be learned in each podcast. So if you're serious about your bbq, check out these podcasts. They are time well spent.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
Though the Memphis Pro works great as a high heat, sear, and direct flame grill, I chose to do some IBP ribs and a couple all natural pork loins I picked up from the store. I won’t go into too much detail on the pork loin and rib prep here, suffice it to say that I was very impressed with the smoke output I got from this unit, which I filled with a full compliment of CookinPellets Perfect Mix Pellets.
I bought my Traeger Pro Grill a year ago and have thoroughly enjoyed using it. The problems began when it suddenly stopped working. The warranty is a self-service warranty which means you have to service it yourself or load it up and haul it to a distributor for repair should your efforts fail. For this reason I HIGHLY RECOMMEND YOU AVOID BUYING A TRAEGER GRILL. Anytime you pay 1500 for anything a warranty should mean just that, it’s a replacement warranty. I am terribly disappointed with the response from Traeger. Please feel free to contact me should you need further clarification.
You are eligible for a full refund if no ShippingPass-eligible orders have been placed. You cannot receive a refund if you have placed a ShippingPass-eligible order. In this case, the Customer Care team will remove your account from auto-renewal to ensure you are not charged for an additional year and you can continue to use the subscription until the end of your subscription term.
Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.
Ever since my visit(s) to All Things BBQ in Wichita, my heart has belonged to the Yoder Smokers. I had researched many comparable size smokers, and guess what - they really are not comparable. The smoker started first time, quickly, and heated up well. I did ribs as my first foray and they were as perfect as my meager talents could get them. The fact that this smoker weighs in at almost 360 pounds speaks volumes as to how well built and how heavy gauge the metal is( something severely lacking in most other smokers). I had the extra shelf put in and the cooking space is easily double what I had seen in other smokers about the same dimensions. Hats off to All Things BBQ for the high quality Yoder smokers they so proudly distribute!!
This heavy-duty top-notch grill and smoker has a total cooking area of 429 square inches, which is large enough for cooking around twenty burgers at once. If that’s not enough, it comes with a secondary rack of 144 square inches that you can use for smoking or warming. With a height of 32.5 inches, you can cook a variety of meats and foods to your heart’s desire.
You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
Wood pellet grills look like standard barbecue grills but some with a separate firebox for making smoked meats that will also let you smoke vegetables and other ingredients. As Traeger and Pit Boss both get good reviews from customers, it’s important that you look at the top features of this grills and how each company compares in relation to those features.
In fact, 80 to 85% of pellet smokers in the USA are Traegers. The consensus is that they are reasonably well built, though some buyers complain that quality has dropped since manufacturing moved to China. But of course we hear more complaints—as well as more praise—about Traegers, since eight out of 10 pellet smoker owners have one. Traeger can be found in many national chains, like Cabela's and Costco. It's not unusual to find special deals on this popular product line, so keep your eyes open.
Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.