The argument for bark is that it smolders really well, providing more smoke during the cook and therefore more smokey flavor. Think about it: When you put a log on the fire, the bark almost immediately begins to smoke and smolder. And therein lies the second half of the pro-bark argument: when cooking on an offset you use logs with bark, so why should pellets be any different?
Hey Dan – I think you’d really up your versatility with a good pellet smoker. Smoke profiles seem to depend largely on the quality of pellets used and then also on the burn consistency of the fire pot. What I mean here is that many pellet smoker users tell me that they prefer models that cycle over faster with frequent temp checks rather than those with longer wait times between temp checks. Cycling faster means that pellets burn more consistently and do not rest to a “charred” state and they “reactivate” This latter problem sometimes results in less than optimal flavor. Yoder smokers cycle very fast and are preferred by many due to this and their thicker metal construction.
Because the wood pellets are the grill’s fuel, you should pay careful attention to the pellet hopper, the chamber that holds the pellets. You want a large enough hopper to hold all the pellets you need for a single cooking session. Look for a hopper with at least an 18-pound capacity if you want to slow cook for longer periods without having to refill the hopper.
So far this smoker is fabulous! There is a learning curve, and this is not a "set it and forget it" smoker. You have to make sure you don't run out of pellets as the smoker will shut down. Tried a pork butt, but I wasn't watching it close enough, so I had to finish it in the oven. Still delicious. Next made some boneless skinless chicken breasts which turned out wonderfully.
The computer controlled system maintains the smoker temperature with a high degree of precision so you don’t have to deal with fluctuations. With the optional (definitely a must) temperature probe you can put your meat in the smoker, set the desired target temperature and the FEC will take it from there. Once the target temperature is reached the smoker temperature will drop into a holding position until you are ready to remove your barbecue.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
Hey Corry – GMG and Traeger have shown that they support their brands very well of late. In many cases, they both provide parts support even when warranty limits run out. If you’re considering a Traeger, I’d urge you to go with their Pro Series 22 or 34. Sounds like that’s what you’re probably looking at where they are concerned if you’re looking at a dealer.
Traeger wood pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger’s wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
I bought my Traeger Pro Grill a year ago and have thoroughly enjoyed using it. The problems began when it suddenly stopped working. The warranty is a self-service warranty which means you have to service it yourself or load it up and haul it to a distributor for repair should your efforts fail. For this reason I HIGHLY RECOMMEND YOU AVOID BUYING A TRAEGER GRILL. Anytime you pay 1500 for anything a warranty should mean just that, it’s a replacement warranty. I am terribly disappointed with the response from Traeger. Please feel free to contact me should you need further clarification.
Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.
Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
I remember a time when I was going through some quad-bike reviews; it was all so confusing and I had no clue whom to believe and whom not to. Even when I eventually decided to put my faith in one of them, I kept having second thoughts regarding whether or not they would fail me. If you’re someone like me, let me give you four reasons our reviews won’t fail you:
The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile The Dyna-Glo Compact Charcoal Bullet Smoker boasts versatile cooking options and thorough heat distribution in a compact space. The removable middle section offers grilling and smoking functionality. This smoker offers a maintenance free cooking experience with a high capacity galvanized steel charcoal and ash chamber. For easy internal access simply ... More + Product Details Close
Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China.
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
In addition, due to the wood pellets used in the Traeger grill, it is easy to cook different food products even pies, something that is impossible with charcoal or propane fired grills like the big green egg grill and the camp chef grill, respectively. Moreover, it is hard to get consistent results with the big green egg grill, as some food might come out good while others will just burn. It is a great challenge to use the big green egg grill.
I have found that using the upper shelf gets more airflow around the meat than the lower shelf. I asked the AmazingRibs.com science advisor Prof. Greg Blonder about the problem (he has a MAK 1 Star). He explained that smoke sticks to cool surfaces and wet surfaces, and the surface of meat warms and dries out after a few hours. When he wants more smoke flavor he uses a strong smoke wood like hickory or mesquite, he starts with cold meat, and then he keeps the meat moist by painting or misting it with apple juice or a mop like Lexington Dip or East Carolina Mop or Texas Mop Sauce. A awter pan can help because the water condenses on the cool meat and attracts smoke. Read his detailed research on the subject in my article on the Science of Wood and my article on Basting.
It doesn't matter if you're talking about pellet grills, pop songs, or pizza, everyone always wants to know which is the best. While that might seem like a fairly straight forward question, there is no simple one-word answer. Is the best pellet grill the most popular one made by the best-known brand? Is it the most expensive one with the most advanced features and high-end bells and whistles? Is it the one that offers the best combination of price and performance? Really, the answer depends on you, your means, and your needs. Or, put another way, maybe the question shouldn't be what's the best pellet grill? but what's the best pellet grill for you?
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
Mixing flavored woods with oak offers a couple of advantages, starting with price. Woods like cherry and hickory aren’t nearly as plentiful as oak and therefore cost more, making 100% flavored wood pellet more expensive than those that use a base of oak or alder. By using a blend of oak and cherry, pellet makers can keep prices down—and because oak is fairly neutral the cherry wood smoke flavor still shines through.
The real innovative feature of this monster pellet grills is that with it can be divided into two independent grills or opened up into one that can accommodate a whole hog (though a rather small one). The best part of this is that it can be a 600 square inch pellet grill when it needs to be or a 1,200 square inch grill when it has to be. For the person who might need to do a lot of cooking once in a while, this is a very good option. With two pellet controllers, mounted on opposite ends this pellet grills has all the versatility imaginable.
I have the Expedition 2x stove I purchased from Costco a few years ago and upgraded it with these side shelves. These are really nice and very useful. Easy to install (only took about 10 minutes) and they fold right on top of the stove so the whole works still fits into the carry bag. They are sturdy, but NOT meant to support heavy items like a cast iron pan or griddle! A little common sense here will go a long way. Happy cooking!
Got the Traeger Pro grill. I was so excited after seeing all of the commercials, unfortunately once I got it together it did not work. No heat on the glow rod no fan nothing. The only thing that worked was the auger and the front panel lights up. Called customer service spent 2 hours on the phone for them to tell me what I already knew they did not work. I told the man on the other end of the line that if it could not work out of the box I did not want it, he stated no returns. Now I am stuck with it. He says, "I will send you the parts needed you can replace them."
But even with their indirect heat, wood pellets do something gas can’t; they give your meat that natural, smoky flavor you expect from wood. They don’t create as much smoke as wood or charcoal, so the flavor is not as intense, you swap that intensity for convenient cooking. The smoke they do create is clean and easy to control. And the hotter you burn pellets, the cleaner they burn, letting you crank up the heat when you don’t need smoke.
Explicitly designed as a tailgate smoker with maximum portability and accessibility, the Davey Crockett does what it does really well. It’s small, but it’s so easy to move and runs off of damn near any power source, so if you want a wood pellet smoker you can take literally anywhere with maximum portability and style, this is the one. That’s why in my opinion, this is the best pellet smoker out there for the money.
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.