Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.
The argument against bark is that it can cause an inconsistent burn and produce excessive ash. Again, consider a log on a fire. Because they have different compositions, the bark and hardwood burn at different rates and produce different amounts of heat. Furthermore, bark doesn’t burn cleanly, it creates more ash than the hardwood. When that ash builds up, it interferes with your grill’s ability to accurately read the temperature, causing large swings. If too much of that ash builds up in the fire pot, it can cut off the oxygen and snuff out the fire.
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
Pellet grill uses various types of flavored wood pellets to flavor the food by infusing smoke into it. Pellets of numerous flavors are available on the market: hickory, strawberry, oak and olive are just to name a few. Many pellet grill companies also manufacture wood pellets alongside the pellet grills that go hand in hand with their respective grills. So know your options, and be sure to spend a few extra bucks into buying a good quality wood pellet for your pellet grill as this is what will set apart your smoked exotic BBQ from the mainstream flavors out there.
My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
Fast forward to today. Finally got my new Traeger running again. Had an issue with the smoker temperature. So I called the toll free Traeger customer service line. Low and behold, who answers my call at Traeger customer service? Frank! He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!" Nice guy! Dude, being a smart aleck didn't exactly earn you any points. You should be ashamed of your self!
Regarding getting a good draft, this is a common misconception for pellet grills. The burn pot on pellet grills receives oxygen via a fan unit. As such, there’s no need for a draft to get a measured burn in the traditional sense. Most pellet grills lack sufficient insulation / gaskets, etc to prevent smoke from leaking out of the body. So, unless you’re going with the Memphis or something that uses oven style insulation, you don’t really need a chimney at all IMHO.
They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
First, it’s really easy to use, with an electric auto ignition and shutdown system, plus LED controls that make setup idiot proof. Once it’s up and burning, the built in temperature sensor and meat probe make knowing what’s going on inside simple, especially considering that the thermometer is one of the most accurate I’ve seen, with only around 10 degrees variance. It’s got multiple settings if you’re using it as a meat smoker, as well, so you can control your flavor.
I've had it for right at a year as of the time of this review, and I absolutely LOVE IT. Normally I am of the opinion that you should overspend to get the better product, but I am 100% satisfied with the SE. I've gone through almost 200# of pellets in a year and I've successfully smoked three briskets, pork in various forms, a bunch of whole chickens, salmon, and probably some other thing I'm not thinking of. The show-stopped for me is bacon-wrapped dove breasts. I smoke them for an hour and then finish them on my grill. They are out-of-this-world amazing.
They had the field to themselves for a few years, but the idea was too good to go unimitated, and with the digital age came the electronic controller that allowed Traegers and others to create a system that had a thermostat in the cooking chamber that would tell the fan and auger when to do their thing. Today there are more than a dozen manufacturers making increasingly sophisticated machines.
Purchased the YS640 about a month ago. So far I have cooked nine pork butts, three racks pork back ribs, one beef brisket and four thick cut New York steaks on it. I am very pleased with the results of these cooks. I have an upright propane smoker, Weber kettle, propane grill and so far the YS640 has out performed all three of those in ease of use and flavor performance. I can get almost the same flavors with my others, but takes more work and babysitting. Also want to mention that the YS640 is built to last. I noticed the ruggedness and excellent USA craftsmanship immediately upon arrival. Some reviewers think maybe the YS has a steep price, but I think its justified due to its construction and craftsmanship. It would be difficult to make something of this caliber for any less. A couple minor things to note is you will have to play with the damper a bit to learn the heat distribution, but after learning it, its not a problem. Doesn't put quite as strong as a wood flavor on the food as my upright propane smoker, but it puts the right amount and I have no complaint here. I would and have already recommended the YS640 to friends and acquaintances. If you have spent long hours smoking foods and know the correct flavors that they should be, your not going to be disappointed with this cooker!
RT 700 offers a Front Folding Shelf and has its own set of meat probe to monitor meat temperature while the grill smoke is infusing with the meat. Its Stainless Steel body protects it from rust and the colors from cracking or peeling. With its built-in WiFi-enabled control, coupled with Rec Tec’s proprietary PID algorithm, you will have control over your cooking process remotely using your wireless devices.
There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
This great build extends itself to its porcelain coated grates allowing it to be used for years with no signs of rust and also allows for an easy clean by the user. You can expect to have excellent results on your food with beautiful grill marks. Temperature control is made easy with its digital elite controller which makes you able to manage temperatures with ease. Its ignition is quick to start meaning there is no stress to be felt when lighting up your device.
Big Horn’s largest available grill, the XL 1093 comes with a large cooking area of 1093 sq inches. With it’s low price tag of around $300 and a high cooking area, this product could have been a great choice for pellet smokers. However, we’d rather not suggest something that’s susceptible to rust and weather conditions to be kept outdoors at all times.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!
Cooking a lot of food is easy when using Camp Chef’s Flat Top Grill. The large surface area will enhance your cooking experience giving you plenty of room to work so cooking is done efficiently. Included is an interchangeable flat top griddle making it easy to cook pancakes, bacon and eggs, sausage, and hash browns - all at once. Then switch to grilled burgers, kabobs, and chicken for the next meal. Four individual burners provide heat in specific areas creating heat zones that will help you manage hot foods. Built in matchless ignition knobs control the heat and flame. Fold-down side shelves and roller wheels are added for convenience.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
Hey Kim – thank you for this. I’ve had this happen with numerous pellet smokers, including GMGs. What happens most often when it happens is that I’ve been remiss in properly cleaning the grill out after several uses (vacuuming the fire pot out). This causes the ash etc to cover up the heating rod, thus making the temperature lower than expected. The auger keeps feeding the fire pot to compensate and you get what you’ve described.
So how do you know which are good pellets and which aren’t? It’s not easy. There are plenty of problematic pellets on the market that have glowing online reviews but which we know cause issues. Quality pellets usually cost in the neighborhood of $17 to $22 for a twenty-pound bag. If you see a price on pellets that seems too good to be true, there’s probably a reason for it.
I’ve had the chance to use one the the Traeger Grills Pro Series grills now for some time, and I find it to be a great pellet grill. They really beefed up the chassis of this model, with a stronger, wider-stance sawhorse base, larger wheels, a nice strong side lift bar, and an upgraded Digital Pro Controller with Advanced Grilling Logic that keeps temps steady, but allows for a temp swing of about 15 degrees. I mention the temp swing here as a positive, rather than a negative. By allowing a tiny bit of temperature fluctuation, I find the grill actually puts out a bit more smoke throughout the cook as pellets are fed in to regulate temps.