Hello.. You recommended a couple weeks ago to go with a GMG grill and that is the one I’m going with. I’m just a little torn between the DB and JB. They are only $150 apart but I’m not sure if the bigger size is worth the money when I can spend that on a cover and some pellets. Do you think the bigger size is worth it for a back yard smoker with the occasional party? I know people say bigger is better but I went bigger with my previous barrel smoker and it was much harder to keep an even temp with the bigger size. I would have went smaller given the chance. Thanks for any input!
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
This purchase, the customer service and the lack of understanding from Traeger Pellet Grills, LLC, has been very unfortunate.  I've since stopped payment with AMEX and Traeger is now telling AMEX that they will do nothing until they get the damaged grill back.  Well, I'm in Florida and my brother is in Virginia, and at his age is not capable of handling a Grill that weighs over 100 pounds by himself.  Additionally, he's not a "Grill Repair Man" and does not have the knowledge to tear down a Grill Body including electronics and putting it back together as assembled at Traeger.
One of the most common problems people encounter with pellet grills is abnormal temperature fluctuations—the controller is set to 250°F, but the grill is dropping to 200°F then climbing to 325°F. Usually people assume that it's a mechanical issue and either the controller or RTD probe need to be replaced. However, very often the problem is far simpler and the solution far easier.

Do not confuse a pellet grill for gas grills. Like the name suggests, a pellet grill obviously uses pellets for cooking its food. But do not doubt its competence with any other gas or convection appliances. It cooks just as well, if not better. And the secret to this are in its pellets. While pellets vary from brand to brand, the best ones have more wood and less binders like sawdust etc.

Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:
Like with e-cigs and their gimmick of flavorful e-liquids, pellets for pellet grills and smokers also have different flavors added to their pellets, and they include bourbon, maple, apple, cherry, mesquite, alder, pecan, and hickory. You can mix flavors, change flavors, or use different flavors for every day of the week if you do everyday barbecues and grills for your restaurant or something.
Hi Jennifer, the Traeger grill you purchased should serve you well. You can see a picture of one of them installed here. I think this is the grill style you bought. One thing the sites you’ve researched (including my own article above) might not have stressed is that Traeger recently hired a new CEO and is actively working to attain the name, reputation, and reputation for quality that they once had. I’m confident should you have any problems with your unit that they will stand behind it and take care of them for you.
I got my YS640 for a combination Father's Day/ Birthday gift and regardless of whether it's grilling or smoking beef, pork or chicken the results have been outstanding. I can hardly wait to break out the turkeys for the Holiday meals. The direct grilling grates leave a steak with beautiful grill marks and the use of the fruit wood pellets along with quality steaks have made for some incomparable meals. As for quality of the smoker itself, I have sons-in-law that are already jockeying for position to try to be the next to have the YS640 after my demise - - - and we're figuring that won't be for at least 20-30 years!
Vista Outdoor will pay a total purchase price of $74 million for Camp Chef, comprised of $60 million in cash paid at closing and $14 million in cash to be paid out in equal installments on the first, second and third anniversaries of the closing date, subject to certain conditions described below. However, the effective purchase price is lower, due to value created by certain tax assets resulting from the transaction and the deferred purchase price structure, leading to an effective multiple of approximately 6.4x Camp Chef's expected calendar year 2016 EBITDA. Vista Outdoor financed the purchase price paid at closing using borrowings under its existing revolving credit facility. Vista Outdoor expects the acquisition to be slightly accretive to FY17 earnings per share (EPS), including impacts associated with transaction expenses. A majority of the payment of $14 million of deferred purchase price will be contingent on continued employment of key members of management and certain other conditions. As a result, Vista Outdoor plans to record the payments conditioned on continued employment as a compensation expense in future periods in accordance with GAAP. However, for purposes of presenting certain non-GAAP financial measures, including adjusted EPS, Vista Outdoor expects to treat those deferred payments as deferred purchase price and will therefore adjust the payments out of its financial results in future periods as payments are made. The purchase price will also be subject to a customary working capital adjustment. Additional information, including impact on full-year guidance, related to Camp Chef will be presented during Vista Outdoor's second quarter FY17 earnings call and webcast.
Bought a Traeger Timberline 850. A lot of money but it's a great smoker. It has WiFire so you can cook based on their recipes right from your iPhone. The problem is with their recipes that aren't built into their app. Nobody proofreads the things so many of them are useless. Just one example - Santa Maria Tri-Tip: smoke for 4-5 hours. At what temperature? 165 F, 250 F, or 500 F? It makes a bit of a difference ! I suspect they pay people to write, and post recipes so the can say they have thousands of (what are actually useless) recipes.

The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.
I have used mine Traeger 15 times and it hasn't worked once. I will not hold the temp within 15 degrees as they state. I can set mine to 225 and will go between 180-370. It also consistently shutting itself off with the same error. I have spoken to cust service 12 times and they are worthless. I have had new controller sent and other various parts. I have been on the phone with them for hours. I always have to take my meat off and finish it on my Weber. They refuse to send me a new one. They still demand to go back through the same damn steps as the last 12 times to debug it. Never again. If you see my post on Craigslist, don't buy it, it's a lemon that Traeger will not support.
The “Smart Smoke” controller goes from 160-450F, with an internal sensor and electric auger maintaining that heat. The hopper holds a good 20lbs of pellet - enough for 10-20 hours of smoking. And it’s built from a sturdy stainless steel that feels solid and looks fantastic, with locking caster wheels keeping it secure while in use. It’s also backed up by a 3-year warranty.
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
There is information overload when it comes choosing a pellet grill. This makes it very difficult for most people to make up their mind on a single grill. Getting back to why you can trust us then to get you the best grill? because our backyard grillers have based their unbiased opinion on these different Traeger grill reviews after months of experimenting and research on customer reviews and satisfaction.
The best pellet grill smoker has the benefit of being easy to light and easy to use. With a pellet smoker, you put the pellets in the hopper, light the heating unit, and you don’t have to worry about it. Conversely, with a charcoal smoker, you have the struggle to light the charcoal, and then throughout the entire cooking time, you need to check the backup on the unit to make sure that it’s functioning properly.

Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.

Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
Heating pellets, meanwhile, can consist of a variety of woods, including softwoods like pine, which contains resin that infuses food with a bitter unappetizing taste. Because it doesn’t really matter what’s in heating pellets, so long as they burn, they can also include bark and leaves and other impurities that can adversely affect food flavor and possibly pose a health risk if ingested. Because less care goes into the production of heating pellets and they're not guaranteed to be 100% pure hardwood, heating pellets are significantly less expensive than BBQ pellets, making them appealing to budget conscious shoppers. However, resist the temptation to save a few bucks and never use heating pellets in a pellet smoker.
Barbecuing and grilling meats to the perfect temperature, texture and doneness is a skill that is acquired over years and years of practice. There is a lot that goes into making a good BBQ than just good seasoning and fresh meat, and any pit master will agree. There are just so many aspects you have to learn how to control: the temperature, the smoke, the placement, the ratios and so on. But you are lucky that this is new of yesterdays.

When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.

Competition: If you are buying a smoker for participating in any competition, then pellet smokers are your best choice. Gas or electric smoker grills are not allowed in any competition as they are using automation. Though you are getting temperature control and electronic start in pellet smoker it is accepted in competition. This pellet smoker review will point out the ones best for a competition.
Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.

Consumer-level Traeger grills are considered a mid-range type of pellet grill, so they’re good for those wanting to try pellet grills for the first time. Traeger models like the Lil’ Tex Elite 22 or the Tailgater cost several hundred dollars and can grill about 12 to 16 burgers at a time. Larger Traeger grills will generally carry low four-figure prices, such as the Pro Series 34 or the Select Pro, which can hold 32 to 40 burgers between the upper and lower grilling racks.


I haven’t posted here before, but have been reading and finding a lot of good information on this site. I am in the market for a pellet grill so have been researching some of them listed on this site. Out of Yoder, Green Mountain, Memphis and MAK I really like price, features and looks of the Yoder YS640. I was wondering if anyone has used Louisianna pellet grills? For example, the CS680? I don’t see it mentioned much on bbq blog sites so not sure if it is a good brand. Thanks for any advice.
Camp Chef is a leading manufacturer of camping stoves, dutch ovens, and other outdoor cooking equipment. If you want quality cookware to take on your next camping trip or barbecue in the park, Camp Chef has the solutions - from camp stoves to cast iron dutch ovens. Camp Chef makes cooking gear for campers, hunting, for traveling by RV, even for your next tailgate party. Camp Chef was built around the idea of finding better ways to cook outdoors - no matter the location, from woods to parking lots to campgrounds - and from that philosophy has come a whole line of outdoor cooking equipment, made to let you go gourmet in the wild!
Multi-position Controller - A step up from 3-position controllers, multi-position controllers feature a knob with temperature settings that go from 180°F to 420°F in 25° increments and may have an LCD display. In addition to more settings, these controllers offer more temperature control. However, they also run on fixed cycles and can only maintain about +/-20°F in ideal conditions—in cold windy weather they are less accurate and reliable. Some versions of these controllers have inputs for meat probes that can monitor food temperatures.
You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.
Pellet grills have a couple of very distinct advantages and disadvantages. The best can hold a constant temperature more or less indefinitely, provide even smoke at low temps, cook w/o smoke at high temps, make it possible to evenly cook several different meats and do a good job at two zone cooking. The Yoder excels at these. It is built like a tank, easy to use and I love it. One drawback for some pellet grills is the inability to reach high temps and sear. With the GrillGrates I have reached almost 600F and can sear with the best of them. Drawbacks. Well, it is a bit tricky to clean, but I guess I am keeping it cleaner than I did my previous grills!
Temperature range is an important factor. What you’ll need will depend on what kind of cooking you want to do. Top pellet grills can hit temperatures between 180 F to 425 F, enough for baking, smoking, roasting, and grilling. On the other hand, ioif you want to sear meat you need something that reaches the 500-550 F range. A functioning thermometer is a must. You’ll need a precise and accurate reading so you’ll know you’re cooking your meat at the right temperature.

They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.

I purchased a Traeger Select Elite from Costco for both my personal residence as well as for my vacation home. I am now on the third grill at my residence. Traeger will tell you that they expect to offer Awesome customer service. I have replaced the auger assembly, the controller and now the fan. I can't get the grill up to temperature. Awesome customer service says it should be no problem. Just replace the _______ (fill in the blank). I don't think these people have ever seen a grill let alone use one. Costco (love their return policy) is about to get another one back. Am I too harsh to expect the product to perform as they say it will? I would think when you pay as much as Traeger thinks their grills are worth, that they should work out of the box. Well, quality control under the new management has gone to hell. Then they expect you to "try" all the fixes that might work on your own. This is self service, not customer service.

When buying an item as important as a grill, it is evident that an individual should look for the best quality for what they desire as well as learn properly what are the best in the industry. With that in mind, pellet grills are even more unique than a regular grill because of the design and the way the grill functions. With that said, the quality of a pellet grill is the first criteria we took into consideration because there is a slew of different elements that have to ensure the grill is made of the best possible quality design. With that in mind, one important aspect of quality design that we took into consideration is how all of the functions are built. Meaning, we wanted to make sure that no area was designed and manufactured in a cheap way. Other than that, one method in which we figured out the best quality grills is how the grill cooked and how the items tasted. However, since we cannot buy every single grill and spend weeks cooking steaks and vegetables, as nice as that sounds, we relied a lot on individual reviews and what people had to say about that particular grill.
A quality pellet grill is built to last and will provide years of reliable performance. Bargain pellet grills not only lack the capabilities of better grills, they’re more likely to break down. No matter your price range, look for a pellet grill that’s built well and offers consistent performance. Fortunately, if price is a major consideration, there are quality pellet grills for under $500, as well as high-end pellet grills for under $1,000.

The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.

This is definitely our top pick for a Traeger grill, due to its level of versatility. It can grill, bake, smoke, braise, roast, and barbecue. It is consistent in its cooking, making it ideal for use with large gatherings. Moreover, it is easy to auto-start and has a digital control. In addition, cleaning it is not that hard, as it has non-stick grill grates.
Like other grills, pellet grills list cooking area two ways: primary cooking area, which refers to the main cooking grate, and total cooking area, which is the main cooking grate plus any secondary racks. However, since pellet grills are primarily indirect cookers, there really is no difference between cooking on the main rack or the upper rack&em;the temperature should be the same. Therefore, a smaller pellet grill with a primary grid of 450 square inches and an upper rack of 125 square inches may be a better option than a larger grill with only a 500 square inch primary grid.
Thank you for a very comprehensive review and all the helpful advice. I would like to know your thoughts about having the burn pot in the center area as in the Rec-Tec, or on the side. My only interest is smoking, not grilling, and I prefer even heat throughout the cooking chamber. How much difference does the location of the burn pot make? Thank you very much.
This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.

I have a pro series Traeger. Both casters broke with minimal use. Bought new casters from Traeger. Neither one fits correctly and were very difficult to install. Casters came without instructions, so I had to guess. I went to u tube and found that people had to build a whole new leg assembly just to fit on new wheels that were not made for this smoker. I do not want to spend four hours of metal work to simply replace the casters that Traeger should have gotten right in the first place. Can of worms! Take that Traeger!

The argument for bark is that it smolders really well, providing more smoke during the cook and therefore more smokey flavor. Think about it: When you put a log on the fire, the bark almost immediately begins to smoke and smolder. And therein lies the second half of the pro-bark argument: when cooking on an offset you use logs with bark, so why should pellets be any different?

I remember a time when I was going through some quad-bike reviews; it was all so confusing and I had no clue whom to believe and whom not to. Even when I eventually decided to put my faith in one of them, I kept having second thoughts regarding whether or not they would fail me. If you’re someone like me, let me give you four reasons our reviews won’t fail you:


Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
With a massive 700 square inches of primary grilling space, this grill impressed us when compared to other Pit Boss grills we reviewed. Its size is large enough to cook for large groups of people. It features a Flame Broiler that uses slide-plates which allow for direct flame grilling, which means you get an even cast-iron cooking each time. If the 700 square inches isn’t enough, you can make use of the additional upper cooking rack space. The racks are made of porcelain-coated cast iron for optimum grilling as well as easier maintenance.
We did return the Traeger to Costco for a full refund. It's not that Traeger has poor customer service; they don't have any customer service. We brought a Bradley Smoker, an upright design, and it has performed much better than the Traeger. The Bradley also takes up much less space and we've placed it on a dolly so it can be rolled around. Overall, a much better solution.

Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.

The rest of the product we reviewed offered 6-in-1 features, but this one surprised us with its 8-in-1 cooking versatility. If an efficient smoker that can do multiple things is what you’re after, then there’s no need to look further. This could just be your top choice! The pit Boss Pellet Grill with Flame Broiler cooks almost all kinds of food with 100% genuine wood pellets. Talk about quality and quantity!

Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.


It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.

This is the single main advantage of a pellet smoker. Unlike charcoal, gas or wood fired smokers you don’t need to do anything with fuel except make sure it’s full when you start. This means no more having to go back and check fuel levels, no fluctuating temperatures, no spending ten minutes setting up charcoal and getting it at the right temperature, and no random heat variance giving you oddly cooked food ’cause you set it all up wrong.
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.
×