When looking at a pellet grill also consider the material its made from. A majority of pellet grills on the market are made from painted steel. However, the quality of that steel and the paint can vary. A good high-temp powder coat paint can stand up to high heat without blistering or flaking. This is essential, because once the steel is exposed, it will rust. Even if the grill body is painted well, you have to look inside. The fire pot and diffuser plate have the potential to corrode and are two of the most common parts that need replacing. With some painted steel grills, such as Traegers®, you can can upgrade the grill and hopper lids to stainless steel, as well as the firepot, diffuser, and drip pan.
Manufacturers advertise this piece of equipment as both a smoker and a grill, but it's best to think of it as a superb indirect-heat convection smoker, not a grill. Most models just don't do as good a job of searing a steak as a charcoal grill or even a gas grill with a sear burner can. You'll sear steaks better on a $20 hibachi than on most pellet smokers.

I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.


Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
Traeger Scout Known Defective Product Jul 30, 2018 New grill has extreme temperature fluctuations. Set T 350 gets as HOT as 548 and as COOL as 275. Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship. WHY ARE THEY NOT ADVISING DEALERS THAT THE GRILL SHOULD BE PULLED OFF THE SHELF? How many have been sold since they discovered this malfunction? Don't they value their loyal customers and their reputation? Cooking Capacity Performance Design Portability Durability Quality Ease of Use Temperature Control Features Value Packaging Versatility You are receiving this email because of your shopping activity at www.traegergrills.com. Your privacy is very important to us; review our privacy policy here. © 2016 Traeger Grills 1215 E. Wilmington Ave Suite 200, Salt Lake City, UT 84106
Although pellet smokers already have their own custom-made wood pellets with different flavor and blends, if you choose to moonlight your smoker as a charcoal smoker for some reason (maybe for a different experience or a cooking experiment), you can use it as a regular smoker using wood chips. Under such circumstances, it’s going to be worth learning a bit about the types of wood chips out there.

The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
The Pit Boss Wood Pellet Series offers superior The Pit Boss Wood Pellet Series offers superior cooking at an affordable cost. Fueled by 100% natural wood pellets Pit Boss grills use fan-forced convection cooking to perfect your BBQ experience. The PB340 features 341 sq. in. of porcelain coated cooking surface and is perfect for individuals or small groups. ...  More + Product Details Close
Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
We ended up going with the Memphis Pro. We were fortunate enough to be able to see all of the manufacturers and models I was most interested in, at Sam’s NW BBQ. (Yoder, MAK, Fast Eddy, GMG’s, a few others, and then, the one we ended up with, Memphis.) Sam took a good amount of time, providing us fantastic information about each model. We ended up with the Memphis Pro for the following reasons: 1) The construction, mainly the double-walled construction; 2) the preciseness of temperature, and being able to hold the temperature (due to reason #1); 3) the extreme ease of changing from smoking to grilling without a lot of effort or reconfiguration; 4) the double hoppers; 5) and another BIGGIE, the fact that grilled or baked foods taste like that, and not like smoked cookies, bread, pizza, etc.
Purchased my grill last fall at Costco, overall it works OK, some meats like Lamb Chops are just delicious. However, customer service seems to be deteriorating as the company is having success. My kids recently purchased me an add on to my Pro 34, a cold smoker. Traeger sells this but does not support it. The installation instructions are incomplete, I was sent parts that do not go with the unit, then customer service couldn't figure it out, this went on for weeks. After getting it installed, I asked for some instructions or recipes on how to use it, there are none. The old cover does not fit now, and Traeger does not sell one to go with a unit with a cold smoker, or plan on doing so. After a web search, I found one at Charbroil that kinda fits. Also, I just saw the same model at Orchard Supply, it now comes with more shelves and upgrades which I now have to buy as extras.
160ºF up to 500ºF temperature range for slow smoking to grill (25,000 BTU). Stainless Steel meat probe measures internal food temperature. Simple Ash Cleanout System (patented).Smart Smoke Technology. Stainless Steel fire box. Digital controller automatically maintains cooking temperature. Grease Management System. Blue LED digital temperature display..Bottom utility rack. Large, heavy wire grilling area dimensions: 19.5" x 22". Included warming rack provides (570 sq. in. total cooking surface).
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
I have owned this pit for over a year and a half now. I previously had a stick smoker which I achieved really good results with but it was time-consuming. But this baby takes it up to a whole new level.everything comes out amazing competition quality. My Family and friends are amazed by these results , The ribs and pulled pork are the best I have ever eaten. My brisket used to always come out average not on this machine.It's extremely juicy and mouthwatering. I would definitely recommend the top shelf and two side probe ports. The heavy duty cover is also top notch I have extremely Highwinds where I live here and the cover works perfect.everything that I have smoked has come out amazing. The juiciest turkey and chicken and even ham first class.I use mine all year even when it's 0° outside just amazed. Pull the trigger and buy this baby you'll never look back. Thank you Yoder for making a great product.

Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
Pellets work so well with the ease of use of a pellet grill because they’re 100% all-natural. They don’t have binders, chemicals, fillers, or petroleum products within them. They serve as a source of compact energy (8,500 BTU per pound) and smoke flavor. Most importantly, there’s little to no ash from them. Compared to coals, there are no flare-ups involved.
Just like your kitchen oven, a pellet grill must keep a consistent temperature in order to produce great food. To get tender brisket, the temperature needs to stay as close as possible to 250°F for the entire 12-plus hours its cooking. A pellet grill’s ability to do that is largely determined by its control board, which is essentially the brains of the pellet grill. There are different types of controllers, and their precision and consistency varies. Most can hold a consistent temperature in ideal conditions, but not all controllers can maintain a tight temperature in the cold, wind, and rain.

Another avenue that many pellet grill owners use is participating in a bulk buy of their favorite brand.  Many times by ordering as little as a thousand pounds of pellets and having them shipped via pallet can save enough per pound to be worth the effort.  Also, check the websites of the pellet brands listed above, many have local distributors that maybe with an hour drive of your location.  If you are new to the pellet world, the thought of ordering a thousand pounds of pellets may sound excessive or intimidating.  Many felt this way at first, but if you are in a location where it is hard to get pellets, the mantra of keeping at least a hundred pounds of pellets (five 20 pound bags) on hand at all times starts to make sense quickly.

Ready for the camp or cabin, this reliable, no-frills stove features two 30,000-BTU commercial-grade cast burners. The all-steel range features sturdy grates built to support hefty cast-iron cookware. It's surrounded by a three-sided steel screen to block drafts and grease splatter. The heavy-duty steel legs slide off for transportation and storage. Cooks up to 15 hours on a 20-lb. propane cylinder (not included). Includes hose and regulator.
You now know more about the perplexing pellet predicament, but where do you actually buy them?  Afterall, none of this matters if you cannot get them when you need them.  If you are lucky you have a local store that sells one of the brands mentioned above.  Definitely take the time to visit the web pages of these manufacturers and see what is available in your area.  If you are not one of the fortunate grill owners who live near an Academy Sports, Dicks Sporting Goods, Rural King, etc there is a chance your local Wal-Mart, Lowes or Home Depot may carry a reputable brand.
You want a set-it-and-forget-it option: Traeger grills work best when they’re allowed to cook and smoke the food over long periods of time. As long as the system has fresh wood pellets in the hopper to feed the fire box, it will be able to maintain a steady temperature. So you can set up the grill and then leave it for half an hour, a couple of hours, or even longer, something that’s difficult to do with other grilling systems.
In 1982 Traeger Heating in Oregon began experimenting with a furnace that would burn wood pellets made from compressed sawdust, a byproduct of the area lumber mills, and before long introduced a home heating system that they sold mostly locally. Since furnaces sold mostly in cold months, before long they began experimenting with a grill that would burn pellets, too. Eventually they created a device with an auger to feed the pellets and a blower to help them burn.
Is it common to have a lot of ash blowing throughout these pellet smokers? I thought it was supposed to be minimal ash and that it’s supposed to stay in the firepot. I noticed after two short cooks I have ash everywhere. The pellets are Perfect Mix from cookingpellets.com, but by “perfect mix” I don’t think they mean to mix ash from their product with your BBQ. Also, didn’t put off a lot of smoke, and really couldn’t taste any smoke at all.
Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
Remote Accessibility: This level of control and observing is critical on the grounds that the container does not generally sustain the pellets into the wood screw accurately and the fire in the firepot can go out. The Davy Crockett will tell you that the container is not sustaining wood pellets and that the temperature is dropping. The Davy Crockett application will reveal to you something isn’t right.
The built-in cords on outdoor cooking devices are often not long enough, and although regular household extension cords will work for rotisserie kits, they will not carry enough juice to keep you pellet smoker or electric smoker going. They could become a fire hazard as they heat up trying to deliver power to the unit. To extend the cord you need a large capacity cable as measured in amps. Here's how to figure out what you need:
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
Featuring a cast-aluminum rust resistant burner this stove Featuring a cast-aluminum rust resistant burner this stove is a versatile all around cooker. Perfect for any of your cooking needs from boiling and frying to Dutch oven cooking. Its compact size and portability make this stove a great side companion to add cooking space to your outdoor kitchen. Great ...  More + Product Details Close
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.

Manufacturers advertise this piece of equipment as both a smoker and a grill, but it's best to think of it as a superb indirect-heat convection smoker, not a grill. Most models just don't do as good a job of searing a steak as a charcoal grill or even a gas grill with a sear burner can. You'll sear steaks better on a $20 hibachi than on most pellet smokers.


When it comes to the material design of a pellet grill, the material is one of the most important aspects to consider for many reasons. First of all, the material has to be able to withstand extremely high temperatures and also be able to cook properly without the heat escaping the grill. With that said, the exterior or the grill has to be able to withstand high temperatures so the color does not peel, rust, or other defects. With that in mind, we discovered that all pellet grills have to be designed from some of the most important materials in the industry, so they can withstand the test of time. Alongside this, pellet grills are built to last so individuals can enjoy them for years to come. When it comes to the exterior craftsmanship of a pellet grill, the most common material is a powerful steel construction. Steel is also known as one of the most powerful and durable materials in the industry today. However, steel does rust if it is exposed to water. Therefore, many quality brands have powder coated the steel so it can be water resistant and does not rust easily.
You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.
I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!
×