I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down.  I did this routine a few more times with customer service and it kept shutting down, day after day.  Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts)  Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call.
I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.

I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.
The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.
I haven’t posted here before, but have been reading and finding a lot of good information on this site. I am in the market for a pellet grill so have been researching some of them listed on this site. Out of Yoder, Green Mountain, Memphis and MAK I really like price, features and looks of the Yoder YS640. I was wondering if anyone has used Louisianna pellet grills? For example, the CS680? I don’t see it mentioned much on bbq blog sites so not sure if it is a good brand. Thanks for any advice.
Hello.. You recommended a couple weeks ago to go with a GMG grill and that is the one I’m going with. I’m just a little torn between the DB and JB. They are only $150 apart but I’m not sure if the bigger size is worth the money when I can spend that on a cover and some pellets. Do you think the bigger size is worth it for a back yard smoker with the occasional party? I know people say bigger is better but I went bigger with my previous barrel smoker and it was much harder to keep an even temp with the bigger size. I would have went smaller given the chance. Thanks for any input!
The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.
To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
I id not purchase this item from Amazon, a local retailer had them on sale but none the less this a great smoker at any cost. I have compared it to the far more expensive smokers and I have found that this one has a much stronger, better built main body. The metal is of a heavier gauge of steel. Cheap smokers are separated from more expensive ones a lot by the electronic controls. Tis model has a control from 160 degrees up to 500 in 25 degree increments. It maintains a constant temp within a few degrees of where it has been set, always a problem on other smokers not of the pellet design I have used. Pellet consumption is modest and the Camp Chef brand pellets are the cheapest I have found. and work extremely well The ash cleaning system is a matter of dumping a cup after use with very little ash left over. The grease trap system is perfect. I see no reason to spend more for a pellet smoker that couldn't perform any better than this one. I would recommend it to anyone in the market for one. They are a set it and forget way to do your smoking.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
They are often called grills, but, at the time of this writing, I consider them to be primarily smokers. Almost all of them cook with indirect heat and those that try to grill over direct flame don't do it well. If you love steaks, there are far better ways to cook them. But if you love smoked turkey, ribs, salmon, pork chops, brisket, and smoked foods, a pellet smoker may be the best solution available.
You now know more about the perplexing pellet predicament, but where do you actually buy them?  Afterall, none of this matters if you cannot get them when you need them.  If you are lucky you have a local store that sells one of the brands mentioned above.  Definitely take the time to visit the web pages of these manufacturers and see what is available in your area.  If you are not one of the fortunate grill owners who live near an Academy Sports, Dicks Sporting Goods, Rural King, etc there is a chance your local Wal-Mart, Lowes or Home Depot may carry a reputable brand.
Most people recommend the Green Mountain Grills smoker for its affordability, despite its plethora of features including Open Flame Technology, which ensures that meats are thoroughly cooked. But what impressed us the most was its Sense-Mate feature. For a budget pick, we were surprised to see that it had some of the most advanced technologies that even the most high-end products use. There’s no denying that you’ll get more than what it’s priced at!
You want your smoker to retain heat and to maintain a constant temperature. If you purchase something that’s inexpensive, yet made with a thin metal, you’re going to regret it because you’re going to be constantly fighting with the temperature. You could purchase the best smoker pellets, but if you don’t have a high quality smoker, it is all for not.
Kevin, your recommendation rocked. The Pro is one of the best pieces of grilling and smoking iron I have had my hands on in a long time! Better than the Backwoods? Well depends on how much work you want to do! Maybe not, they are first class, but ease of use? I use the Backwoods a couple times a year, the Pro has already done 8 cooks in 5 weeks. Love it.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
When reviewing pellet smokers, we’ve gone through over 1000 different user reviews to get an accurate understanding of how useful the products have been to them. With that primary data in hand, we did an extensive online research on 65 products from 17 different brands popular brands. In fact, we even looked into three less known brands as well, but they failed to stand out. We left no stone unturned.
Cleaning and Maintenance: Keeping the grill clean is critical if you need to get the most out of the unit. Old debris can influence the viability of the unit thus normal cleaning is vital. In addition, while moving it around, take alert not to thump it since it accompanies little legs which can without much of a stretch tip over the unit when thumped.

If you get it that BBQ is more than burning hotdogs on a propane grill, you could likely benefit from The BBQ Beat podcasts. Kevin interviews the best Pitmasters in the country. They share their knowledge, stories, and experiences. There is something to be learned in each podcast. So if you're serious about your bbq, check out these podcasts. They are time well spent.
We’re people like you, people who love outdoor cooking—the food, the fun, the time with family and friends. We’ve turned that passion into expert knowledge and an unmatched selection of BBQ and grilling products. Any question, big or small, we can help. From your first click to your next call, whether you’re interested in backyard BBQ or an outdoor kitchen, we have what you need and same-day ship nearly every order from our huge in-house inventory.
Yeah it seems like no one is providing any input on it…I was interested in having them review it and do a direct comparison to some of these other grills. I made the mistake of getting a Myron Mixon pitmaster Q3 at sears. It turned out to be a waste of money and the slight humidity I had caused the pellets to burst and seize up the Auger. Anyway I had narrowed my search down to a rec tech or silverback but none of the reviewers seems to be giving it any attention.
It offers 700 sq. in. of cooking space and a powerful thermostat for a higher price, but makes up for it as soon as you start cooking on it. Also, it has a stunning design with the bull horns, which sets it apart yet again. But if you find yourself not spending as much and could do with a lesser cooking space, then the Camp Chef PG24 is a no-brainer for you.
I spent months checking out Memphis, Fast Eddy, Mak, and Yoder grills. I must say the Yoder is by far the most robust pellet grill of them all. I noticed many reviews with 3 or 4 star ratings for price and I must disagree; fit, finish, build quality, and material robustness of the Yoder was better than the Memphis Pro & Elite...and we all know how expensive the Memphis is.
A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.

Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more

Generally speaking cheap grills are not made with quality materials. While the outside may look good, often times you will find the guts of the grill are made with lower grade metals. This of course affects functionality and longevity. If the inside of the grill isn’t made using quality materials you will literally burn through it over a certain period time.


Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China.
A: As another key question that many individuals are asking for, users want to know if the grill is water resistant. Now, the inside of the grill in no scenario should be exposed to water. However, the exterior of the grill, once covered can be exposed to water. However, it is always best to ensure that the grill is powder coated and is able to withstand a bit of moisture, so it does not rust. If this is the case, then an individual will need a grill cover, which brings us to the next question.
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
The best way to ensure your pellet grill lasts for years to come is to purchase one that's built well and features quality construction. If you're in the store, lift the lid and feel its weight—is it flimsy or made from a heavier gauge steel? Pellet grills aren't like offset smokers, they don't need to be hefty, but they shouldn't feel delicate either. When you close the lid, see how it lays on the grill—are there gaps or is it flush, providing a good seal? Check out the joints, the hardware, and any welding—does the grill feel solid? It should be sturdy and all the joints and seams should fit together snugly, no gaps or spaces for heat to escape.
When you think of a portable smoker and grill, you think about basic features. But with the Tailgater by Traeger Grills, you get more than what most portable grills have to offer. At 300 sq. in., this portable grill is enough to cook decent and succulent dishes for small groups. It can even reach to a maximum 450 degrees F, so you’re never limited when it comes to the type of meat you want to grill or smoke. We loved its EZ fold legs, which make it easier to throw into the car trunk, ready for the next adventure.
The Traeger Lil-Tex 22 Wood Pellet Smoker and Grill impressed us the most with its “6-in-1” feature, which lets you braise, smoke, grill, braise, roast and BBQ all kinds of foods. With porcelain-coated racks, this durable grill offers top-grade function that you’d expect from high-quality pellet smoker grills. The smoker features 418 sq. in. of cooking area, enough to cook for medium-sized groups. But if that isn’t enough, other sizes are available, all offering the same functions. It comes with digital temperature controls, so you can leave it to take care of the rest while you relax and play. This durable pellet grill is 2nd not because it’s not as great as our first pick –the grill is a bit more costly that’s all.
Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.

I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
With modern advances in the outdoor cooking appliances due to their high demands, you too can cook up a great BBQ spread now with the help of a pellet grill! Gone are the days of overcooked and burned steaks. With the pellet grill on your backyard, you can BBQ to standards that even pit masters will approve. So today I will be giving you a 101 class on pellets grills, also including a list that will provide you with some great pellet grill review so that you can make the right decision when deciding to purchase one for you and your specific needs.

When I first noticed the BBL, with its attached cover, I thought that this would be something I'd eventually want. When it came up on sale, I ordered one after reading the Amazon description of what it would work on. I should have checked the Camp Chef website. This unit is designed for the stoves with the 14 inch capacity front to back--as in the two-burner models. The Amazon propaganda stated that it would fit both two burner and three burner stoves. My intent was to use it on one burner of my 3 burner Pro-90 model, and use the remaining burners with a Camp Chef griddle that I already had. I gave this 4 stars because it is useable, but you have to place the unit crossways over one of the burners. This leaves you with deciding whether to face the lid toward ... full review


Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.
Apart from the aforementioned problems, you might face some minor issues like the smoker staying hot for hours in the end even after your cooking is over and it’s turned off? It’s better to check out the backdraft preventing cooling fan for your grill. Although this wouldn’t cause any major issues with your grilling experience, it’s a safety feature that is always worth checking out and fixing.
In addition, due to the wood pellets used in the Traeger grill, it is easy to cook different food products even pies, something that is impossible with charcoal or propane fired grills like the big green egg grill and the camp chef grill, respectively. Moreover, it is hard to get consistent results with the big green egg grill, as some food might come out good while others will just burn. It is a great challenge to use the big green egg grill.

It has a cooking area of 800 sq. inches and a hopper capacity of 20lbs. While that just would be fine for regular smoking, this product needs some supervision and pellet refilling for longer smoking sessions. It does not have a Wi-Fi enabled control system, though it does come with a digital control system to provide you some ease of control while cooking with this product.

You want a set-it-and-forget-it option: Traeger grills work best when they’re allowed to cook and smoke the food over long periods of time. As long as the system has fresh wood pellets in the hopper to feed the fire box, it will be able to maintain a steady temperature. So you can set up the grill and then leave it for half an hour, a couple of hours, or even longer, something that’s difficult to do with other grilling systems.


The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
In the second year, the grill quit working. The auger turns and the heating rod gets hot but the grill shuts itself off within minutes. I think it is the controller but I've had the same experience as others: emails and phone calls to Traeger's customer service are unanswered. My wife just wants to return it to Costco but I'd rather fix it. Given the lack of response and the poor quality of the electronics, I'm starting to come around to my wife's point of view.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.
Hey Boyd, it’s really great hearing from you here. I am becoming a much bigger Traeger fan then I was in the past. They have done some excellent work of late on their Grill models. I really think they’re doing a lot of work too improve and restate their original value proposition. Their Pro Series models are excellent, and I believe that the directions the company is taking especially with getting back into the competition world will benefit both it and its customers… Like you… Long into the future.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂

The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.

The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
What makes it stand out from the crowd is that it’s the only pellet grill on the market (so far) that has an ash cleanout system… no more hauling out your vacuum to the patio to suck out the ashes when it’s time to clean out your grill! You just need a small cup… and with a simple turn of a small lever, the ashes drop out! You’ll LOVE this feature!
When a product is listed as Pre-Order, such product is not yet in stock but is available for advanced purchase on our site, prior to the manufacturer's public release date. Pre-Order items are shipped once in stock and the public release date arrives. You will be notified of a product's updated status by email. The expected shipment time is listed on the Product Detail page.

Hey Vernon – Yoder warranty is is 1-year on the igniter, 3-years on the control system and 10-years on the cooking body. Products manufactured by Memphis Wood Fire Grills carry a seven (7) year Limited Warranty from the date of purchase by the original owner against defects in material and workmanship. Electronic and electrical components carry a three (3) year replacement warranty when subjected to normal residential use. Limited Warranty does not apply to burn pot, meat probe, grill cover gaskets or damage caused by corrosion. The meat probe is under Warranty for 30 days from the date of purchase. (Both warranty blurbs were pulled from the respective company websites) Yoder: http://www.yodersmokers.com/pellet-frequently-asked-questions.html Memphis Grills: https://memphisgrills.com/warranty/


Tech geeks: A tech geek will also prefer a Pellet smoker grill and some of the latest grills including Green Mountain Grills came up with some exciting tech functionality like Wi-Fi! Just imagine, hanging with friends and monitoring your pork with your smartphone? You can increase and decrease temperature and control pellet feed without even touching the grill. This gives you the ability to cook while you work!

Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
It makes party hosting, as well as small crowd-feeding a breeze! Pellet grills are easy to use because they often come with easy temperature controls (along with other variable facilities depending from grill to grill), making it ideal for beginners who do not have prior grilling and cook-out experiences. A pellet grill is the answer to every cook enthusiasts who love to cook, but lack the knowledge and experience of skilled pit masters.
This heavy-duty top-notch grill and smoker has a total cooking area of 429 square inches, which is large enough for cooking around twenty burgers at once. If that’s not enough, it comes with a secondary rack of 144 square inches that you can use for smoking or warming. With a height of 32.5 inches, you can cook a variety of meats and foods to your heart’s desire.
Included meat probes and whether they’re programmable - Not every grill that can accommodate a meat probe comes with the probe. Some require you to buy it separately Also, not all meat probes and the control boards they connect to are created equal. Some are just for monitoring temperatures. Others are programmable—you can actually program the pellet grill to lower the heat when your food reaches its finishing temperature.
I say almost idiot proof because I still make stupid mistakes when I'm cooking and I like to blame it on the pellet grill once in a while. The unit is extremely easy to use for a novice such as myself. I just fill the hopper with my favorite wood pellets, set the temperature and add my food. I have owned this unit a little over a year and everything from the first burger I cooked until the smoked pork chops I just had for dinner has turned out really, really well. I find myself wanting to either smoke or direct grill everything. We have cooked pizza, turkey breasts, tri-tips, pork butts, burgers, salmon, cookies, brownies, chicken wings, drum sticks, pork chops, ribs, cornbread, vegetables, meatloaf and many other things. Nobody ever complains. LOL I have used it in all types of weather all year long. Once I learned how to use the damper (didn't take long) the heat stays where I want it and remains relatively stable even on the coldest days. I would buy this unit again and I would recommend it to others.

Remote Accessibility: This level of control and observing is critical on the grounds that the container does not generally sustain the pellets into the wood screw accurately and the fire in the firepot can go out. The Davy Crockett will tell you that the container is not sustaining wood pellets and that the temperature is dropping. The Davy Crockett application will reveal to you something isn’t right.


Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
An electric smoker and a pellet smoker, according to the reviews, both allow you to set the temperature and walk away. However, the flavor that you’re going to get from a pellet smoker is a lot stronger as compared to an electric one. Pellet smokers allow you a little bit more versatility than an electric smoker, whereas electric smokers are better at maintaining and controlling the temperature inside the cook box.
Today I grilled up a T-Bone steak. And I used the Grill Grates. I upped the temps to 600 degrees. The T-Bone came out FABLULOUS!!! Actually, it cooked faster than I expected, and the sear marks were way better than I expected. I have been using Weber Gas Grill for many years and way satisfied with the results, but the Yoder smoker kicks ass...BRAVO YODER!!

REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).
The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.
Perfect for traveling and tailgating, or even just a smaller patio space, the Traeger Junior Elite 20 is small in size, but delivers big wood-fired barbecue taste. Impress your friends by grilling, smoking, roasting, baking, braising, or BBQing at any tailgate or outdoor activity. The integrated Digital Elite Controller keeps temps within +/- 20 degrees F and makes setting the grill temperature as easy as turning a dial.
I've been BBQing and pit smoking for many years. About 4 yrs ago I tried out pellet grilling with an import brand, and had to rebuild and replace parts for 3 yrs until it was no longer worth it! I started looking at the YS640 about a year ago, and finally pulled the trigger on buying one. No gimmicks, No hype, this is the finest backyard pellet grill/smoker and wood fired sear machine on the market. The YS640 would also be right at home on the competition circuit as well. As many other reviews have stated, if your thinking about buying one, just do it. You will not be disappointed. Shes built like a tank and holds temp very consistently. From start to finish the staff at ATBBQ has been outstanding and professional, the unit arrived in only 1-1/2 weeks and was packaged securely on a pallet. Great American made product, and great customer service have made this one of the best purchases we've made in years, Thank you.
Second, It would be just my wife and me BBQing so I’m looking small. I’m considering the REC TEC Mini Portable Wood Pellet Grill (RT-300) after reading your reviews. Having only ever BBQed with hard wood coals on a Webber, is there going to be a taste fall-off going to the pellet grill as far as charring and/or smoke? I’d hate to spend that kind of money and get bland steaks. Really, steak is all we ever cook outside, though that would probably change with a nice grill.
×