Hi Mark – I’ve not personally used the Smoke Hollow Pellet Grill you mention here. The base model pellet smokers I see at stores like Sam’s and Costco are going to do fine for most backyard cooking preparations. I’d look into what the Smoke Hollow folks offer customer service wise. When you buy at the lower end, understand that the unit might not enjoy the longevity or durability of other mid-tier or higher end models.
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
I id not purchase this item from Amazon, a local retailer had them on sale but none the less this a great smoker at any cost. I have compared it to the far more expensive smokers and I have found that this one has a much stronger, better built main body. The metal is of a heavier gauge of steel. Cheap smokers are separated from more expensive ones a lot by the electronic controls. Tis model has a control from 160 degrees up to 500 in 25 degree increments. It maintains a constant temp within a few degrees of where it has been set, always a problem on other smokers not of the pellet design I have used. Pellet consumption is modest and the Camp Chef brand pellets are the cheapest I have found. and work extremely well The ash cleaning system is a matter of dumping a cup after use with very little ash left over. The grease trap system is perfect. I see no reason to spend more for a pellet smoker that couldn't perform any better than this one. I would recommend it to anyone in the market for one. They are a set it and forget way to do your smoking.
As you can see in this selection of pellet grill reviews, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet grills use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
The completed transaction enhances Vista Outdoor's position within one of the camping market's most attractive categories, complementing its already broad portfolio of 50 brands in shooting sports and outdoor recreation. Wholesale dollar sales in the camping category grew at a 6% Compound Annual Growth Rate (CAGR) from 2010 to 2015 (source: Sports & Fitness Industry Association). Camp Chef's sales growth has been fueled by a strong product development pipeline and user-friendly products.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord.  The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.

Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?
Every outdoor cooking enthusiast wants an affordable pellet smoker that has all of the key features that even a high-end unit would have. In most cases, this is just a dream and a result of false advertising, because most impressive smokers typically cost a hefty sum of money. The Z Grills Wood Pellet Grill and Smoker claims to be a reasonably-priced smoker that offers top-of-the-line features, and many users have agreed with those claims. With this pellet smoker review of the Z Grills Wood Pellet Grill and Smoker, we’ll find out if it really does what it claims to do.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.

With the internal temperature sensor, meat temperature probe, and a digital temperature readout, the PG24 pellet smoker takes the guesswork out of your cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The patented Ash Can Cleanout System makes clean up the easiest out there.

I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.
We did return the Traeger to Costco for a full refund. It's not that Traeger has poor customer service; they don't have any customer service. We brought a Bradley Smoker, an upright design, and it has performed much better than the Traeger. The Bradley also takes up much less space and we've placed it on a dolly so it can be rolled around. Overall, a much better solution.

I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.


When buying an item as important as a grill, it is evident that an individual should look for the best quality for what they desire as well as learn properly what are the best in the industry. With that in mind, pellet grills are even more unique than a regular grill because of the design and the way the grill functions. With that said, the quality of a pellet grill is the first criteria we took into consideration because there is a slew of different elements that have to ensure the grill is made of the best possible quality design. With that in mind, one important aspect of quality design that we took into consideration is how all of the functions are built. Meaning, we wanted to make sure that no area was designed and manufactured in a cheap way. Other than that, one method in which we figured out the best quality grills is how the grill cooked and how the items tasted. However, since we cannot buy every single grill and spend weeks cooking steaks and vegetables, as nice as that sounds, we relied a lot on individual reviews and what people had to say about that particular grill.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.

All the talk about made in China...... well it could have likely been made anywhere and inside the hopper it says "Tested". Well the LED display does not work correctly, i.e. not all the letters have all the LEDs light up to correctly state the temperature. The frame had a crimp in it on the front and when I closed the lid, it cam down crooked. It was not put on square with the grill. The warranty says that defective parts will be replaced, but the defective part has to be returned, pre-paid by me. That is B.S. This adds to my cost of the grill. Unless they pay for the return of parts, then it will just be fully returned to Amazon.
Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
Vista Outdoor will pay a total purchase price of $74 million for Camp Chef, comprised of $60 million in cash paid at closing and $14 million in cash to be paid out in equal installments on the first, second and third anniversaries of the closing date, subject to certain conditions described below. However, the effective purchase price is lower, due to value created by certain tax assets resulting from the transaction and the deferred purchase price structure, leading to an effective multiple of approximately 6.4x Camp Chef's expected calendar year 2016 EBITDA. Vista Outdoor financed the purchase price paid at closing using borrowings under its existing revolving credit facility. Vista Outdoor expects the acquisition to be slightly accretive to FY17 earnings per share (EPS), including impacts associated with transaction expenses. A majority of the payment of $14 million of deferred purchase price will be contingent on continued employment of key members of management and certain other conditions. As a result, Vista Outdoor plans to record the payments conditioned on continued employment as a compensation expense in future periods in accordance with GAAP. However, for purposes of presenting certain non-GAAP financial measures, including adjusted EPS, Vista Outdoor expects to treat those deferred payments as deferred purchase price and will therefore adjust the payments out of its financial results in future periods as payments are made. The purchase price will also be subject to a customary working capital adjustment. Additional information, including impact on full-year guidance, related to Camp Chef will be presented during Vista Outdoor's second quarter FY17 earnings call and webcast.
While there's not a lot to dislike about pellet smokers, it really comes down to your cooking/grilling style.  Some Smoking Geeks prefer pellet smokers to traditional smokers (or even the Green Egg style smokers) testifying that flavor is superior to that of other styles of smokers within the price range – and it's hard to argue with them.   While Traeger is the pioneer, there are other brands that give it a run for its money.
Another pellet smoker from industry leaders Traeger. The Lil Tex Elite is an upscaled Junior Elite, and whilst it’s still a good quality smoker and grill with a powerful burner and excellent heat output, plus all of Traeger’s usual electronic gizmos. There’s just not enough of a difference between this and the Junior Elite, especially not when you consider the increased price tag, which is disappointing.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
If you’re in the market to purchase a new pellet grill, you might be intrigued by all the grills and smokers on sale you see advertised locally and online. Let’s be honest, purchasing a pellet grill can be quite an investment and it may be something you have been saving your money for. That’s why it’s important that you take the time to research and educate yourself about not only the different brands of pellet grills but the price tag that’s attached to them. When you see a pellet smoker “on sale”, what does it really mean? Is the company really saving you money? Are you getting a good value? First, let’s take a look into the two different purchasing options you have when it comes to buying your new pellet grill.
With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
This is a great pellet smoker! With a few minor tweaks, this thing would be perfect. Ribs, brisket, chicken, pulled pork, sausage, you name it and it comes off of the grates awesome. I've had mine since 2012 and would recommend that you purchase a spare thermocouple in case your's bites the dust in the middle of a smoke (replaced my thermocouple twice since 2012). This thing is built solid with longevity as a guarantee. The customer support at Yoder is unbelievable as well. I have gotten phone calls from them at 8am on Sunday morning when my first thermocouple gave up in 2014. Made in the USA with a commitment on customer support that has been incomparable to anything I've ever purchased! It's a bit pricey compared to the competition but does an amazing job. "The Sauce", with Chef Tom, is a huge help for those just getting their feet wet in pellet smoking. He does an amazing job by keeping it simple and flavorful!
Whether you call them pellet grills or pellet smokers (the terms are interchangeable), there's no denying the impact these do-everything cookers are having on BBQ. In the past year alone, interest in pellet grills has grown at an astounding rate, with the number of online searches nearly doubling. Although they've been around for over thirty years, it's only recently that they've earned the title of the Hottest Product in BBQ.

As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.

×