Revising Product review to include photos! Excellent size and performs better than hoped for. Doe great job of smoking meats. Did a 12hr Pork Butt last weekend, tasty. Ran into a snag lately with the smoke stack though. Installed a aluminum patio cover over our deck $5,000. Now when I use my Traeger, the smoke has only a few feet to rise due to new roof over it. If windy, smoke billows in circles, trying to escape. And smoke will race into sliding door when opened. Experimented and came up with cure that works 100% excellent! Home Depot for 25ft roll of 6" Flexible Aluminum Duct. The 6" size goes over the hat on top of Traeger stack, pull down a few inches, wrap aluminum foil around bottom to seal. Other end over end of deck rail. Tried to keep as straight as possible, then trimmed to fit when expanded. Works like a charm and solved problem. Now smoke goes out end of 8ft long alum tube and out from under roofline, up into the air. No more smoke trapped under deck. With the flex alum tube, I can place it on East, West or North deck rails for smoke direction. Just thought I would pass this along as it did not effect the Traeger at all. Actually most likely helps with keeping air draft from entering thru smoke stack.
When you purchase this smoker, the cost is a bit more then some and less then others. Yet, I believe a great deal! One get's what they pay for. I believe this grill is a bargain at the price you pay. From the way it is shipped to me, I was throuoghly impressed with the attention to detail in packing and my receiving the smoker in perfect condition. It is a tank and the people I dealt with at All Things Barbeque, were first rate. If you have any questions, they would answer them. I plan on using the smoker in the next few days and can hardly wait. If the smoker works anything like the staff does at ATBBQ, it will be a grand slam! Kudos to everyone there and thank you for everything!
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.
The hook rack works great and is a must. The Towel holder works ok but does not work well if there a some wind blowing by. Wants to unroll the towel just enough to make it a possible fire hazard by the gind unwinding the towel rool enought that it can flip up over the wind gaurd and get in the flames. I have to remove it from the camp stove if there is any wind to avoid this problem.
As time passed, a thermostat was added to the equation, and the production BBQ smokers fueled by pellets working in “set it and forget it” fashion was in full force. From this point, several manufacturers of pellet grills began to pop up, with a few key names like Yoder Smokers, Mak Grills, Green Mountain Grills, and Fast Eddy’s Cookshack grills being among the most notable.
This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
Vista Outdoor is a leading global designer, manufacturer and marketer of consumer products in the growing outdoor sports and recreation markets. The company operates in two segments, Shooting Sports and Outdoor Products, and has a portfolio of well-recognized brands that provides consumers with a wide range of performance-driven, high-quality and innovative products for individual outdoor recreational pursuits. Vista Outdoor products are sold at leading retailers and distributors across North America and worldwide. Vista Outdoor is headquartered in Utah and has manufacturing operations and facilities in 13 U.S. States, Canada, Mexico and Puerto Rico along with international customer service, sales and sourcing operations in Asia, Australia, Canada, Europe and New Zealand. For news and information, visit www.vistaoutdoor.com or follow us on Twitter @VistaOutdoorInc and Facebook at www.facebook.com/vistaoutdoor.
You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
Hey Kim – thank you for this. I’ve had this happen with numerous pellet smokers, including GMGs. What happens most often when it happens is that I’ve been remiss in properly cleaning the grill out after several uses (vacuuming the fire pot out). This causes the ash etc to cover up the heating rod, thus making the temperature lower than expected. The auger keeps feeding the fire pot to compensate and you get what you’ve described.
Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
Wood pellet grills look like standard barbecue grills but some with a separate firebox for making smoked meats that will also let you smoke vegetables and other ingredients. As Traeger and Pit Boss both get good reviews from customers, it’s important that you look at the top features of this grills and how each company compares in relation to those features.
The Dyna-Glo Signature Series DGSS681VCS-D Heavy-Duty Vertical Charcoal The Dyna-Glo Signature Series DGSS681VCS-D Heavy-Duty Vertical Charcoal Smoker will satisfy your outdoor cooking needs. This Heavy-Duty Vertical Charcoal Smoker features a porcelain enameled steel charcoal chamber which keeps briquettes tightly packed for improved burn efficiency. The removable high capacity ash pan handles large amounts of ash facilitating hours of ... More + Product Details Close
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.
My wife and I were one of the first buyers of the YS640 in 2010. We had owned a couple of gas grills that, of course, eventually rust out. My wife saw the YS640 at the Kansas State Fair and called me and said that I HAD to look at this smoker! At first, the smoker had many problems--inaccurate temps, huge swings in temps, etc. Don and Joe kept working on the problems and installing updates--never charging us for updates or service calls. Finally, in about March of 2011, they installed the update that really was the solution. Since then, the YS640 has been a consistent workhorse that does everything as advertised. Built like a tank. built to last. Don and his staff stuck by his product and by his customers. In this day and age, customer service is uncommon. By the way, I thought the YS480 would have been big enough, but my wife said, "our family isn't getting smaller,".....I'm very glad we got the 640 and the second shelf. I have needed it many times. Thanks Don!
My traeger has had some good moments but it very unreliable. I really do not enjoy cooking with it. I have no confidence in the temp readings and the smoke control. Every time I open the lid the temp drops like 200 degrees. I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf? I thought this POS was supposed to be a set it and forget it type smoker. Very unreliable. Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down. The pellet feeder is garbage. It will all the sudden just start smoking like crazy because the pellets have jammed into the burner. Completely ridiculous smoker. I use it still but only when I can sit and watch the feeder. The guys comment below is true about the feeder always just using the middle pellets. I always have to check it and push the pellets to the center. Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
Of all the different smoker designs available, pellet smokers are the easiest to use, because they're thermostatically controlled, like your kitchen stove. You just select a cooking temperature, and a controller maintains it by feeding wood pellets to a fire pot as needed to maintain your set temp. Set it and forget it. You can throw a brisket in a pellet smoker, set it for 225°F (105°C), go to bed, and sleep like a baby, knowing you'll wake up to delicious smoked meat.
While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.