Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
The Pit Boss Wood Pellet Series offers superior The Pit Boss Wood Pellet Series offers superior cooking at an affordable cost. Fueled by 100% natural wood pellets Pit Boss grills use fan-forced convection cooking to perfect your BBQ experience. The PB340 features 341 sq. in. of porcelain coated cooking surface and is perfect for individuals or small groups. ...  More + Product Details Close

When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at pitmaster@grillagrills.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
Hey Vernon – Yoder warranty is is 1-year on the igniter, 3-years on the control system and 10-years on the cooking body. Products manufactured by Memphis Wood Fire Grills carry a seven (7) year Limited Warranty from the date of purchase by the original owner against defects in material and workmanship. Electronic and electrical components carry a three (3) year replacement warranty when subjected to normal residential use. Limited Warranty does not apply to burn pot, meat probe, grill cover gaskets or damage caused by corrosion. The meat probe is under Warranty for 30 days from the date of purchase. (Both warranty blurbs were pulled from the respective company websites) Yoder: http://www.yodersmokers.com/pellet-frequently-asked-questions.html Memphis Grills: https://memphisgrills.com/warranty/
There’s so much about this grill to love, but one aspect that gets RAVE reviews is the customer service. Rec Tec has pretty much the best customer service in the industry. First off, there’s a 6 year warranty, meaning, they expect their product to perform. But in the unlikely case that you have issues, their customer service is incredibly fast to respond, is available even on the weekends, and believe it or not, the owners even provide their cell phone numbers so they can help you through a problem when you’re stuck. Incredible!
My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.
While the exterior is certainly whimsical, this smoker is serious business, with a proprietary Digital Pro Controller that maintains even cooking temperature, just like an oven. Dual meat probes let you monitor the pork and the chicken at the same time, and 425 square inches of grilling space means you can easily feed a crowd. The 11.5-pound hopper holds plenty of pellets, so you won’t need to refill for many hours.
I've been wanting a Yoder for the last year and a half. Finally pulled the trigger on a 640 a couple months ago. Absolutely fantastic. I've been a Weber guy forever and this is my first smoker. This defiantly took my food over the top. My 640 has been incredibly accurate with keeping the heat on the grate to the setting I punch in. Just finished my first brisket and it was fantastic. The only way to go!
Wood pellets are small pieces of hardwood made from compressed sawdust from hardwood. Generally, some wood pellets made for room heating and stoves are produced using some form of binding agent like glue and other additives, which would leave a bad taste and flavor when used for cooking. However, for modern-day grilling, wood pellets are made of pure wooden sawdust and sometimes a little bit of vegetable oil to help it burn. So, nowadays, wood pellets are even better than the real wood chips for grilling.

However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.

The Dyna-Glo Signature Series DGSS681VCS-D Heavy-Duty Vertical Charcoal The Dyna-Glo Signature Series DGSS681VCS-D Heavy-Duty Vertical Charcoal Smoker will satisfy your outdoor cooking needs. This Heavy-Duty Vertical Charcoal Smoker features a porcelain enameled steel charcoal chamber which keeps briquettes tightly packed for improved burn efficiency. The removable high capacity ash pan handles large amounts of ash facilitating hours of ...  More + Product Details Close
If you have faced or currently face the problem with common things like pellet feed jamming or wear and tear of your smoker, then replacing the exact component will solve your problem. Thus, without changing your whole smoker you can continue with some $40 – $50 changes. It might seem complicated for you if you face a problem with your digital control system. Adding the element of professional knowledge will help tremendously. Solving problem with $150 is much better than spending $500, right?
Yes, no one likes to read the instruction manual. But there are many advantages of learning the specifics of your grill and reading the manual is key. Generally, you should not use water to clean your pellet smoker, so keep your hose pipe far away. These smokers have digital controllers, a motorized auger, a fan and an igniter rod for the fire pot. These parts will get destroyed if they come into contact with water. You should gently dry scrub the dirt off these parts, making sure not to disassemble any parts. Cleaning the thermostat will also prove to be essential; otherwise, it may read internal temperatures inaccurately.
As the last criteria that we took into consideration, we have shared this a couple of times but we really wanted to focus on variety. We not only wanted to share some of the best tops of the line brands in the industry but we also wanted to share brands that may be unknown but offer excellent craftsmanship and material design. For instance, some of the grills we have shared are perfectly designed for everyday use, while some are designed for large events and parties.
This is well worth the money. I'm a Weber charcoal guy for steaks and chicken and only used my old propane for baked potatoes, corn and asada. Fired this thing up and my asada was fast and easy to make. Philly cheesesteak was fast and simple. Large cooking surface lets you do a lot and it heats fast and evenly. Just make sure if you have kiddos around they keep their hands clear of the flat top! As of yet I haven't cooked on the grill grates so can't say anything about that. Putting this together was simple and took me about 20 minutes. On a side note one of the threaded tubes for a wheel broke loose when I put the wheel on and this was due to a very poor tack weld holding it. I contacted camp chef customer service and took a pic of the defective part and within 2 business days replacement part arrived. Excellent customer service. This thing will get a work out this summer! If your looking for a cover for this it can be a pain and I bought a patio furniture coffee table cover that is close to the grill demisions and it fits perfect.
Fast forward to today.   Finally got my new Traeger running again.  Had an issue with the smoker temperature.   So I called the toll free Traeger customer service line.   Low and behold, who answers my call at Traeger customer service?  Frank!   He is still nasty and ended the conversation with "Hopefully you do not burn your grill up again!"   Nice guy!   Dude, being a smart aleck didn't exactly earn you any points.  You should be ashamed of your self!

In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?

love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
-Warranty-(Forgive my soapbox here, folks.) I'd give it 5 stars if Camp Chef would give it a real warranty. One year is pathetic and WAY below the industry standard. Camp Chef, I know you are reading this because you guys are too excited about your great new product to not pay attention to feedback like this. Nut up and stand behind your awesome product. Why would anybody buy a product from an industry newcomer with no track record when you yourself are only willing to stand behind it for 1 lousy year?... Especially when the "industry leader" will guarantee their product for 3 years?!?! You are communicating that you have 1/3rd the amount of trust in your product that Traeger does. That's terrible! You should exceed what they are offering just to make the point in the industry! At a minimum, you should at least match their warranty just so it doesn't become a stumbling block to potential customers. Look, you basically took the lil tex and said "ok boys, so how can we make this better?!?" You did that! You totally knocked it out the park! Why cheap out with the warranty?!? As a customer, it makes me nervous that you know something I don't.
My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).
Although pellet grill smokers are more expensive than your regular electric smokers, they come with great convenience as they do not demand your undivided attention. Now although there are a lot of reviews online available about pellet grills in general, none of them provided in-depth information about different models of Traeger Grills. So we decided to take on the challenge!
Is it common to have a lot of ash blowing throughout these pellet smokers? I thought it was supposed to be minimal ash and that it’s supposed to stay in the firepot. I noticed after two short cooks I have ash everywhere. The pellets are Perfect Mix from cookingpellets.com, but by “perfect mix” I don’t think they mean to mix ash from their product with your BBQ. Also, didn’t put off a lot of smoke, and really couldn’t taste any smoke at all.
Is it customization? I called before I order my YS640 and told them I wanted my grill grates made out of expanded stainless steel, and a few other small things done to ""personalize"" my grill so it was just the way I wanted it. ""No problem. The added materials will cost extra, and shipment will a week so we can fabricate your grates."" Try getting that with a Chinese import!
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.
You are worried about flare-ups: When grilling fatty types of meat on a propane grill, you run the risk of having flare-ups, where the flame gets too high and too hot, burning the meat. You have to keep a close eye on the propane grill to guard against them. But with the Traeger grilling system, the even distribution of the heat and the indirect heating system prevent this problem.
I had to cancel my order today. I called this morning, however no one at their office could provide a satisfactory answer or response to my order. I actually was asked to provide a second copy of the invoice pink slip which I had already done so. Very disappointed with your company's sales rep that sold me the smoker at the Timnath Colorado store location. She guaranteed that the grill would be shipped out in three days and I would receive it before Easter, my daughter's birthday weekend for a party.
With that said, depending on the size of the green an individual may need more pellets to fuel the food. However, a bigger sized pellet grill allows the cook to grill for a large number of people. While a compact grill can easily be taken anywhere. With that in mind, one important criterion that we wanted to take into consideration is how easy the item is to set up.
The Champion Competition Pro Wood Pellet Grill and Smoker by Louisiana Grills takes outdoor cooking versatility to all new heights. A total cooking area of 3432 sq. in. (8718 sq. cm) and fully integrated multi-chamber smoking cabinets, the Champion Competition Pro is designed to be a show stopper. With direct and indirect flame grilling in the main barrel, hot smoking in the lower smoke cabinet, and cold smoking in the upper smoke cabinet, the Champion Competition Pro is the ultimate grill for the outdoor barbecue enthusiast. This grill revolutionizes grilling in three different ways: the digital control center and lid thermometer allows for precise temperature control of a dynamic range of 60°F-600°F (15°C -177°C) for grilling and smoking, the use of all-natural hardwood pellets allows you to enjoy the amazing wood flavor with the single push of a button, and a programmable meat probe that works together with the digital control center to regulate temperature.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.

With their portable model, Traeger has their own version of the classic 'tailgater'. Still fairly hefty at a little over 60 pounds, this grill is still far and away the most lightweight model Traeger offers. The legs fold up for ease of storage and transportation. As with all other Traeger products, temperature controls allow grillers to use the Tailgater as either a conventional grill or a smoker.
I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!
×