Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.
Never worry about overcooking or burning your food. Masterful control of airflow throughout all chambers allows you to skillfully prepare food with savory natural hardwood flavor. Our propriety exhaust system makes for even grilling and smoking in the main grilling chamber, and sliding damper vents allow great versatility and control when using the upper and lower smoke cabinets. The fan-forced convection airflow in the main barrel allows the grill to work like a convection oven with indirect flame cooking, while the sliding plate on the flame broiler gives the option to sear a steak using direct flame cooking when desired. The removable upper cooking racks in the main barrel adds additional cooking space: cook dinner on the bottom and prepare vegetables and dessert at the same time on the top racks.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.
Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®.
Joe Traeger designed and developed pellet grills back in 1985 and he patented the design one year after. But these didn’t go into full commercial production until 1988. Because of the patented design, Traeger held a monopoly in the pellet grill market for twenty years. But being a small family-run company, they did not diversify and kept supplying their products only to a select network of stores.
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?
But if you like the idea of a wood pellet grill, one of the oldest names in wood pellet grilling is Traeger, which developed some of the first units to use this technique three decades ago. Having that name recognition gives Traeger a leg up versus some of its competitors. And for the most part, Traeger’s grills live up to what consumers expect from this established brand, providing good design and longevity. They don’t typically match up with the higher end models currently on the market in terms of precise cooking temperatures, but Traeger is a nice mid-range product with several price points available.

Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).

With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.
Any retail store that you visit, regardless of the product you are intending to purchase, has a supply chain that these products go through before reaching their final destination. There are certain costs associated with getting the product from the manufacturer to you that get tacked onto the price tag of the product. These additional costs can include aspects such as transport fees, warehouse handling, packaging, and display. Therefore, the price tag you see when the product reaches you isn’t just covering a small margin on top of the absolute base price of the product. It has been marked up to cover the additional costs listed above in order to reach you.
The Camp Chef PG24S lets you set the smoker to your desired settings so you can leave it to relax while it does the rest for you. With an advanced digital temperature chip, it steadily monitors the temperature, achieving a constant cooking temperature at all times. Dual LED temperature displays allow you to easily check the temperature of the food kept inside your smoker without losing any heat. With an auto-dispensing pellet hopper that can hold around 18 pounds, your pellets are used efficiently. The grill can work in temperatures that range from 160F to 400F.
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?

I love the taste of smoked food. I have now tried, ribs, turkey, chicken, and steak on my traeger grill and would have given them one star if not that smoked meat taste great. Everytime i use the grill, something that isn't supposed to happen, happens. I have to go out and check the pellet hopper every half hour to make sure it doesn't just use the pellets in the middle, so I have yo mix them around. Even when I do that, I can have the grill set for 225 and it goes up to 400-500 degrees or catches fire. Then when I restart it, it sometimes cools down to below 150° and shuts down in the middle of my smoke. I'm very dissappointed because the grill was not cheap, the pellets aren't cheap, and the food I am.ruining isn't cheap. I know traeger isn't going to do anything about it because I have called and they gave me "reasons" all of these things happen, and they already got their money from me but I am hoping I can deter as many people as possible from overspending on a defective grill. I really do wish it was a good product because I don't have the money to buy another.
Never worry about overcooking or burning your food. Masterful control of airflow throughout all chambers allows you to skillfully prepare food with savory natural hardwood flavor. Our propriety exhaust system makes for even grilling and smoking in the main grilling chamber, and sliding damper vents allow great versatility and control when using the upper and lower smoke cabinets. The fan-forced convection airflow in the main barrel allows the grill to work like a convection oven with indirect flame cooking, while the sliding plate on the flame broiler gives the option to sear a steak using direct flame cooking when desired. The removable upper cooking racks in the main barrel adds additional cooking space: cook dinner on the bottom and prepare vegetables and dessert at the same time on the top racks.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only Picnic Time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ...  More + Product Details Close

The hopper capacity is the same as the Traeger Lil’ Tex Elite 22, but what sets it apart is the “Pellet Hopper Drain Chute Technology”. So if you are looking to try a different wood or just storing the grill for a long time, then all you need to do is hang a bucket on the chute and pull out the knob to catch the pellets… and before you know, the tedious task will be over, leaving you with nothing but love for your Camp Chef Grill.

So far this smoker is fabulous! There is a learning curve, and this is not a "set it and forget it" smoker. You have to make sure you don't run out of pellets as the smoker will shut down. Tried a pork butt, but I wasn't watching it close enough, so I had to finish it in the oven. Still delicious. Next made some boneless skinless chicken breasts which turned out wonderfully.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
Local availability of pellets is only one problem though.  How are you, the consumer, supposed to know which is a good pellet brand versus a bad?  If you do a Google search for “where to buy pellets” you are likely only to see a lot of advertisements all proclaiming their product to be the best.  This situation is very akin to what consumers in the charcoal industry deal with as well.
In some ways, it’s surprising that something so small could be the culprit behind so many problems on a hi-tech cooker like a pellet grill. Then again, pellets are your grill’s fuel and using bad pellets is like using subpar charcoal in a kamado, and it can cause the same problems—too much ash is produced, making it hard to hold a steady temperature and snuffing out the oxygen supply to the fire.
Revising Product review to include photos! Excellent size and performs better than hoped for. Doe great job of smoking meats. Did a 12hr Pork Butt last weekend, tasty. Ran into a snag lately with the smoke stack though. Installed a aluminum patio cover over our deck $5,000. Now when I use my Traeger, the smoke has only a few feet to rise due to new roof over it. If windy, smoke billows in circles, trying to escape. And smoke will race into sliding door when opened. Experimented and came up with cure that works 100% excellent! Home Depot for 25ft roll of 6" Flexible Aluminum Duct. The 6" size goes over the hat on top of Traeger stack, pull down a few inches, wrap aluminum foil around bottom to seal. Other end over end of deck rail. Tried to keep as straight as possible, then trimmed to fit when expanded. Works like a charm and solved problem. Now smoke goes out end of 8ft long alum tube and out from under roofline, up into the air. No more smoke trapped under deck. With the flex alum tube, I can place it on East, West or North deck rails for smoke direction. Just thought I would pass this along as it did not effect the Traeger at all. Actually most likely helps with keeping air draft from entering thru smoke stack.
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)

Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods! 🙂
All the talk about made in China...... well it could have likely been made anywhere and inside the hopper it says "Tested". Well the LED display does not work correctly, i.e. not all the letters have all the LEDs light up to correctly state the temperature. The frame had a crimp in it on the front and when I closed the lid, it cam down crooked. It was not put on square with the grill. The warranty says that defective parts will be replaced, but the defective part has to be returned, pre-paid by me. That is B.S. This adds to my cost of the grill. Unless they pay for the return of parts, then it will just be fully returned to Amazon.
Do you enjoy hassle and stress-free living? If you want to enjoy the juicy smoked BBQ ribs with your friends and family without feeling disturbed, then the automatic smoker is the top choice for you. The automatic smoker, a pellet smoker, makes for an ideal choice. Do you know why it has it has earned the reputation of the best among all the easy to use smokers? You will find the automatic features incredibly easy to use and this convenient product’s simplicity stands out.
You want to easily switch to different smoky flavors: Changing flavors in your Traeger grill is as easy as changing the pellets that you place in the hopper. Through its website, Traeger offers several different smoky flavors of hardwood pellet offerings, including hickory, mesquite, apple, maple, cherry, and oak. And Traeger’s website provides information on which types of hardwoods provide the best smoky flavor for certain types of foods, which can help you successfully use this grill immediately out of the box.
Our Privacy Promise, Terms of Service, Code of Ethics. AmazingRibs.com promises to never sell or distribute any info about you individually without your express permission, and we promise not to, ahem, pepper you with email or make you eat spam. We are GDPR (the General Data Protection Regulations as passed by the European Union). GDPR requires that we be willing to delete any info we have about an EU resident if you request it. We go a step further. We extend this right to anyone, EU resident or not. For more about our privacy promise, code of ethics, terms of service, and how we operate to insure you unbiased info, click here.
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
With the Camp Chef PG24S, you won’t have to constantly refill your hopper. Your pellets will be used as efficiently as possible, as this product comes with a hopper that can hold up to 18 pounds of wood pellets. With the digital heat control system, it instantly feeds the pellets into the grill to maintain the ideal cooking temperature. This ensures that food is cooked most satisfyingly.
It is almost as we have forgotten how to live life the way it should be lived. We no longer have the time to sit back on a summer’s day, and appreciate the show that nature has put up for us. Now-a-days we are so committed to our work, responsibilities and duties towards the external that we often forget that we have our very first priority neglected: happiness. We are so engaged in our daily 9 to 5 routines that we have actually began to take it as a way of living while it slowly drains and strains us away over time. 

You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
Hey Jeff – I think that due to pellet smokers requiring much of the wood pellet for “fuel” leaving a smaller part for the “smoke” means that you want as much of the smoke to stay in the chamber for as long as possible. Just my opinion. I’ve not used charcoal pellets. Those I’ve spoken with who have used them weren’t extremely happy with the results. Regarding the water pan, I feel that pellet smokers don’t typically require water pans. However, you can surely use one and see how your results go.
Wood pellet grill is a two-in-one mixture of a smoker and a grill. It doesn’t provide direct flame for your steaks or meat as a grill would which eliminates flare-ups. Since there’s no direct flame, searing meat isn’t an option and there’s a better choice if this is your desire. However, if you desire a great smoky flavor with an easy cooking process then a pellet smoker is an excellent choice.
A: As one of the most frequently asked questions, consumers want to know if the grill comes with a grill cover to protect the grill. With that said, most brands do have a grill cover when it comes to the grill. However, it is important to always as the manufacturer if they include a grill cover with the purchase. In most cases, the grill cover is made from some of the best materials in the industry for durability and functionality.
I'm a certified BBQ Judge and found the following; The new portable Traeger Ranger seems to be not well thought out. All the cooking directions are for the large units and over cook everything in the smaller unit. All the pellet smoke is wasted, it is drawn out the back vent and very little ever reaches what you're cooking. They have a grease bucket on the back that is supposed to catch the grease but doesn't, Grease coats the inside of the bbq and runs down the sides and out of the grill landing on whatever you have the grill on. I've been using this Traeger Ranger since June 18, 2018.
This is obviously no revelations that temperature is the first on my list. When it comes to cooking appliances, temperature is always a key factor. However, it is not the sole reason to be on my list. The thing about temperature you need to look for in a good pellet grill is its ability to control, change and maintain it. Any grill can turn screaming hot, but only the best ones provide you with multiple temperature settings, and are able to maintain it constantly to ensure an even cooking surface where it is not too hot on the left and cold on the right. Many pellets come with special, even patented, temperature features.

In the second year, the grill quit working. The auger turns and the heating rod gets hot but the grill shuts itself off within minutes. I think it is the controller but I've had the same experience as others: emails and phone calls to Traeger's customer service are unanswered. My wife just wants to return it to Costco but I'd rather fix it. Given the lack of response and the poor quality of the electronics, I'm starting to come around to my wife's point of view.
The first thing we have to understand is the anatomy of a pellet smoker. Check the related section on this page to get the idea. Once we know which part goes where, the bigger battle will be won. Next, we’re going to have to be able to analyze the problem if we are to solve it. What seems to be the issue? Are the pellets not lighting up? Are the pellets getting stuck and not working properly? Weird noises coming out from the hopper? Are foods not cooking well? Let’s take a look at these problems and how to solve them:

It doesn’t matter what it is that you’re buying, you want to get the best bang for your buck and not pay more than you have to. We all have this same mentality when it comes to making a purchase. This is why when we see price tags that indicate something is “on sale’, we immediately think we are getting a good deal. But is that really the case? The answer is no. When it comes to buying your new pellet grill “on sale” from a distributor or retailer, it means that they are essentially reducing the markup that you have to pay. Aside from the rare instances where a retailer is selling a product as a loss leader where they are intentionally losing money on a product to get you into the store and buy other more profitable products, you will still be paying more money in the end than what the manufacturer would price the grill at if they were to sell it to you directly.
There is information overload when it comes choosing a pellet grill. This makes it very difficult for most people to make up their mind on a single grill. Getting back to why you can trust us then to get you the best grill? because our backyard grillers have based their unbiased opinion on these different Traeger grill reviews after months of experimenting and research on customer reviews and satisfaction.

The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.
Local availability of pellets is only one problem though.  How are you, the consumer, supposed to know which is a good pellet brand versus a bad?  If you do a Google search for “where to buy pellets” you are likely only to see a lot of advertisements all proclaiming their product to be the best.  This situation is very akin to what consumers in the charcoal industry deal with as well.
For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!

You need some temperature control in your grilling system: Even though most propane and charcoal grills include a temperature gauge, they’re not precise. Because the pellet Traeger grill works more like an oven, cooking at a precise temperature setting is a lot easier to do. It’s not quite as precise as the oven in your kitchen, but the Traeger system’s temperature control is surprisingly accurate most of the time. Some manufacturers of low cost pellet grills only offer low, medium, or high temperature settings.


Please Note: If you select Express or Expedited shipping, your order must be received and credit must be approved by 12:30 p.m. EST, or it may not be processed until the next business day. Expedited shipping is available for select products. You can view complete shipping options for your product in your shopping cart. The estimated delivery date for your order will be provided on the order review page prior to completing the order.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills
×