The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
I have used mine Traeger 15 times and it hasn't worked once. I will not hold the temp within 15 degrees as they state. I can set mine to 225 and will go between 180-370. It also consistently shutting itself off with the same error. I have spoken to cust service 12 times and they are worthless. I have had new controller sent and other various parts. I have been on the phone with them for hours. I always have to take my meat off and finish it on my Weber. They refuse to send me a new one. They still demand to go back through the same damn steps as the last 12 times to debug it. Never again. If you see my post on Craigslist, don't buy it, it's a lemon that Traeger will not support.
Hey Dan – I think you’d really up your versatility with a good pellet smoker. Smoke profiles seem to depend largely on the quality of pellets used and then also on the burn consistency of the fire pot. What I mean here is that many pellet smoker users tell me that they prefer models that cycle over faster with frequent temp checks rather than those with longer wait times between temp checks. Cycling faster means that pellets burn more consistently and do not rest to a “charred” state and they “reactivate” This latter problem sometimes results in less than optimal flavor. Yoder smokers cycle very fast and are preferred by many due to this and their thicker metal construction.
Big Horn’s largest available grill, the XL 1093 comes with a large cooking area of 1093 sq inches. With it’s low price tag of around $300 and a high cooking area, this product could have been a great choice for pellet smokers. However, we’d rather not suggest something that’s susceptible to rust and weather conditions to be kept outdoors at all times.
Your choice of the pellet can also dictate how much cleanup you’ll have to deal with (even though generally 10 pounds of pellets can produce at most half a cup of ash, but this varies from pellet variant to pellet variant). Just be warned that when the temperature is high, there’s not much smoke happening, so you need to smoke out your meats at lower temperatures to get that smoky flavor.
If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.
Ease of Use: At first, the unit appears somewhat mind boggling to use however when you get over it the first occasion when it turns out to be very simple. For one thing, there is a get-together video instructional exercise from the maker’s site for a less demanding get-together. Else, anybody that has used a BBQ before wouldn’t have any type of trouble with the unit.
I’ve seen a lot of pellet smokers over the years, and it’s easy to say that out of every one, the RecTec is without a doubt a beast. It combines exceptional cooking performance with fantastic build quality and a thoughtfulness of design that you just don’t see in other smokers. Or a lot of other products. Not only that, but it’s one of the easiest smokers I’ve ever used, with professional quality cooking literally at the push of a button
I purchased my first Traeger Grills over a year and a half ago and now I am on my third grill. I have had the most amazing experience grilling, smoking and baking. I do everything on my Traeger. It accurately holds the temperature, starts up automatically and has convection which cooks my food evenly and thoroughly. I recommend this grill to anybody who’s looking for a amazing cooking experience with little effort and really likes to show off to their friends how good their food tastes. My favorite part is being able to walk away from the grill and not have to babysit it so I can do overnight briskets without even checking them. I love it.
What we loved most is that it has a trap door to allow burn pot cleaning after every cooking. It lessened our job of cleaning this pellet smoker by 60%. It is more than amazing because from our research we know that a feature like this will cost twice as much as the Camp Chef. Honestly, this has emerged as our key point when we selected this smoker to be the best in our review.
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.
The smoker does not hold temperature. I called the service dept and they sent a new controller card and it does not hold temp either. When I contacted the service dept they told me that the grills do not hold temp at the 225 degree setting. If you look at all the Traeger literature and cookbook and recipes all say to smoke at 225. As does every other smoking cookbook. So Traeger manufactures and sells a known defective product. DO NOT BUY TRAEGER.
At the peak level of outdoor cooking, the Champion Competition Pro is a rugged grill and smoker with extensive features that come standard. Clean-up is a breeze with the heavy-duty, porcelain-coated cast-iron cooking grids. Known for superior heat retention, cast-iron makes searing easy. Other features include the stay-cool handle, side shelf with tool hooks and bottle opener, bottom cabinet for storage, robust locking caster wheels for easy movement, and a heavy-duty 14-gauge powder-coated steel finish. Sear or smoke, bake or roast: discover the taste of real wood-fired flavor with the Champion Competition Pro. Comes complete with a weatherproof grill cover.
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Access to electricity has its downfalls. First, if the cord isn’t long enough you will need to make sure you have a proper extension cord. Using the wrong cord is a fire hazard. Do the math (watts / volts = amps) and make sure you have the right extension cord. The smoker is also less mobile, and if it's stored outside it absolutely must have a cover. Electrical components and weather don’t mix.
Purchased the YS640 about a month ago. So far I have cooked nine pork butts, three racks pork back ribs, one beef brisket and four thick cut New York steaks on it. I am very pleased with the results of these cooks. I have an upright propane smoker, Weber kettle, propane grill and so far the YS640 has out performed all three of those in ease of use and flavor performance. I can get almost the same flavors with my others, but takes more work and babysitting. Also want to mention that the YS640 is built to last. I noticed the ruggedness and excellent USA craftsmanship immediately upon arrival. Some reviewers think maybe the YS has a steep price, but I think its justified due to its construction and craftsmanship. It would be difficult to make something of this caliber for any less. A couple minor things to note is you will have to play with the damper a bit to learn the heat distribution, but after learning it, its not a problem. Doesn't put quite as strong as a wood flavor on the food as my upright propane smoker, but it puts the right amount and I have no complaint here. I would and have already recommended the YS640 to friends and acquaintances. If you have spent long hours smoking foods and know the correct flavors that they should be, your not going to be disappointed with this cooker!
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.
I have always been a believer: “do what you love and you’ll never work a day in your life”. I’ve been lucky enough to use my professional experience in the meat industry over the past 20 years to create a business where I love to go to work. Smoking Meat Geeks is all about bringing people together that enjoy food as much as I do. We provide a place for everyone to share thoughts, ideas, and recipes; to be a go-to spot for cooking inspiration. Feel free to leave a comment, say hello, or provide any tips. There is no right or wrong input, as long as you’re engaging, you’re a Meat Geek!
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).
160ºF up to 500ºF temperature range for slow smoking to grill (25,000 BTU). Stainless Steel meat probe measures internal food temperature. Simple Ash Cleanout System (patented).Smart Smoke Technology. Stainless Steel fire box. Digital controller automatically maintains cooking temperature. Grease Management System. Blue LED digital temperature display..Bottom utility rack. Large, heavy wire grilling area dimensions: 19.5" x 22". Included warming rack provides (570 sq. in. total cooking surface).
Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.
The original Traeger Grill was invented 30 years ago and was every bit as impressive then as it is now. Although it developed a cult following, the early Traeger never grew beyond a niche product. In the past two years, however, Traeger has stepped up its game, redesigning and upgrading its grills while doing everything it can to build a buzz around its amazing do-everything cookers.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.
Rubbery skin has very little to do with the type of heat (direct vs indirect). Rubbery skin is a result of too low a cooking temperature. Take your smoker/grill or whatever you use and get the temperature in the mid 400’s or even higher and you will get crispy skin. One thing though never let the internal temperature of your bird get over 150 or you’ll have crispy skin and dry crunchy meat too. Take it off the grill and let is rest a full 30 minutes. Best bird you’ll ever eat no matter which grill, smoker, 50 gal barrel, etc you cooked it on.
Craft amazing wood-fired creations with the Traeger Lil' Tex Elite 22 pellet grill. From grilled steak, to smoked ribs, and even a freshly baked apple pie, the set it and forget it ease of use allows any home chef to cook it all. Swap the gas and charcoal barbecue for 100% pure hardwood pellet flavor and grill, smoke, bbq, bake, roast, or braise a masterpeice.
Their behavior is sometimes counterintuitive. The hotter they get, the less smoke they produce, and at their top settings, they don't produce much smoke at all. This is good for when you are baking cakes or pies or doing dishes that don't need smoke. But down under 250°F, they produce plenty of mild, elegant smoke. And even though the fuel is wood, it is hard to oversmoke with a pellet smoker. Burning wood on a charcoal grill produces much more intense smoke flavor.
Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
Some products feature the wood-pellet fuel system as a bonus, but the Camp Chef SmokePro SG makes its wood-fired function the star of the show. Using 100% real hardwood pellets, recreating 5-star-cuisine level dishes on a large scale is now made convenient. Though it still has limited reviews, it wouldn’t be a surprise if this smoker quickly becomes a best-selling choice. It’s the kind of smoker that you need if you want hassle-free and fast cooking.
The Camp Chef SmokePro’s automatic features definitely set it apart and make it truly a “set it and forget it” kind of unit. It makes use of an electric auto-igniter system that lets you start grilling with just one button. The automatic auger instantly dispenses pellets to maintain the desired temperature and use your pellets the most efficient way.
Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
Standard shipping via common carrier "Threshold Delivery" is included in the quoted price. "Threshold Delivery" includes placement inside your front door or garage. Delivery can only be made inside the front door on the ground floor of multi-level housing. Carrier will call or email to set up a delivery appointment. Please include a daytime phone number in the shipping information at the time of check out and please monitor your emails for an opportunity to set your delivery appointment. Deliveries are made between the hours of 8 AM to 5 PM, Monday through Friday, and will be scheduled as a 4 hour window. Extraordinary delivery requirements may necessitate an additional fee to the carrier. NOT INCLUDED: Placement in your room of choice, removal of packing materials and assembly are NOT included.
Competition: If you are buying a smoker for participating in any competition, then pellet smokers are your best choice. Gas or electric smoker grills are not allowed in any competition as they are using automation. Though you are getting temperature control and electronic start in pellet smoker it is accepted in competition. This pellet smoker review will point out the ones best for a competition.
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.
The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
Beef: For ground beef items such as patties and pies, the ideal temperature would be 250 F. If trying to smoke some steak, we’d suggest 225 F. For both these temperatures, the food should be allowed to cook for around 1 hour to 1 and a half, depending on your preferred doneness. Alternately, for steaks, you can reduce the temperature further, increasing the cooking time for more tender but less juicy results.
A few other mentionable features are that it has a highly durable temperature proof textures powder coat finish, it features auto start. The REC TEC Wood Pellet Grill accommodates temperatures from 180 degrees Fahrenheit to 500 degrees Fahrenheit with 5 degrees increment. This amazing temperature control features let you be in control of how much heat you want to cook your food in, without having to worry about it getting dry or burnt. This low increment allows you to cook delicate meats like fishes and seafood as well! It smart grill tech makes sure that the temperature you set is always consistent and constant. It also has an “Extreme” smoke feature from the 180 to 250 degrees Fahrenheit setting that intensifies the smoke in the grill.
Many other features, like its automatic control and built-in meat probe have made us select this smoker as the top one in our pellet smoker review. And the most amazing fact is the price. In the price range (see the price here), we never thought that we could get all these features and benefits. We took all the top smokers into considerations like the Rec Tec smokers, but this PG24 by Camp Chef can beat all through its performance and affordability.
So far this smoker is fabulous! There is a learning curve, and this is not a "set it and forget it" smoker. You have to make sure you don't run out of pellets as the smoker will shut down. Tried a pork butt, but I wasn't watching it close enough, so I had to finish it in the oven. Still delicious. Next made some boneless skinless chicken breasts which turned out wonderfully.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
Despite being a little complicated when compared to the other types of grilling equipment (because of the automatic pellet auger and fan), they are pretty easy to repair if you have the right parts. You can find these parts right at a home depot or online. It doesn’t matter if you need to replace the auger or the fan, the ignitor rod or the hopper, for the top brands, you’ll find the replacement parts just as easily. Let’s look at the replaceable parts of a pellet smoker:
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.