Do not confuse a pellet grill for gas grills. Like the name suggests, a pellet grill obviously uses pellets for cooking its food. But do not doubt its competence with any other gas or convection appliances. It cooks just as well, if not better. And the secret to this are in its pellets. While pellets vary from brand to brand, the best ones have more wood and less binders like sawdust etc.
In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.
This smoker offers a decent 418 square inches of grilling space. This is enough to cook around sixteen burgers or four whole chickens. If the grilling space isn’t enough, Traeger also offers a larger unit that offers the same features at a higher price range. But the medium sized one is enough to cook for large groups of people already. Built to have a high capacity, this smoker allows for multiple cooking at the same time.
Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.
I had heard about Traeger from a friend who was at a conference where the catering was done on one of the commercial units. He had said the food the it made was mind blowing, and on a late night impulse buy I decided to purchase this from Amazon - as an open box/scratch and dent for about $800.There are some less expensive grills available, I have never owned them so I can't comment on them. i started to get a little buyers remorse with all the negative reviews this grill had received, but decided to give it a fair shot. It arrived quickly not by UPS but from trucking company. Despite being listed as damaged box/open box it was well packaged no damage. Assembly took 30 min by just me, assembly tools were included. Stood it up off the floor and filled the hopper with mesquite and followed break in procedure listed to cook off any manufacturing oil etc. Let it cool retired it once more to make sure it was seasoned let it cool again and was ready to go. I purchased an IGrill wireless thermometer to go with it which I would recommend also. I signed up to the Traeger recipe sight and they send a recipe every few days, and you can browse the website for some inspiration. Since I have owned this I have gone thru about 3 bags of pellets including alder mesquite and hickory. I have grilled Trout ( the smoked trout dip list on the website was amazing) as well as trout fillets, Salmon, Haddock, Ribs, Brisket, Pulled Pork x 3 and 2 prime ribs and 2 loafs of bread Jerkey ( smoking now) butternut squash etc etc . All the food I can only say is mind-blowing - enough so that 4 of my friends have purchased the smaller Traeger's for themselves. It has all been incredibly easy - just season, set the temp put the food on and the temp probes in and forget it- the wireless I grill continually upgrades my phone so I can keep working inside and not have to worry. It has never failed to light, caught on fire, overheated or preformed to anything other perfection for me. I can't speak for all the other negative reviews but I have had nothing but success with this, the Weber propane I own hasn't been touched is just taking up space it can't compare to this thing. Its a big purchase at close to 1k but is incredibly versatile I can't speak about customer service response because I haven't needed them, but if you are concerned I would call the headquarters and see how hard it is to get someone on the phone. The Temp probe is off by a few degrees compared to my Igrill reading but the grill has no trouble maintaining a narrow temp window if you keep the lid closed and don't F%$k with it . Most important it has bought back some passion to cooking, and made me want to try new things which is priceless.
It’s also worth double checking the precision of the controls. Less expensive smokers sometimes have cheap control panels that only allow you to set the temperature to a few discrete settings, for example just low and high. This is, generally speaking, awful, and leads to improperly cooked meat and a whole host of other issues. Avoid it if you can.
Complete with a variety of spectacular features, the Z Grills Wood Pellet Grill and Smoker redefines the whole concept of smoking. At a reasonable price, this smoker gives you more than what you paid for. It offers top technology-rich features that ensure consistent smoking for that great smoky flavor. Plus, many customers – including ourselves – have attested to its durability. This smoker will serve you without failure for a very long time.
Hey Ben! Cool re: your Camp Chef! Pellet smokers produce a light smoke as compared to stick burners, gravity fed smokers, Ugly Drum Smokers, etc. Most feel that the smoke provided is enough. If you need more – check out the Amazn Tube Smoker. You can find the Tube Smoker and Cookin’ Pellets via this link. Look for the Pellet Smokers and Pellets links.
I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.
From among these 65 products, we have selected the top class pellet smokers out there shortlisting 18 of the best candidates. Then, we have conducted a secondary research and compared their features against each other to find the best 10. Finally, we have compiled this review list of top 10 best rated pellet smokers considering their features, reviews, ratings, review frequencies and how great they were when we tested them out during BBQ parties.
Although mesquite is often thought of as the quintessential BBQ wood, don’t stock up on it until you’ve tried it. While many who are new to pellet smokers and BBQ immediately choose mesquite pellets, be forewarned: it has a strong assertive flavor than can overpower food. When buying pellets for the first time, its wise to choose flavors that are versatile enough to be used on many different foods.
We have reviewed the best pellet smokers on the market today after doing our extensive comparative research. However, there were some hidden gems that could not make it to our top 10 product list because of one reason or another e.g. due to their high prices, unavailabilities in some regions, and other factors. Also, some just failed to get in our top 10 list only because it was a top 10 list and not a top 20 list. Regardless of the reasons, here are a few honorable mentions that failed to make it to this top 10 best pellet smoker review, but are still worthy in their own rights:
Cleaning and Maintenance: Keeping the grill clean is critical if you need to get the most out of the unit. Old debris can influence the viability of the unit thus normal cleaning is vital. In addition, while moving it around, take alert not to thump it since it accompanies little legs which can without much of a stretch tip over the unit when thumped.
Cleaning and Maintenance: Any individual who’s taken a stab at cleaning a pellet grill before sees exactly that it is so hard to get all the ash out after use. This unit gives you a less demanding access to the burn pot. It also includes a trap door which permits you to clean the unit without digging through the ashes and oil. Cleaning the unit is by and large significantly less demanding when compared with the normal charcoal grills.
The Vulcan is a Picnic Time original design The Vulcan is a Picnic Time original design and the ultimate tailgating cooler and propane barbecue set in one. Don't be fooled by other similar looking items on the market. Only picnic time's Vulcan features a PVC cooler that conveniently nests inside the compartment that houses the portable propane BBQ. ... More + Product Details Close
The Smart Smoke technology is one of the most convenient and easy to use features on the grill. It contains a dual LED temperature readout that keeps the heat at a constant temperature. This means you have more time for socializing and can sit back and relax. The temperature ranges from 160 to 500 degrees Fahrenheit. The grill uses a pellet feeder system that burns slowly to add intense flavor to your food. It also uses an electric auto-start ignition that requires the grill be plugged into a standard 120v outlet.
Yes, no one likes to read the instruction manual. But there are many advantages of learning the specifics of your grill and reading the manual is key. Generally, you should not use water to clean your pellet smoker, so keep your hose pipe far away. These smokers have digital controllers, a motorized auger, a fan and an igniter rod for the fire pot. These parts will get destroyed if they come into contact with water. You should gently dry scrub the dirt off these parts, making sure not to disassemble any parts. Cleaning the thermostat will also prove to be essential; otherwise, it may read internal temperatures inaccurately.
The first thing to consider before purchasing a pellet smoker is your budget. This will allow you to buy the best pellet smoker for the money. If you are a beginner, you do not need to get an expensive unit in order to produce results. However, if you have some experience and you want to take your smoking to the next level, you may look into a more expensive model with the goal of getting some of the features you want.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
Kevin, your recommendation rocked. The Pro is one of the best pieces of grilling and smoking iron I have had my hands on in a long time! Better than the Backwoods? Well depends on how much work you want to do! Maybe not, they are first class, but ease of use? I use the Backwoods a couple times a year, the Pro has already done 8 cooks in 5 weeks. Love it.
Brad Barrett at Grill Grates makes a fantastic product. Reverse searing 2″ steaks and chops (or thicker) works great on pellet smokers as you can get the internal temp up to 10-15 degrees below your desired finish temp, remove them and loosely wrap / cover in foil, crank up the smoker with the grates on to say, 400 degrees, and then sear off your protein getting great grill marks with little to no sticking at all. Huge fan of Grill Grates.
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.
I’ve been grilling and smoking for many years and throughout all those years I have burned through many expensive grills. Four years before I purchased the 640 I got on the pellet smoker wagon and started my research. Finally when my daughter was getting married she ask me to cook for the wedding and gave me the perfect excuse to finally get a smoker I wanted. So getting back to the research and after 3 months of comparing I settled on the YS640. I wanted a grill, at my age, to be able to pass down to one of my kids. It was big investment but like I’ve learned in life, you get what you pay for “most” of the time. I have had this grill now, September 2018, will be 4years now. I have no regrets and would do it again. I’ve had some minor corrosion issues and after an email was promptly sent the matching paint to clean it up. I spent the time to do it right and today, a month later, today my grill looks brand new. Honestly nothing like this can be left to take care of itself. Maintenance like anything else is required. But I know this will most likely be my last grill. Thank for a great product and great follow up service. Smoke Shack.....
The Traeger Pellet grill can accommodate temperatures from 180 degrees to 375 degrees, and high. It has a state of the art digital temperature control system that not only monitors the temperature to keep it consistent and even, but also regulates the pellets the auger feeds to the fire according to that temperature. This is truly a grill worthy of a place in our pellet grill review.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
Wood pellets that are tailored for pellet stoves or fireplaces usually contain tree barks and binding agents such as glue. When used in pellet smokers, these wood chips can expel some harmful chemical substances infused with the food. But since the dawn of Traeger pellet smokers, different manufacturers have been producing food-grade wood pellets to be used in pellet smokers.
Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.