I am currently using a Bradley Smoker, which is basically an electric oven with a smoke generator that makes tons of smoke, using special Bradley Smoker pucks (of compressed saw dust). A tall cylinder hold a stack of pucks, and the smoke generator pops a new puck into the oven every 20 minutes or so (when the pucks are about 80% burned). Managing temps is not as difficult as a stick burner, but nothing like advertised with these pellet burners (like the Rec Tec).
We ended up going with the Memphis Pro. We were fortunate enough to be able to see all of the manufacturers and models I was most interested in, at Sam’s NW BBQ. (Yoder, MAK, Fast Eddy, GMG’s, a few others, and then, the one we ended up with, Memphis.) Sam took a good amount of time, providing us fantastic information about each model. We ended up with the Memphis Pro for the following reasons: 1) The construction, mainly the double-walled construction; 2) the preciseness of temperature, and being able to hold the temperature (due to reason #1); 3) the extreme ease of changing from smoking to grilling without a lot of effort or reconfiguration; 4) the double hoppers; 5) and another BIGGIE, the fact that grilled or baked foods taste like that, and not like smoked cookies, bread, pizza, etc.
Though the Memphis Pro works great as a high heat, sear, and direct flame grill, I chose to do some IBP ribs and a couple all natural pork loins I picked up from the store. I won’t go into too much detail on the pork loin and rib prep here, suffice it to say that I was very impressed with the smoke output I got from this unit, which I filled with a full compliment of CookinPellets Perfect Mix Pellets.
Hi there i want to recommend the CAMP CHEF pellet smokers you get the bang for your buck with these smokers i know a lot of you out there are turning up your noses but these smokers have all the extras at a very good price well under a $1000 customer service second to none you get the pellet clean out in the hopper they have a ash tray under the body you just pull a lever and all your burnt ash is cleaned out digital temp for the food digital temp for the chamber lo smoke and high smoke setting and it goes up to 500 degrees at 25 degree increments mine coast me $359 out the door includes shipping it dose a wonderful job holding the temps with a 10 to 15 degrees swing i bought mine at CAMP SAVER.
Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
I had hung my hat on the Yoder and had even contacted the factory and a couple of distributors in the DFW area. Then I did my usual, search craigslist and see if anyone is moving and selling their unit. Low and behold a Memphis Pro!!! Story was brand new, bought for a built in and now cannot use it now. Brand new but you may not have a warranty though. Price… wait for it! $1600!!! You got to be kidding! Scam?? Ok well I will contact him. Surprisingly he had it advertised for a few weeks and only had a few contacts but none serious. Ok, I will come look and if you can plug it in and show me the controller works I will take it. Called the factory and they were quite responsive. They said we probably won’t warranty the controller because we don’t know the history but it will depend on the failure. Everything else we will cover. So right before Thanksgiving headed to Dallas and it basically all looked brand new, plugged in and it did everything you could do without burning pellets.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
I have used mine Traeger 15 times and it hasn't worked once. I will not hold the temp within 15 degrees as they state. I can set mine to 225 and will go between 180-370. It also consistently shutting itself off with the same error. I have spoken to cust service 12 times and they are worthless. I have had new controller sent and other various parts. I have been on the phone with them for hours. I always have to take my meat off and finish it on my Weber. They refuse to send me a new one. They still demand to go back through the same damn steps as the last 12 times to debug it. Never again. If you see my post on Craigslist, don't buy it, it's a lemon that Traeger will not support.
Rec Tec has always been known for making advanced Rec Tec wood pellet grills coming in at a higher price. However, some of the popular models come in smaller sizes, like Trailblazer 340 or Bullseye 380. However, compared to their capacities and features, the products in our top ten lists would be better choices. So, among its products, the RecTec Bull 700 is the only one that falls in our Honorable Mentions.
PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
Hi Jennifer, the Traeger grill you purchased should serve you well. You can see a picture of one of them installed here. I think this is the grill style you bought. One thing the sites you’ve researched (including my own article above) might not have stressed is that Traeger recently hired a new CEO and is actively working to attain the name, reputation, and reputation for quality that they once had. I’m confident should you have any problems with your unit that they will stand behind it and take care of them for you.
If you’ve ever wanted an 8 in 1 wood pellet grill that you can just “set and forget”, then this grill makes a perfect unit for you. It was the best smoker we’ve used in terms of hassle-free use which is why it had to be one of our top picks. Digitally-controlled, this smoker ignites the unit and uses a Smart Smoke Technology™ to heat it up from 160 to 450 degrees F. This pellet smoker comes with 513 square inch grilling area, plus a 2nd cooking rack! While it doesn’t have any auto/one-touch cleanup system, its auto-shutdown feature makes it worth the value.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.
We love recommending and reviewing wood pellet smoker grills, but we also want you to get the most out of them once you purchase. Without proper care and maintenance, even the best pellet smoker is bound to have a shorter lifespan. Therefore, how you use your smoker and how you maintain it after use greatly determines how long it will serve you. A little bit of work will go a long way toward extending the life of your smoker. A thorough cleaning of the smoker should occur at least once a year. If you frequently use it, you should have it done at least three times a year. Buying quality pellets will extend its life as well.
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
An attractive option for many people are stainless steel pellet grills, which are rust-resistant, more durable, and easier to maintain. While pellet grills made from commercial-grade 304 stainless steel are the most desirable, they come at a higher. However, there are also some pellet grills made from 430 stainless steel, which is more affordable and still incredibly durable.
You want even grilling: One of the downsides of using a charcoal grill is ensuring that the entire grilling area is evenly heated. Spreading the charcoal evenly and avoiding hot spots is difficult. Traeger’s pellet grilling system overcomes this problem with a fan that evenly distributes the heat throughout the grilling area, much like a wood-fired oven would have.
We were surprised to see that the pellet grill was WiFi-compatible. Usually, grills come with basic remotes, but this one comes with a digital WiFi controller. It allows you to control and monitor your cooking through an app on your iOS or Android phone. We found this convenient, since we didn’t have to get up to check on our grill every few minutes. This is probably why it’s one of the top pellet grills in the market.
On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
This grill actually came about because of an IndieGoGo campaign. IndieGoGo is a crowdfunding platform wherein interested parties on the Internet can donate money to the maker if they want his invention or service to come about. The Z Grills Wood Pellet BBQ Grill and Smoker got its $500,000 from its donators and now the previously nonexistent Z Grills Company now exists to make their wildly popular grill.
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.
My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.
This pellet smoker will bring your outdoor cooking experience to an entire new level with its massive 560 cubic meter cooking area that comes with one removable rack. It can reach temperatures of up to 500 degrees F which makes it an excellent choice for grilling, smoking, braising, baking, BBQ and roasting. Reasonably priced, it’s a great investment. It’s made of high-quality materials and superior digital controls, including LED controls and auto pellet feeder. Cleanup is also 60% less demanding because the convenient trap door is for burn pot cleaning. With this efficient pellet smoker, the money you spent will be worth it.
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
When you’re buying a pellet smoker vs a wood smoker, what you’re buying is convenience and simplicity of use. Whilst electric smokers are arguably more convenient than pellet based smokers because they start quicker, only need a power point and a handful of wood chips, pellet smokers are still incredibly easy to use and far more convenient than wood smokers.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
The completed transaction enhances Vista Outdoor's position within one of the camping market's most attractive categories, complementing its already broad portfolio of 50 brands in shooting sports and outdoor recreation. Wholesale dollar sales in the camping category grew at a 6% Compound Annual Growth Rate (CAGR) from 2010 to 2015 (source: Sports & Fitness Industry Association). Camp Chef's sales growth has been fueled by a strong product development pipeline and user-friendly products.
One other thing to know about the wonder of pellet grills is that they come with pellet hoppers, varying in capacity from brand to brand, that accommodates and use the pellets you put it accordingly and automatically as per the heat setting, eliminating the need to refill the hopper manually so frequently. So throw on some lamb ribs on to those hot grills, and go enjoy some cold beer while the pellet grill does the rest for you!
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
As a new and nervous cook or just a busy one, it is always a struggle to get the results you want without having to tend to a grill or stovetop all day long. Luckily, Pellet Grills offer a convenient solution. These foolproof devices allow you to truly set it and forget it. Whether you crave perfectly grilled spare ribs or smoked pork butt, Pellet Grills allow you an unprecedented degree of control over the temperature and cooking style you want. What’s more, Pellet Grills are a terrific way to infuse your food with the real flavor of wood smoke, whether it be hickory, mesquite or maple. Unlike gas grills, the flavor is right there in the fuel with wood-pellet grills.
I purchased a Traeger Select Elite from Costco for both my personal residence as well as for my vacation home. I am now on the third grill at my residence. Traeger will tell you that they expect to offer Awesome customer service. I have replaced the auger assembly, the controller and now the fan. I can't get the grill up to temperature. Awesome customer service says it should be no problem. Just replace the _______ (fill in the blank). I don't think these people have ever seen a grill let alone use one. Costco (love their return policy) is about to get another one back. Am I too harsh to expect the product to perform as they say it will? I would think when you pay as much as Traeger thinks their grills are worth, that they should work out of the box. Well, quality control under the new management has gone to hell. Then they expect you to "try" all the fixes that might work on your own. This is self service, not customer service.
This is well worth the money. I'm a Weber charcoal guy for steaks and chicken and only used my old propane for baked potatoes, corn and asada. Fired this thing up and my asada was fast and easy to make. Philly cheesesteak was fast and simple. Large cooking surface lets you do a lot and it heats fast and evenly. Just make sure if you have kiddos around they keep their hands clear of the flat top! As of yet I haven't cooked on the grill grates so can't say anything about that. Putting this together was simple and took me about 20 minutes. On a side note one of the threaded tubes for a wheel broke loose when I put the wheel on and this was due to a very poor tack weld holding it. I contacted camp chef customer service and took a pic of the defective part and within 2 business days replacement part arrived. Excellent customer service. This thing will get a work out this summer! If your looking for a cover for this it can be a pain and I bought a patio furniture coffee table cover that is close to the grill demisions and it fits perfect.
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®.
This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
Ready for the camp or cabin, this reliable, no-frills stove features two 30,000-BTU commercial-grade cast burners. The all-steel range features sturdy grates built to support hefty cast-iron cookware. It's surrounded by a three-sided steel screen to block drafts and grease splatter. The heavy-duty steel legs slide off for transportation and storage. Cooks up to 15 hours on a 20-lb. propane cylinder (not included). Includes hose and regulator.
Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.
Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
This podcast is great for anyone that has ever had an interest in BBQ, grilling, smoking, etc. The guests that are brought on to this pod along with the dialogue that Kevin has with them makes this a great podcast that would be enjoyable for anyone to listen to regardless if they liked BBQ or not. There is a great wealth of knowledge to be found in these pods, and each time I listen to the BBQ Beat I feel genuine excitement to go outside and try something new with my grill or smoker. Aside from all of this, the audio is great and the topics are interesting which makes the experience engaging for not only the guest on the pod, but also you the listener. Suscribe and listen often. I promise you won't be disappointed.
Yeah it seems like no one is providing any input on it…I was interested in having them review it and do a direct comparison to some of these other grills. I made the mistake of getting a Myron Mixon pitmaster Q3 at sears. It turned out to be a waste of money and the slight humidity I had caused the pellets to burst and seize up the Auger. Anyway I had narrowed my search down to a rec tech or silverback but none of the reviewers seems to be giving it any attention.
We did return the Traeger to Costco for a full refund. It's not that Traeger has poor customer service; they don't have any customer service. We brought a Bradley Smoker, an upright design, and it has performed much better than the Traeger. The Bradley also takes up much less space and we've placed it on a dolly so it can be rolled around. Overall, a much better solution.
I ordered a thermostat for my Junior Elite grill because service said that was most likely the problem with my 4-year-old Traeger grill. I was promptly charged on my credit card. The order did not get to me and 2 weeks later, I emailed them. They said they would send out another thermometer. That thermometer has been making the rounds in 1/2 dozen post offices:
So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
Rifles Delivery Confirmation-Adult Signature Required. Customer must provide a physical address for delivery of this item. Cannot ship to a PO Box or APO/FPO addresses. Black powder rifles are not shipped to customers in IL, MI, NJ, NY and Washington, DC because of restrictions. This item will be removed from your order if your shipping address is to a restricted location.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
I’ve had the chance to use one the the Traeger Grills Pro Series grills now for some time, and I find it to be a great pellet grill. They really beefed up the chassis of this model, with a stronger, wider-stance sawhorse base, larger wheels, a nice strong side lift bar, and an upgraded Digital Pro Controller with Advanced Grilling Logic that keeps temps steady, but allows for a temp swing of about 15 degrees. I mention the temp swing here as a positive, rather than a negative. By allowing a tiny bit of temperature fluctuation, I find the grill actually puts out a bit more smoke throughout the cook as pellets are fed in to regulate temps.