just received my new YS-640 two weeks ago and I absolutely love it. The shipping process and delivery was just as described. The delivery guy unloaded it off the truck, and wheeled the pallet into my garage. Everything was perfect. I am very impressed with the build quality...this thing is a tank. So far have smoked ribs and a brisket, and grilled chicken breasts. The grill heats up much faster than I expected. Temperature holds very steady over the long cooks. I love having the built in probe ports. Still figuring out and tweaking the baffle to control different cooking zones. Only negative thing I say is it can be difficult to manouver in tight quarters because it's so heavy and only the small caster wheels turn. So if you need to move your smoker around a lot, consider the comp cart.
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.

At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.


From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
Wood pellet grills are a great addition to any home because they combine everything you love about a smoker with a standard grill. Depending on the model that you buy, you can make smoked dishes like brisket and sausage at the same time that you make burgers, hot dogs and other dishes on the grill. These grills are great for family dinners in the summer and for parties and special occasion celebrations.
Background: I've had this flat top for a month now and do 99% of my cooking on it. I have it set up next to my kitchen balcony which allows me to cook outside in most weather conditions and allows me to keep my kitchen clean for the most part due to a natural gas hook-up that I have outside. I purchased the Natural Gas Kit Hose (NGKIT) and converted the flat top to only intake natural gas. Please note that once you make the conversion then you cannot convert it back to propane unless you get new orifices. I had to drill all 4 orifices with a #45 drill bit to ensure that sufficient gas will be funneled through to the flat top. This process took a couple hours and will take more if you don't have the proper tools.

Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.


When you think of a portable smoker and grill, you think about basic features. But with the Tailgater by Traeger Grills, you get more than what most portable grills have to offer. At 300 sq. in., this portable grill is enough to cook decent and succulent dishes for small groups. It can even reach to a maximum 450 degrees F, so you’re never limited when it comes to the type of meat you want to grill or smoke. We loved its EZ fold legs, which make it easier to throw into the car trunk, ready for the next adventure.
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
The rest of the product we reviewed offered 6-in-1 features, but this one surprised us with its 8-in-1 cooking versatility. If an efficient smoker that can do multiple things is what you’re after, then there’s no need to look further. This could just be your top choice! The pit Boss Pellet Grill with Flame Broiler cooks almost all kinds of food with 100% genuine wood pellets. Talk about quality and quantity!

The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.

PG24 by Camp Chef has a weight of 124 lb with a pellet hopper that has 20-pound capacity. That’s so large, you won’t need to worry of getting more before your meal is done. This approach allows you to have the ultimate cooking experience. When the temperature drops, one wood pellet is released. This convenience can’t be found in other grill types, like gas or charcoal.


The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
Each grill is porcelain coated, like you’d find on professional grills, for exceptional heat transfer and easy wipe cleaning. This attention to excellence is extended over the whole machine, with everything made out of heavy gauge steel and top quality material. The only real let down is the wheels, which are kind of low quality, but they’re real simple to switch out.
Spent thousands on Traeger, they are ok. Wouldn’t have an issue if they were only $500. But the last one I bought, (Timberline 850) cost $2500 Canadian. Almost burnt my house down because it got over 600F and was still climbing. All Traeger does is mail you more Chinese parts to fix your China made grill. By the end of it you will know your Traeger in and out because you WILL have to take it apart to repair! Overpriced for a smoker with many issues. Timberline lower grill has a portion of the grill removed for some kind of design. They added a 1/4 lip to justify this Grand Canyon of a hole in the back of the grill. Well needless to say if you cook wings or something small and toss them around you will for sure lose the wings to this big stupid hole. But they said they pit the little lip to stop the food from falling... Do they not test these products?
Once you start paying more than $500, you’re looking at a big boy professional level machine. It’s going to be big enough that you don’t have to worry about having the neighbours over as well as the family. You’re also looking at more expensive sensors and thermostats, so you get a more consistent temperature, which leads to a much better end result, and there’s generally some sort of cleaning assist built in, which makes cleanup and putting it away at night so much easier.
Every outdoor cooking enthusiast wants an affordable pellet smoker that has all of the key features that even a high-end unit would have. In most cases, this is just a dream and a result of false advertising, because most impressive smokers typically cost a hefty sum of money. The Z Grills Wood Pellet Grill and Smoker claims to be a reasonably-priced smoker that offers top-of-the-line features, and many users have agreed with those claims. With this pellet smoker review of the Z Grills Wood Pellet Grill and Smoker, we’ll find out if it really does what it claims to do.
One of the fun features this grill offers is that it’s WIFI enabled (controlled or monitored through an iOS or Android app). Sense-Mate, a thermal sense that constantly monitors the grill temperature, keeps you up to date on the status of your grill and your food! The digital controlling really lets you micro-manage your cooking, as you can adjust it a degree at a time. You can also program a series of temperatures and then sit back and enjoy your day while your food cooks! (Yes, you can also control it manually as well.)
The Memphis Elite is the largest cooker in Memphis Wood Fire Grills' impressive line of luxury pellet smokers. They're extremely well designed and well built. The top-grade 304 stainless steel is thick and extraordinarily well machined. Fit and finish are impeccable. Meathead proclaims Memphis smokers to be "some of the best cookers [he's] ever had the pleasure to use." At $4,999, the Elite is clearly not in everyone's budget, but this beast is impressive enough for us to include in our 2016 Top 10 Luxury Grills and Smokers list, where prices go up to $50,000.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
This purchase, the customer service and the lack of understanding from Traeger Pellet Grills, LLC, has been very unfortunate.  I've since stopped payment with AMEX and Traeger is now telling AMEX that they will do nothing until they get the damaged grill back.  Well, I'm in Florida and my brother is in Virginia, and at his age is not capable of handling a Grill that weighs over 100 pounds by himself.  Additionally, he's not a "Grill Repair Man" and does not have the knowledge to tear down a Grill Body including electronics and putting it back together as assembled at Traeger.

The first time I grilled something on it -- pulled pork, which takes a long time on the grill -- the fire kept going out on me. My husband called the company, and they said they knew they had that problem. So he told the nice lady on the end of the line that what they needed to do was to add something to the hopper to keep it jiggling just a little so that the pellets continued to go down. "We're working on a solution," she said. "I just told you the solution," my husband, who's a mechanic and loves solving mechanical problems using unusual, but straightforward solutions. His trick? -- get one of those cheap, plastic, clip-on fans and clip it to the hopper, pointing the fan down into the hopper. The fan jiggles it just enough. The air into the hopper "couldn't hurt, either," he told me.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.

Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
When it comes to the material design of a pellet grill, the material is one of the most important aspects to consider for many reasons. First of all, the material has to be able to withstand extremely high temperatures and also be able to cook properly without the heat escaping the grill. With that said, the exterior or the grill has to be able to withstand high temperatures so the color does not peel, rust, or other defects. With that in mind, we discovered that all pellet grills have to be designed from some of the most important materials in the industry, so they can withstand the test of time. Alongside this, pellet grills are built to last so individuals can enjoy them for years to come. When it comes to the exterior craftsmanship of a pellet grill, the most common material is a powerful steel construction. Steel is also known as one of the most powerful and durable materials in the industry today. However, steel does rust if it is exposed to water. Therefore, many quality brands have powder coated the steel so it can be water resistant and does not rust easily.

If you’re in the market to purchase a new pellet grill, you might be intrigued by all the grills and smokers on sale you see advertised locally and online. Let’s be honest, purchasing a pellet grill can be quite an investment and it may be something you have been saving your money for. That’s why it’s important that you take the time to research and educate yourself about not only the different brands of pellet grills but the price tag that’s attached to them. When you see a pellet smoker “on sale”, what does it really mean? Is the company really saving you money? Are you getting a good value? First, let’s take a look into the two different purchasing options you have when it comes to buying your new pellet grill.


It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
Brad Barrett at Grill Grates makes a fantastic product. Reverse searing 2″ steaks and chops (or thicker) works great on pellet smokers as you can get the internal temp up to 10-15 degrees below your desired finish temp, remove them and loosely wrap / cover in foil, crank up the smoker with the grates on to say, 400 degrees, and then sear off your protein getting great grill marks with little to no sticking at all. Huge fan of Grill Grates.

Most old-timers will tell you that a buildup of soot and grease will improve the taste of your food. This does not prove true, in fact, it’s not good for you and can even be dangerous. At Grills Forever we want your grilling experience to be the best and safe. Therefore, before any cooking session, always clean your grill to optimize its performance and prevent any off-flavors. Check the grease pans or collectors before smoking because the collector could be full and overflow, starting a fire. If there is a grease chute then clean it for sure.
Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!
Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.
Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.

© Copyright 2005 to 2018 by AmazingRibs.com. All text, recipes, photos, and computer code are owned by AmazingRibs.com and protected by US copyright law unless otherwise noted. It is a US Federal crime to publish or distribute anything on this website without permission. But we're easy! We usually grant permission and don't charge a fee. To get permission, just click here. And you don't need permission to link to us.
Pit Boss Wood Pellet Grills are fueled by all natural BBQ wood pellets. The digital control board ignites the grill and allows you to set the cooking temperature from 180° to 500°F. Fan forced convection cooking eliminates the need for a rotisserie and creates a versatile environment for grilling, roasting, smoking, braising, searing and baking. The 820 features a Flame Broiler as standard; this adds the option to grill directly over an open flame when direct heat is needed. The Pit Boss 820 features a large 820 sq. in. total cooking surface: 580 sq. in. main and 240 sq. in. removable upper rack. With complete structural strength and durability, the Pit Boss 820 is made to last.
From boiling brewing frying or whatever the job From boiling brewing frying or whatever the job might be this little stove has the power to get it done. The maximum output high-pressure burner system heats mass amounts of liquid in a hurry and will maintain it at boiling temperatures making it a great cooker for home canning and ...  More + Product Details Close
Got the Traeger Pro grill. I was so excited after seeing all of the commercials, unfortunately once I got it together it did not work. No heat on the glow rod no fan nothing. The only thing that worked was the auger and the front panel lights up. Called customer service spent 2 hours on the phone for them to tell me what I already knew they did not work. I told the man on the other end of the line that if it could not work out of the box I did not want it, he stated no returns. Now I am stuck with it. He says, "I will send you the parts needed you can replace them."

Like with e-cigs and their gimmick of flavorful e-liquids, pellets for pellet grills and smokers also have different flavors added to their pellets, and they include bourbon, maple, apple, cherry, mesquite, alder, pecan, and hickory. You can mix flavors, change flavors, or use different flavors for every day of the week if you do everyday barbecues and grills for your restaurant or something.


Sometimes, the ideal pellet is something that costs a little over $1 for quality but you can still save money by buying them in bulk (like in 40 pound bags). Half a pound of pellets per hour is consumed on the smoke setting that’s about 175° Fahrenheit. Meanwhile, you can burn 2.3 pounds of pellet within an hour by setting the temperature at 450° Fahrenheit (this is an average on many of the pellet smokers mentioned above).

Buying factory direct means that you are purchasing a product directly from the manufacturer, which eliminates the need for a middleman. There’s no need for the product to go through any kind of supply chain and acquire additional costs in order to reach you. The price tag that’s displayed on factory direct products doesn’t contain any markup to compensate for additional costs. Buying factory direct gives you the best chance at receiving the lowest price possible for the product you’re purchasing.
After looking at a lot of pellets smoker grill reviews, it is easy to see that this is a pretty decent model. It is just so functional. So if you are looking to purchase something that is more than a pellet smoker, this is the product for you. Make sure to follow the instructions carefully when assembling it and be sure to gauge cooking time since this is a fast one.
We’re people like you, people who love outdoor cooking—the food, the fun, the time with family and friends. We’ve turned that passion into expert knowledge and an unmatched selection of BBQ and grilling products. Any question, big or small, we can help. From your first click to your next call, whether you’re interested in backyard BBQ or an outdoor kitchen, we have what you need and same-day ship nearly every order from our huge in-house inventory.
A pellet grill often comes with many facilities that are usually not available on any other grilling appliances. One of them is its temperature control and settings. This is a huge advantage for inexperienced cooks who do not have the understanding and years of experience of pit masters who know how to cook different foods on different temperatures. This also means that you do not have to fiddle and fidget around with the heat every 2 minutes after slapping on the steak on to the grills.
Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase

My Egg will last past my lifetime. And I have a lifetime warranty on it as well. I don’t want to plunk down good money(even $500 is good money if you think about it) to have a grill of no use in 5 years. I guess I’m looking for a do it all grill. Not that I need one to do it all, heck I can use my Old Smokey to grill up some mean steaks and burger and hotdogs if need be.
Editor's Note: If you're looking to upgrade your backyard cooking setup this summer, you're probably in need of a little advice. We're longtime admirers of the folks behind AmazingRibs.com, the site dedicated to unraveling the science of barbecue and grilling. Please welcome back Max Good, the only person in the world whose full-time job is testing, rating, and reviewing grills and smokers. The database he maintains includes over 500 grills and smokers, ranging in price from $30 to $50,000. When it comes to barbecue equipment, nobody knows it better.
I id not purchase this item from Amazon, a local retailer had them on sale but none the less this a great smoker at any cost. I have compared it to the far more expensive smokers and I have found that this one has a much stronger, better built main body. The metal is of a heavier gauge of steel. Cheap smokers are separated from more expensive ones a lot by the electronic controls. Tis model has a control from 160 degrees up to 500 in 25 degree increments. It maintains a constant temp within a few degrees of where it has been set, always a problem on other smokers not of the pellet design I have used. Pellet consumption is modest and the Camp Chef brand pellets are the cheapest I have found. and work extremely well The ash cleaning system is a matter of dumping a cup after use with very little ash left over. The grease trap system is perfect. I see no reason to spend more for a pellet smoker that couldn't perform any better than this one. I would recommend it to anyone in the market for one. They are a set it and forget way to do your smoking.
Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/

With the internal temperature sensor, meat temperature probe, and a digital temperature readout, the PG24 pellet smoker takes the guesswork out of your cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The patented Ash Can Cleanout System makes clean up the easiest out there.
Actual Cooking: This flat top is a game changer for cooking. The grill heats up very fast and heats up evenly across all 4 burners. It also has traditional grill grates beneath which makes this a 2 in 1 grill. You can cook a plethora of items ranging from tacos, cheese steaks, quesadillas, eggs, pancakes, hash browns, fried rice, assortment of Chinese dishes (beef and broccoli, Mongolian Beef, Garlic Chicken with Veggies, etc), and basically anything that could be cooked in a typical cast iron pan or skillet. It heats up bread, tortillas, and buns in a matter of seconds. The flat top itself can accommodate a lot of food at once and can cook for up to 50 people per hour at max capacity. The ability to cook multiple items on the flat top at once is especially helpful for cleaning as you won't need to have multiple cooking pans or skillets to clean up afterwards. Anyone that has the ability to use this as their main cook top should do so.
With that said, depending on the size of the green an individual may need more pellets to fuel the food. However, a bigger sized pellet grill allows the cook to grill for a large number of people. While a compact grill can easily be taken anywhere. With that in mind, one important criterion that we wanted to take into consideration is how easy the item is to set up.
I paid $700.oo for my Traeger. My heating element went out in 2 BBQ seasons. Not good considering the price I paid. It's just me, so it's not like it was in overkill. Bi-weekly meal give or take? Smokes fur shit!! Planned on some good'ol smoked salmon (cause I like to fish for salmon), or some pheasant jerky (cause I have Springers, and I hunt pheasant***) NOT HAPPENING. The only smoke there is...is when you start the damn thing. If you want smoke flavor, you have to add artificial smoke flavor from a bottle. Conventional outside oven heated by wood pellets. If you want BBQ this is not the way to go. If you want smoke this is not the way to go. If you want to leave something inside the oven to cook outside your house....this is the way to go. Wasted $
Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.

Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®.

The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
Hey Jeff – I think that due to pellet smokers requiring much of the wood pellet for “fuel” leaving a smaller part for the “smoke” means that you want as much of the smoke to stay in the chamber for as long as possible. Just my opinion. I’ve not used charcoal pellets. Those I’ve spoken with who have used them weren’t extremely happy with the results. Regarding the water pan, I feel that pellet smokers don’t typically require water pans. However, you can surely use one and see how your results go.
Pellet grills are every lazy man’s dream appliance. These grills need absolute zero to minimal maintenance. You just need to lightly wipe through it after every use, and maybe thoroughly clean it 2 to 3 times a year! All pellet grills now come with a drip pan that catch the accumulating oils that drops from the food. They are also made with good quality raw materials that enable them to withstand the outdoor atmospheres all year round. If this does not entice your lazy bones, no other appliance will, and that is a fact. Period!
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.
Once it reaches the ideal temperature, it uses an Internal Temperature Sensor to maintain it throughout the cooking process. Forget about checking on the status of your grilling every few minutes, this unit makes sure your food is cooked thoroughly and evenly — no babysitting needed here! This way, you can enjoy your time with your friends, which is what a BBQ party should be.
I have the Expedition 2x stove I purchased from Costco a few years ago and upgraded it with these side shelves. These are really nice and very useful. Easy to install (only took about 10 minutes) and they fold right on top of the stove so the whole works still fits into the carry bag. They are sturdy, but NOT meant to support heavy items like a cast iron pan or griddle! A little common sense here will go a long way. Happy cooking!
Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.

Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.

×