Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.

Placed against our Top Pick, this Traeger smoker and grill is a worthy competitor. It offers a variety of useful functions that will allow you to smoke, grill, bake, braise, roast and BBQ anything and everything. It’s definitely worth your money, because if you take care of it properly, it’s going to last you a long time. However, since it’s slightly more expensive than the top pick, we just couldn’t set it at the top of our review.
Cleaning/Maintenance: The grease catcher on this flat top is pretty decent. It is located on the bottom left hand side and all the oil/grease gets caught without anything dripping elsewhere. I usually wipe the grease catcher's orifice down with a paper towel to ensure it does not get clogged up over time. Other flat-top grills have either grease catchers that drip onto the leg of the grill or have them in the back of the flat top which is a little inconvenient getting to. As for cleaning after every use, I use a stainless steel scrapper/chopper to wipe the grill clean after I am done cooking. I scrape everything down into the grease catcher. For saucy foods or foods that might stick to the flat top, I use water when the grill is still hot to scrape it off and send it to the grease catcher. Afterwards, I put a little bit of oil onto the flat top and spread it all over using paper towels to maintain the seasoning before putting the cover on. Total clean-up time and re-seasoning takes roughly 3 minutes.
If you don't buy this cooker and spend more than $600 on any cheap thin steeled cooker. By year 2 you will realize you paid for quality that lasts. I joke that no one would steal it because it weighs so much. But it's my baby and it's double locked. I promise you in a year you will look at your wife or family and say "That's the best purchase I ever made!" It's impressive, no one makes a better product. If u buy Traeger or any other cooker. In 3 years you will regret not spending the money on a luxury machine. Yoder is the best of the best. Yoder is who the other guys want to be. I would buy it again tomorrow! Don't have regrets. You won't regret this purchasem

What makes it stand out from the crowd is that it’s the only pellet grill on the market (so far) that has an ash cleanout system… no more hauling out your vacuum to the patio to suck out the ashes when it’s time to clean out your grill! You just need a small cup… and with a simple turn of a small lever, the ashes drop out! You’ll LOVE this feature!
Most old-timers will tell you that a buildup of soot and grease will improve the taste of your food. This does not prove true, in fact, it’s not good for you and can even be dangerous. At Grills Forever we want your grilling experience to be the best and safe. Therefore, before any cooking session, always clean your grill to optimize its performance and prevent any off-flavors. Check the grease pans or collectors before smoking because the collector could be full and overflow, starting a fire. If there is a grease chute then clean it for sure.
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.
Not all people and culture will be able to truly understand our love for barbecue here in the USA. For them, it might just be a cooking activity while for us, it’s a tradition – a ritual to celebrate the summers (and occasionally the winters). As long as this love for grilling stays with us, which will be, we’re going to continue to expect more and more from the grill manufacturers.

Second, more people know about them. More manufacturers are realising the advantages of pellet smokers and hopping on board, the market is expanding, and with the advantage of the internet putting all the info at our fingertips, even someone who hasn’t got the first clue about smokers and grills can find out everything they need in just a few minutes.
REC-TEC, also known as Rec Tec, has been in business for more than 7 years. Its pellet grill offers up to 702 square inches of the cooking surface real estate, beating out the Pit Boss and its 700 square inches by (only) about 2 inches of extra space. Its grills can also calibrate themselves in 5° increments and its pellet hopper is capable of holding 40 pounds of pellets (no constant refills required).
For example, it has a decent 570 sq. in. of cooking area, a patented ash cleanout service, endless versatility (wherein you can barbecue, braise, roast, bake, smoke, and grill to your heart’s delight), and an advanced digital control (the same one that allowed the Camp Chef SmokePro to take the top spot). However, the quality control for this unit is a little worse than SmokePro.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.

Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.
This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
This pellet smoker and its humongous 20 inches by 15 inches or 300 square inches of grilling space are capable of holding 3 rib racks, 18 hotdogs, 4 chickens, or 12 burgers at the same time. This is also one of the most Affordable pellet smokers around. Its thermostat control is LED digital so that you can set it as easily as your microwave. Just press buttons and get the setting you want every time.

Over time, as other companies started entering the scene, the designs saw some massive improvements. Later, the firepots were brought closer to the hopper, reducing the distance the pellets had to travel to reach it. This move reduced the probability of a pellet jam. Later, more features began to be added to these grills to further improve the reliability, safety, and convenience.

Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
The Elite's digital control panel is a sophisticated touch-pad PID controller that holds set temps with more accuracy than most kitchen ovens. It's simple to operate and offers an integrated meat probe and some useful programming options. For example, you can set it to cook your brisket up to 200°F (93°C) and then drop to a lower cooking temp to keep it warm without overcooking.
From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.

I've had it for right at a year as of the time of this review, and I absolutely LOVE IT. Normally I am of the opinion that you should overspend to get the better product, but I am 100% satisfied with the SE. I've gone through almost 200# of pellets in a year and I've successfully smoked three briskets, pork in various forms, a bunch of whole chickens, salmon, and probably some other thing I'm not thinking of. The show-stopped for me is bacon-wrapped dove breasts. I smoke them for an hour and then finish them on my grill. They are out-of-this-world amazing.
If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.
Never worry about overcooking or burning your food. Masterful control of airflow throughout all chambers allows you to skillfully prepare food with savory natural hardwood flavor. Our propriety exhaust system makes for even grilling and smoking in the main grilling chamber, and sliding damper vents allow great versatility and control when using the upper and lower smoke cabinets. The fan-forced convection airflow in the main barrel allows the grill to work like a convection oven with indirect flame cooking, while the sliding plate on the flame broiler gives the option to sear a steak using direct flame cooking when desired. The removable upper cooking racks in the main barrel adds additional cooking space: cook dinner on the bottom and prepare vegetables and dessert at the same time on the top racks.
With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:

Wood pellet grills are a great addition to any home because they combine everything you love about a smoker with a standard grill. Depending on the model that you buy, you can make smoked dishes like brisket and sausage at the same time that you make burgers, hot dogs and other dishes on the grill. These grills are great for family dinners in the summer and for parties and special occasion celebrations.

Most pellet smokers have a flat drip plate under the cooking grate that diffuses heat and catches grease and gunk. Louisiana uses a curved "Arched Flavor Guard" that mirrors the shape of the lid. The company claims that this design presents a larger surface for meat drippings to sizzle and enhance flavor. The Flavor Guard also has a section over the fire pot that can slide out of the way to expose large, slotted openings, which allow meats to sear over open flame.


Wood pellets are small pieces of hardwood made from compressed sawdust from hardwood. Generally, some wood pellets made for room heating and stoves are produced using some form of binding agent like glue and other additives, which would leave a bad taste and flavor when used for cooking. However, for modern-day grilling, wood pellets are made of pure wooden sawdust and sometimes a little bit of vegetable oil to help it burn. So, nowadays, wood pellets are even better than the real wood chips for grilling.
Save up to $100 during the Green Mountain Grill Early Fall Special Buy.  Shop America's largest online selection of Green Mountain Pellet Grills during the GMG Fall Grilling Season Sales Event including Green Mountain Daniel Boone Grills for as low as $549.99, GMG Grilling Accessories, Davy Crockett Portable Tailgate Grills at $374.99, Jim Bowie Pellet Smokers starting at $724.99, Premium Wood BBQ Pellets, GMG Grill Parts, Green Mountain Grill Pizza Oven Attachments, and much more!  Call Toll Free:  888-313-2737 to speak with an Authorized Green Mountain Grill Dealer.
There is information overload when it comes choosing a pellet grill. This makes it very difficult for most people to make up their mind on a single grill. Getting back to why you can trust us then to get you the best grill? because our backyard grillers have based their unbiased opinion on these different Traeger grill reviews after months of experimenting and research on customer reviews and satisfaction.

Now that we have covered the most important criteria to take into consideration when it comes to quality pellet grills, we wanted to share the cost and the value criteria and why we have included this on this list. Now, It is evident that the more costly the grill is, the better quality designed it will be and the better functions it will have. With that said, most grills that are costly have some of the top of the line premiere features available such as high-quality construction that is rust resistant and up to 600sq in. of grilling space.
PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.

Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
A smoking piece of juicy pork butt will just make your day. Not only does it smell good and taste good, the excitement of grilling and the anticipation of a good meal makes the experience even greater. But if you’re new to cooking and grilling, gathering the correct ingredients for a pork butt might be difficult. So, we’d rather simplify it for you with off the shelf products. If you’d rather make the rub yourself, check out our detailed guide.

You are eligible for a full refund if no ShippingPass-eligible orders have been placed. You cannot receive a refund if you have placed a ShippingPass-eligible order. In this case, the Customer Care team will remove your account from auto-renewal to ensure you are not charged for an additional year and you can continue to use the subscription until the end of your subscription term.
Editor-in-Chief Sean McCoy is a life-long outdoorsman who grew up hunting and fishing central Wisconsin forests and lakes. He joined GearJunkie after a 10-year stint as a newspaperman in the Caribbean, where he learned sailing and wooden-boat repair. Based in GearJunkie's Denver office, McCoy is an avid trail runner, camper, hunter, angler, mountain biker, skier, and beer tester.

There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.

When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.

To see if ShippingPass is right for you, try a 30-day free trial. Also, with ShippingPass, there is no need to worry about commitment. If you decide you want to discontinue the service, you can cancel your subscription at any time. No matter what your shipping needs, Walmart's got you covered. Sign up for ShippingPass so you can shop more, save money and live better.
The Silverbac and the Silverbac original models of the Grilla Grills come with a good build. It has a stainless steel burn grate and a stainless steel firebox with a rugged exterior. It is painted with a high-temperature powder coating on a heavy-duty steel body. The seams are welded, caulked and powder coated for a three-layer weather resistance. Its lid and all the internal components are made of stainless steel, greatly improving this product’s life.
I did a lot of research, and ended up buying the Camp Chef DLX24. It was at a price that fit my budget, (under $500) and had a lot of features the others didnt. The pellet trap door for quick dumping of the pellet hopper into a bucket, and the ash cleanout under the drum was a clincher. Being able to pull a lever and dump the ashes into an easily removable cup is a great feature that all grills should include.It has a digital temperature controller, and dual probes (one inside the smoker for grill temp, one for the meat) and overall good quality construction. The second shelf inside is standard (you pay extra for that on other grills). If your budget allows, would suggest purchasing the propane powered sear box ($199) which attaches to the side of the grill and allows for reverse searing meat..
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
Barbecue was not his first career. He earned a BA from Columbia College in Chicago and studied at the Cleveland Institute of Art and the Dana School of Music. He has been involved in every aspect of film, video and music production. He edited the 1991 Academy Award nominated documentary, "The Mark of the Maker" and "Universal Hotel", which is part of a permanent exhibit at the Dachau Memorial Museum.
I called Traeger to discuss their 10k Commercial smoker. The fellow who answered was polite but not helpful. He said, "You need to call our commercial division. They can answer any question you might have," and gave me the number. This is literally how the conversation went when phone was answered. Me: "Hello I was hoping to talk to someone there about your 10k commercial smoker." Him: "What state you live in?" Me: "Texas." Him: "We don't ship direct to Texas anymore, you will need to call one of our dealers." CLICK. So I am thankful I found out now as there is no way in hell I will spend 10k with Traegar.
Another “set it and forget it” pellet grill, the Camp Chef allows you to set the temperature controls for up to a range of 500 degrees F, and leave it to do the regulating. With its efficient auto-dispensing pellet hopper and digital temperature controls, the pellet grill sets, maintains and adjusts the desired temperature for even cooking each time. With consistent and fuss-free temperature control, you’ll sure to have the most perfectly grilled foods.

I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.


Recently bought portable Traeger ptk+ smoker as camp a lot. Food is amazing though grill size better suited for 2-4 ppl and you can’t fit a large roast. However cooked a rack of ribs, several chickens and burgers. Food comes out amazing. You do need electricity hookup camping and it drains too much power to run off cars dc socket. $300 and of you call them to order v online they will throw in free weather cover free shipping and some rub. It does take up some room in car so beware if you have tiny vehicle. Buyer beware racoons love smoked food so remove your trash bag with bones from campsite before retiring, as we found out the hard way
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.
Traeger's, unlike other models, have a temperature probe, these sensors tell it if the temperature is too low and automatically feeds more pellets to the fire. You can set up the temperature in 5-degree increments. Other brands and cheaper versions only offer three settings low, medium and high. There is no sensor to monitor the temperature. If you are purchasing a pellet grill it is because you can set it and forget it. If you plan to hoover then it makes more sense to use a standard smoker or to transform your grill into a smoker.
We are going to take the guesswork out of it for you. Here at Grills Forever we have seared, smoked and grilled on grill after grill so you can have the latest information on what smokers are the best pellet smoker grills. These best pellet smokers can sear and cook the most delicious foods, they are easy to control and convenient to use. We took all these features and more into consideration while compiling the top 10 wood pellet smoker review.
You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
At the peak level of outdoor cooking, the Champion Competition Pro is a rugged grill and smoker with extensive features that come standard. Clean-up is a breeze with the heavy-duty, porcelain-coated cast-iron cooking grids. Known for superior heat retention, cast-iron makes searing easy. Other features include the stay-cool handle, side shelf with tool hooks and bottle opener, bottom cabinet for storage, robust locking caster wheels for easy movement, and a heavy-duty 14-gauge powder-coated steel finish. Sear or smoke, bake or roast: discover the taste of real wood-fired flavor with the Champion Competition Pro. Comes complete with a weatherproof grill cover.
Tech geeks: A tech geek will also prefer a Pellet smoker grill and some of the latest grills including Green Mountain Grills came up with some exciting tech functionality like Wi-Fi! Just imagine, hanging with friends and monitoring your pork with your smartphone? You can increase and decrease temperature and control pellet feed without even touching the grill. This gives you the ability to cook while you work!
One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.
Most pellet smokers have a flat drip plate under the cooking grate that diffuses heat and catches grease and gunk. Louisiana uses a curved "Arched Flavor Guard" that mirrors the shape of the lid. The company claims that this design presents a larger surface for meat drippings to sizzle and enhance flavor. The Flavor Guard also has a section over the fire pot that can slide out of the way to expose large, slotted openings, which allow meats to sear over open flame.
Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!

Perfect for traveling and tailgating, or even just a smaller patio space, the Traeger Junior Elite 20 is small in size, but delivers big wood-fired barbecue taste. Impress your friends by grilling, smoking, roasting, baking, braising, or BBQing at any tailgate or outdoor activity. The integrated Digital Elite Controller keeps temps within +/- 20 degrees F and makes setting the grill temperature as easy as turning a dial.
The hook rack works great and is a must. The Towel holder works ok but does not work well if there a some wind blowing by. Wants to unroll the towel just enough to make it a possible fire hazard by the gind unwinding the towel rool enought that it can flip up over the wind gaurd and get in the flames. I have to remove it from the camp stove if there is any wind to avoid this problem.
Very often pellet grill manufacturer instruct you to use their pellets, with some going so far as to state that failure to do so will void the warranty. Why? Well, there’s the obvious reason that they want you buy their pellets. However, it really has more to do with ensuring that the grill runs properly, and that starts with using quality pellets. The easiest way for pellet grill makers to guarantee you’re using good pellets is to have you use theirs, which they know meet the desired quality standards. They can’t make that guarantee about another brand of pellets.
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
The grill is plated with beautiful stainless steel that gives the grill a refined and impressive look. The huge cooking area includes 570 square inches of surface area. That’s enough to hold 20 burgers or 4 rib racks! It also contains a second warming rack and bottom shelf that provides the grill stability and extra storage. This version comes with a sear box that can reach temperature of up to 900 degrees Fahrenheit, which caramelizes your food. There’s a cheaper version without a sear box that costs around $200 less if a sear box isn’t a necessity for you. Additionally, the legs are built with extreme thickness giving the grill a grounded base. The caster wheels add portability to the grill so you can find that perfect place in the backyard.
So back to the Internet for one last attempt on making a decision on the smoker that is of great quality and can also fill my need grilling needs as well. I am almost sold on the Rec Tec, but I’m curious about the Grilla Grill Silverbac. It’s a little smaller than RT and metal is a gauge off from the RT. It doesn’t run off a PID system but a digital controller and is priced at $699. I do like the underneath storage of the Grilla and the second tier cooking grates.
Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
I always encourage consumers to get to know a little bit about a brand and company before purchasing a product from them. What differentiates a smart consumer from a consumer is preparedness. Get to know about the company history, its commitment to consumers, its consumer service, after-sales services and warranty. It is also a great idea if you can go through consumer ratings and reports the company’s pellet grill review before buying it. Do not just fall for intelligent marketing and chic packaging. Get you facts checked; remember it is your hard earned money on the line.

The Fast Eddy's by Cookshack PG500 Pellet Smoker is a collaborative design from respected smoker manufacturer Cookshack and competition-barbecue-circuit pro "Fast Eddy" Maurin. The FEC (Fast Eddy's by Cookshack) line has been popular with competitive teams for years. While most FEC models have a utilitarian appearance, the beautifully crafted stainless steel PG500 fits right in with your shiny outdoor kitchen.
Just finished my first smoke on the YS640, ribs and chicken thighs. This machine is amazing. It couldn't be simpler to use. The chicken was the best I have ever tasted. The ATBBQ team was great, with fast shipping and they threw in some extras. I could not be happier and can't wait for years of great food off the YS640. Don't hesitate to buy this cooker or to order from ATBBQ.
So, when their patent expired in 2006, large companies capitalized on that one and Traeger began facing cut-throat competitions. Within two years, a few companies had already begun producing some of the best pellet grills with more advanced designs and features. By 2014, around 27 companies had already penetrated the market and newer brands were coming out almost every month. Now, with so many companies already in the market, some of them are creating strategic alliances with other brands producing different grilling equipment.
Good info, but it’s missing something… the cost to use. I’ve been looking for a long time to get into smoking. I have only ever used a propane setup for grilling. My main quesion is the cost to use propane vs charcoal vs pellets. I’m very interested in pellet smoking AND grilling. A couple times a week my wife and I will grill some chicken breasts or steaks. Can you breakout an approximate cost comparison to run the different methods? Appreciate it!
This will work using one burner only on the stove when connected to our RV exterior grill connection port. Our camp chef portable stove has one large and one standard burner. It would only operate on the standard burner due to the low pressure regulated on the RV piping system. Be prepared to break out the standard propane tank & regulator hose set if you plan on running a two or three burner camp chef stove. Rating is 4 stars due to the price and short length at $35 price tag, it could have been longer.
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
Editor's Note: If you're looking to upgrade your backyard cooking setup this summer, you're probably in need of a little advice. We're longtime admirers of the folks behind AmazingRibs.com, the site dedicated to unraveling the science of barbecue and grilling. Please welcome back Max Good, the only person in the world whose full-time job is testing, rating, and reviewing grills and smokers. The database he maintains includes over 500 grills and smokers, ranging in price from $30 to $50,000. When it comes to barbecue equipment, nobody knows it better.
A quality pellet grill is built to last and will provide years of reliable performance. Bargain pellet grills not only lack the capabilities of better grills, they’re more likely to break down. No matter your price range, look for a pellet grill that’s built well and offers consistent performance. Fortunately, if price is a major consideration, there are quality pellet grills for under $500, as well as high-end pellet grills for under $1,000.
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!
Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.

There is no doubt that grilled food tastes better, especially if it is done with wood pellets. This is because it retains the smoky flavor of the wood pellets. However, there are always health concerns when it comes to meals that are grilled. The main issue is always the animal fat, which burns, resulting in the formation of heterocyclic amines, HCAs. This harmful chemical is a known cause of cancer as it easily fills the smoke that permeates into your food.
I’ve seen a lot of pellet smokers over the years, and it’s easy to say that out of every one, the RecTec is without a doubt a beast. It combines exceptional cooking performance with fantastic build quality and a thoughtfulness of design that you just don’t see in other smokers. Or a lot of other products. Not only that, but it’s one of the easiest smokers I’ve ever used, with professional quality cooking literally at the push of a button
With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
The Smart Smoke technology is one of the most convenient and easy to use features on the grill. It contains a dual LED temperature readout that keeps the heat at a constant temperature. This means you have more time for socializing and can sit back and relax. The temperature ranges from 160 to 500 degrees Fahrenheit. The grill uses a pellet feeder system that burns slowly to add intense flavor to your food. It also uses an electric auto-start ignition that requires the grill be plugged into a standard 120v outlet.
Of course, we recommend our pellets and have proven them to work fantastically with all of our grills, but we would never be short-sighted enough to say that our owners must only use our pellets.  That just seems a bit, well, wrong.  From our testing and customer feedback, the following brands all worked very well:  B&B, BBQrs Delight, Cooking Pellets.com, Lumberjack and Smoke Ring.
Whenever you want to smoke with a pellet smoker, you will have to make a choice: What type of wood pellets should I use? Well, the answer may sound simple – whichever flavor you like the best – but might be pretty difficult if you’re smoking for the first time. Unfortunately, the only way to know which flavor you like most is to try them all at least once and then decide upon which one floats your boat.

4 years ago I made a 700 hundred dollar mistake a bought a China made grill it never worked right from day one. My wife suggested that I should replace it. I decided I wanted a us made grill after seeing the yoder series and all of the great reviews I couldn't wait for it to arrive.so glad a bought the ys640 works like a dream, any one reads these reviews and buys another grill you have made a mistake
A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs.
The argument for bark is that it smolders really well, providing more smoke during the cook and therefore more smokey flavor. Think about it: When you put a log on the fire, the bark almost immediately begins to smoke and smolder. And therein lies the second half of the pro-bark argument: when cooking on an offset you use logs with bark, so why should pellets be any different?
The major issue is the size. It’s the smallest smoker at this price range, and barely bigger than the Junior Elite. Considering the price difference in the two, it’s hard to justify the extra expense, and when you compare it to the other smokers at this level, the Lil Tex seems more than a little lackluster. There’s less cleaning options, less automation, less cooking space. Just less of everything.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
Ever since my visit(s) to All Things BBQ in Wichita, my heart has belonged to the Yoder Smokers. I had researched many comparable size smokers, and guess what - they really are not comparable. The smoker started first time, quickly, and heated up well. I did ribs as my first foray and they were as perfect as my meager talents could get them. The fact that this smoker weighs in at almost 360 pounds speaks volumes as to how well built and how heavy gauge the metal is( something severely lacking in most other smokers). I had the extra shelf put in and the cooking space is easily double what I had seen in other smokers about the same dimensions. Hats off to All Things BBQ for the high quality Yoder smokers they so proudly distribute!!
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
Hey John – great question. My experience is that I use maybe 8 lbs of pellets for a 7 or 8 hour cook at 275 degrees. Pellet grills are relatively fuel efficient. The brand of pellet you choose will play into this. Cost for pellets varies by manufacturer, similar to charcoal. I think you’ll find them very efficient if you’re just firing them up for high heat, shorter grilling sessions.

To compound the complexity of this issue the consumer also has to deal with some grill manufacturers recommending the use of only their branded pellets.  Then to make matters even worse pellet consumers have to navigate all the different flavors available and whether to use a blended pellet (a blend of multiple kinds of wood such as oak, hickory, and cherry) or a 100% pure pellet (a pellet that uses only the flavor listed on the package).   This doesn’t even take into consideration some pellet companies using things such as oils and fillers in their pellets.
I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down.  I did this routine a few more times with customer service and it kept shutting down, day after day.  Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts)  Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call.

Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China.
Yo, Kevin! Hope that you can soon review one of my all-time favorite purchases, the Traeger Li’l Tex Elite Smoker/Grill. After using it for a couple of months, I gave away my two year old gas-grill to my grandson. We’ve done chicken, turkey, pheasant, lamb, all kinds of beef, pork and sausages including some wonderful ribs and brisket. Our Easter Rib Roast turned out terrific as did the chunks of assorted sausages that we did for another family get-together. I was never a big fan of grilling until we got our Traeger. Both Traeger and the web-sites like yours are full of great recipes and ideas.
×