Cleaning and Maintenance: Keeping the grill clean is critical if you need to get the most out of the unit. Old debris can influence the viability of the unit thus normal cleaning is vital. In addition, while moving it around, take alert not to thump it since it accompanies little legs which can without much of a stretch tip over the unit when thumped.
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?
Local availability of pellets is only one problem though. How are you, the consumer, supposed to know which is a good pellet brand versus a bad? If you do a Google search for “where to buy pellets” you are likely only to see a lot of advertisements all proclaiming their product to be the best. This situation is very akin to what consumers in the charcoal industry deal with as well.
So, we’re here to discuss the different cooking times and temperatures for different types of meat so that you don’t overcook or undercook your meal. But for the health concious, they should avoid certain meats. It’s worth noting that we’re here to discuss the temperatures needed for slow cooking and these should not be considered as universal standards for searing or grilling.
There is no doubt that grilled food tastes better, especially if it is done with wood pellets. This is because it retains the smoky flavor of the wood pellets. However, there are always health concerns when it comes to meals that are grilled. The main issue is always the animal fat, which burns, resulting in the formation of heterocyclic amines, HCAs. This harmful chemical is a known cause of cancer as it easily fills the smoke that permeates into your food.
The best way to ensure your pellet grill lasts for years to come is to purchase one that's built well and features quality construction. If you're in the store, lift the lid and feel its weight—is it flimsy or made from a heavier gauge steel? Pellet grills aren't like offset smokers, they don't need to be hefty, but they shouldn't feel delicate either. When you close the lid, see how it lays on the grill—are there gaps or is it flush, providing a good seal? Check out the joints, the hardware, and any welding—does the grill feel solid? It should be sturdy and all the joints and seams should fit together snugly, no gaps or spaces for heat to escape.
Extremely high build quality. It's heavy. Solid. Nothing flexes or bends. The temp displayed is very accurate when referenced with a thermometer. My only complaint is that the 2-piece diffuser should either be standard equipment, or an optional upgrade at order time (in exchange with the stock diffuser). The 2-piece diffuser is a MUST HAVE accessory. Cleaning the firepot is a messy pain the A** without the 2-piece diffuser. I didn't think I would need it, But I ended up ordering it about 6 weeks after receiving my YS640. I also highly recommend the direct grilling grates. I was able to get rid of my gas BBQ because the direct grilling feature works so well on the YS640.
From boiling brewing frying or whatever the job From boiling brewing frying or whatever the job might be this little stove has the power to get it done. The maximum output high-pressure burner system heats mass amounts of liquid in a hurry and will maintain it at boiling temperatures making it a great cooker for home canning and ... More + Product Details Close
This is the right choice for anyone that likes smokey flavors and cooking slow at home. It is my first experience with a pellet grill and I have read and studied them for a while. I was looking for a outdoor cooking solution that would give me the ability to cook like the pros without the super sized trailer. Finally deciding to go with the Camp Chef I haven't been disappointed. The temperature control is flawless so you can dial down the cooking process. I smoked chicken the other day and the red smoke ring was a 1/2" deep. It works like a convection oven so there are no cool or hot zones, it just keeps the heat even and consistent. I have noticed even if smoke isn't pouring out the wood flavors are present.
I've been wanting a Yoder for the last year and a half. Finally pulled the trigger on a 640 a couple months ago. Absolutely fantastic. I've been a Weber guy forever and this is my first smoker. This defiantly took my food over the top. My 640 has been incredibly accurate with keeping the heat on the grate to the setting I punch in. Just finished my first brisket and it was fantastic. The only way to go!
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
Thanks for the quick response and advice. I see a pellet pro hopper assembly is around $250 compared to the Memphis pro at over $2000. I didn’t realize that drafting isn’t important for the sake of temp regulation but what about how the smoke travels from the firebox towards the meat? I also would like to include an element of humidity, is simply putting a pan of water in the cooker or is there a better way?
Hey Dan – I think you’d really up your versatility with a good pellet smoker. Smoke profiles seem to depend largely on the quality of pellets used and then also on the burn consistency of the fire pot. What I mean here is that many pellet smoker users tell me that they prefer models that cycle over faster with frequent temp checks rather than those with longer wait times between temp checks. Cycling faster means that pellets burn more consistently and do not rest to a “charred” state and they “reactivate” This latter problem sometimes results in less than optimal flavor. Yoder smokers cycle very fast and are preferred by many due to this and their thicker metal construction.
DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork
The real innovative feature of this monster pellet grills is that with it can be divided into two independent grills or opened up into one that can accommodate a whole hog (though a rather small one). The best part of this is that it can be a 600 square inch pellet grill when it needs to be or a 1,200 square inch grill when it has to be. For the person who might need to do a lot of cooking once in a while, this is a very good option. With two pellet controllers, mounted on opposite ends this pellet grills has all the versatility imaginable.
Another “set it and forget it” pellet grill, the Camp Chef allows you to set the temperature controls for up to a range of 500 degrees F, and leave it to do the regulating. With its efficient auto-dispensing pellet hopper and digital temperature controls, the pellet grill sets, maintains and adjusts the desired temperature for even cooking each time. With consistent and fuss-free temperature control, you’ll sure to have the most perfectly grilled foods.
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
*Big R strives for accuracy in our advertising, but errors in pricing, photography, and/or description may occur. Big R reserves the right to correct any such errors. Photography is for illustration purposes only and may not reflect actual product. Big R reserves the right to limit quantities ordered and the right to accept or decline any E-Commerce order.
The hook rack works great and is a must. The Towel holder works ok but does not work well if there a some wind blowing by. Wants to unroll the towel just enough to make it a possible fire hazard by the gind unwinding the towel rool enought that it can flip up over the wind gaurd and get in the flames. I have to remove it from the camp stove if there is any wind to avoid this problem.
A: As one of the most frequently asked questions, consumers want to know if the grill comes with a grill cover to protect the grill. With that said, most brands do have a grill cover when it comes to the grill. However, it is important to always as the manufacturer if they include a grill cover with the purchase. In most cases, the grill cover is made from some of the best materials in the industry for durability and functionality.
My husband used my two cast iron dutch ovens to make corned beef, but neglected to wash out the pots afterward. Needless to say, when I discovered the ruination of the years of seasoning destroyed by the salt brine, I wanted to cry. This product is so much better than using vegetable oil or shortening as I have done in the past. It seals the surfaces well and does not leave a sticky residue. Hope it gets back to at least an approximation of the old coating. Only time will tell.
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
A FOLLOW UP: Traeger has agreed to send me replacement parts for the defective ones and I don't have to return them. However I am not returning the grill. I tried to cook a prime rib and a Boston butt. The grill randomly turned off three times and it had the "mini-explosion" others have talked about where the unit actually has an explosion within the housing lifting off the lid a couple inches and making a loud boom. This is not only a potential safety issue, but the "set and forget" is simply not true. It turned off within an hour after setting the temperature at 225 and leaving it unattended for an hour. This is not what I expected or wanted. Sorry Traeger quality is not what it is cranked up to be and certainly not worth the premium pricing they charge for their name. DON'T BUY THIS IF YOU EXPECT TO GET A GRILL THAT WORKS AS ADVERTIZED.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
I purchased my first Traeger Grills over a year and a half ago and now I am on my third grill. I have had the most amazing experience grilling, smoking and baking. I do everything on my Traeger. It accurately holds the temperature, starts up automatically and has convection which cooks my food evenly and thoroughly. I recommend this grill to anybody who’s looking for a amazing cooking experience with little effort and really likes to show off to their friends how good their food tastes. My favorite part is being able to walk away from the grill and not have to babysit it so I can do overnight briskets without even checking them. I love it.
Pellets not Lighting: It’s a simple issue. There is a problem either with the connection of your lighting rod or a damaged system. Repairing the wiring, if that’s where the problem is, might be a little complicated for most. So, for the average griller, the best and the easiest option is to replace the lighting mechanism altogether. When you buy the replacement part, it will come with a detailed instruction manual that anyone can follow.
It can be said often enough: the best pellet grill is the one that's best for you. Ultimately, you're the one paying for it and you're the one who will be cooking on it, so make sure whatever pellet grill you choose is the one you'll be happy with. Just because you're friend has no qualms paying top dollar for the most advanced grill on the market doesn't mean you should feel bad about spending half as much on a grill that does the things you want it to do. The best advice: do your research, be informed, and know what you're purchasing. If you can do that, you're unlikely to experience buyer's remorse.
With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.
This pellet smoker will bring your outdoor cooking experience to an entire new level with its massive 560 cubic meter cooking area that comes with one removable rack. It can reach temperatures of up to 500 degrees F which makes it an excellent choice for grilling, smoking, braising, baking, BBQ and roasting. Reasonably priced, it’s a great investment. It’s made of high-quality materials and superior digital controls, including LED controls and auto pellet feeder. Cleanup is also 60% less demanding because the convenient trap door is for burn pot cleaning. With this efficient pellet smoker, the money you spent will be worth it.
So back to the Internet for one last attempt on making a decision on the smoker that is of great quality and can also fill my need grilling needs as well. I am almost sold on the Rec Tec, but I’m curious about the Grilla Grill Silverbac. It’s a little smaller than RT and metal is a gauge off from the RT. It doesn’t run off a PID system but a digital controller and is priced at $699. I do like the underneath storage of the Grilla and the second tier cooking grates.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazonhttps://tinyurl.com/amazingribs
Hey Bill! I think you’d be very happy with a Yoder pellet smoker. From a product and manufacturing standpoint, they’re great pellet smokers. If you’re looking at spending $1,700 and can perhaps go a little higher, you can then consider either a MAK grill or a Memphis Grill Pro Series. These are fantastic pieces of equipment. They are insulated at the point where the lid touches the body at closing, and provide superior convection cooking. Anytime you feel you want some extra smoke, you can always throw in an Amazn Pellet Tube or use a Mojo Cube. These will amp up your smoke profile in a manner you can predict and keep under control. I would NOT recommend adding anything foreign to your burn pot ever. Just keep things from the main pellet smoker function working as per the manufacturer’s design.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
The first thing we have to understand is the anatomy of a pellet smoker. Check the related section on this page to get the idea. Once we know which part goes where, the bigger battle will be won. Next, we’re going to have to be able to analyze the problem if we are to solve it. What seems to be the issue? Are the pellets not lighting up? Are the pellets getting stuck and not working properly? Weird noises coming out from the hopper? Are foods not cooking well? Let’s take a look at these problems and how to solve them:
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
A charcoal unit is going to provide a more powerful authentic smoke flavor when compared to a pellet smoker.Electric pellet smoker reviews show that gas smokers and pellet smokers are comparable in that they both can be set to a particular temperature and left alone. The one advantage that a pellet smoker has over a gas smoker is that with a pellet smoker, you can actually say that you are cooking with wood because the pellets are compressed wood.
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.
I watched the Traeger infomercial on T.V. Seemed easy enough. Ha! QVC ran a similar infomercial on their channel, seemed really easy. Ha! Like a fool and his money are soon departed, I jumped in and bought one. When it came in the mail, I started to assemble it. What a joke! No instructions came with it to tell me where the nuts and screws went. Called the manufacturer. The lady said they had many complaints with the QVC orders, she would email me a copy of the instructions. Well I finally put it together. Performed the (curing and start up method). Bought a nice pork shoulder and started grilling. It is interesting that both infomercials say set the temp and WALK AWAY!!! What a joke, I sat and watched the grill like a hawk for 3 hours, everything was good. I figured I would go eat lunch, ha! What a mistake. When I came back (20 min.) the grill had turned itself off and had an error on the screen.
SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase
Even if you’ve got a meat thermometer at home, it’s not a bad idea to pick up a smoker with one built in. This is because the built in thermometers send their readings straight to the smokers computer and it automatically adjusts how it’s cooking based not just on how hot it is inside, but how this affects what you’re cooking. Now, unless you’re Gordon Ramsey you probably can’t tell what’s going on inside that turkey you’re cooking, so this is obviously a major plus.
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.
This website has a lot of negative reviews... I mixed some salt and pepper, rubbed onto some ribs, and put on the Traeger. After about 5 hours sitting in my a/c living room, looking out the window, at perfectly managed temp, the ribs were done, perfect, juicy, with a beautiful wood smoky flavor that I've never gotten on charcoal or even in restaurants with professional pitmasters and all. I did phone Traeger when I was putting the grill together and doing the 1st burn in, there were humans there (!) and they were knowledgeable and helpful on the 1st time.
And of course, it’s definitely a plus when the company that makes your grill includes a multi-year warranty and top notch customer service. Pellet grills are finicky compared to gas or charcoal grills simply because there are so many more parts that require electronics or that have electrical components… which means there is a fair bit more that can actually go wrong or require service at some point.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!