I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down.  I did this routine a few more times with customer service and it kept shutting down, day after day.  Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts)  Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.

The cooking process is made a lot more convenient with this smoker. To start cooking, all you need to do is flip the Traeger on/off switch, and you’re good to go. Then, you can simply set your desired temperature through the digital controls. Enjoy your time and relax while you leave the unit to do everything else. With its efficient temperature control system and automated auger with an induction fan, heat remains constant throughout the cooking process. You’ll have evenly-cooked foods that have that mouth-watering smoky flavor in no time.

This pellet smoker will bring your outdoor cooking experience to an entire new level with its massive 560 cubic meter cooking area that comes with one removable rack. It can reach temperatures of up to 500 degrees F which makes it an excellent choice for grilling, smoking, braising, baking, BBQ and roasting. Reasonably priced, it’s a great investment. It’s made of high-quality materials and superior digital controls, including LED controls and auto pellet feeder. Cleanup is also 60% less demanding because the convenient trap door is for burn pot cleaning. With this efficient pellet smoker, the money you spent will be worth it.


Certain statements in this press release, including statements regarding the expected future financial performance of Camp Chef and the impact of that performance on Vista Outdoor, constitute forward-looking statements as defined in the Private Securities Litigation Reform Act of 1995. The words 'believe', 'expect', 'anticipate', 'intend', 'aim', 'should' and similar expressions are intended to identify such forward-looking statements. All such forward-looking statements involve estimates and assumptions and are subject to a number of risks and uncertainties, many of which are beyond Vista Outdoor's control, which could cause actual results to differ materially from the expectations described in the forward-looking statements. Among those risks and uncertainties are: assumptions regarding demand for Camp Chef's products; the risk that the anticipated benefits and cost savings from the transaction may not be fully realized or may take longer than expected to realize; the ability of Vista Outdoor to retain and hire key personnel and maintain relationships with customers, suppliers and other business partners of Camp Chef; costs or difficulties related to the integration of the business following completion of the transaction; and changes in the business, industry or economic conditions or competitive environment. Vista Outdoor undertakes no obligation to update any forward-looking statements. For further information on factors that could impact Vista Outdoor, and the statements contained herein, please refer to Vista Outdoor's most recent Annual Report on Form 10-K and any subsequent quarterly reports on Form 10-Q and current reports on Form 8-K filed with the U.S. Securities and Exchange Commission.

What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
Thanks Kevin for the reviews and content. Like many of the folks I too will be purchasing a pellet pooper. I have narrowed my choices to a MAK 2 star and a Memphis Elite. One of the earlier posters indicated on the Memphis that the effective direct grilling space was about 1 square foot. I am assuming that with the smaller footprint of the MAK that the direct “flame zone” is less than that. I’m just wondering how much less.

Ready for the camp or cabin, this reliable, no-frills stove features two 30,000-BTU commercial-grade cast burners. The all-steel range features sturdy grates built to support hefty cast-iron cookware. It's surrounded by a three-sided steel screen to block drafts and grease splatter. The heavy-duty steel legs slide off for transportation and storage. Cooks up to 15 hours on a 20-lb. propane cylinder (not included). Includes hose and regulator.

At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.

This is definitely our top pick for a Traeger grill, due to its level of versatility. It can grill, bake, smoke, braise, roast, and barbecue. It is consistent in its cooking, making it ideal for use with large gatherings. Moreover, it is easy to auto-start and has a digital control. In addition, cleaning it is not that hard, as it has non-stick grill grates.

I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.
Thanks Kevin. I am about to buy both a 5 burner gas grill and a smoker for a new bbq island. Rather than buy both, will one of these higher end pellet grills take the place of a traditional propane grill? I can apply the funds for the gas grill to a higher end pellet if it can really do double duty. It has to be able to cook burgers and dogs and steaks etc. Just like a gas grill though. Thoughts?

With their portable model, Traeger has their own version of the classic 'tailgater'. Still fairly hefty at a little over 60 pounds, this grill is still far and away the most lightweight model Traeger offers. The legs fold up for ease of storage and transportation. As with all other Traeger products, temperature controls allow grillers to use the Tailgater as either a conventional grill or a smoker.
DS, I have a green mountain grill. besides that for any pellet smoker cook your chicken at a high heat otherwise the skin will be rubbery. doesnt have to be a direct flame to get it crispy. I set my GMG to 425 flip it after 8 mins pull it at 170 crispy perfection. if you want more smoke flavor, smoke it at 150 for an hour then crank it up to 425 to finish it. I was upset with my rubbery skin when i first used it as well but i got some good advice from the pros. chicken doesnt need to be cooked low and slow to tenderize it like pork and beef does. it doesnt have the tissues or muscles that need to be broken down like beef and pork
My wife and I purchased this over the weekend. Been wanting this grill for a while. $349.99 includes cookbook, 3 years warranty +costco visa warranty. They also had the lil tex and the other bigger grills at reasonable prices. Links are for the locations for their "roadshow" in order to capture the prices. Technically doesn't come with the cover but I convinced the rep to throw one in.
Hey Eric! Man, thank you for the kind words. While I don’t post every day, I do try to make what I share with you guys as informative as possible. To that end, your words mean a lot. Now, the pellet release option is a great feature to have on any pellet smoker. In cases where you don’t have one, I suggest using a small shop vac you use just for pellet removal. Works great. But the quick release chute option saves a ton of time and effort for sure. Not what I’d call a deal breaker if a pellet smoker you like doesn’t have one. However, I’d like to see it become standard on pellet smokers for sure!
Igniter: An igniting rod, heated up to a red hot level, ignites wood pellets as they fall inside the firebox. A cooling fan blows air into the pellet smoker from behind the pellet auger to prevent heat backdraft, while the fan underneath the firebox fans the flame – distributing heat evenly throughout the smoker. This heat is used to smoke and slow cook food in the smoker to give it the best flavors possible.
Buying factory direct means that you are purchasing a product directly from the manufacturer, which eliminates the need for a middleman. There’s no need for the product to go through any kind of supply chain and acquire additional costs in order to reach you. The price tag that’s displayed on factory direct products doesn’t contain any markup to compensate for additional costs. Buying factory direct gives you the best chance at receiving the lowest price possible for the product you’re purchasing.
Maintenance is an issue. There are moving parts on these grills. Moving parts eventually break. There is an auger with a motor, and a fan with a motor. There are proprietary electronics systems on these babies. Augers clog. Motors burn out. Electronics have bugs or fail. Especially when exposed to rain, snow, hot, and cold. When they fail, will the manufacturer have a replacement part?
My traeger has had some good moments but it very unreliable. I really do not enjoy cooking with it. I have no confidence in the temp readings and the smoke control. Every time I open the lid the temp drops like 200 degrees. I'll smoke at the "smoke" setting but as soon as I turn it to 225 it spikes to like 300-500 degrees. Wtf? I thought this POS was supposed to be a set it and forget it type smoker. Very unreliable. Temp fluctuates so much and if there is even a slight breeze the temps just go up and down up and down. The pellet feeder is garbage. It will all the sudden just start smoking like crazy because the pellets have jammed into the burner. Completely ridiculous smoker. I use it still but only when I can sit and watch the feeder. The guys comment below is true about the feeder always just using the middle pellets. I always have to check it and push the pellets to the center. Some simple engineering would change this. Never again will I purchase a traeger. There are much better options out there and better price.
Most pellet smokers have a flat drip plate under the cooking grate that diffuses heat and catches grease and gunk. Louisiana uses a curved "Arched Flavor Guard" that mirrors the shape of the lid. The company claims that this design presents a larger surface for meat drippings to sizzle and enhance flavor. The Flavor Guard also has a section over the fire pot that can slide out of the way to expose large, slotted openings, which allow meats to sear over open flame.

I had my Traeger grill now at least a week. Not really satisfied because every time I use it it does good for about a hour then it starts to cool down very quickly. Have to turn it off and start over and over again. This take all day to do this. I should not have to do this all day. Just a waste of pellets. Done wasted a whole bag of pellets. Called customer service. They tell me do the same thing. I think a grill should not do this. The meat I cook sometimes is not cooked. Have to start over again. All of this I have described take hrs. Have to stay outdoor to babysit. This grill should not have to do this. That tell me the grill is not good.
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...
I have yet to have any problems with my smoker, other that what I caused for myself. Please follow the instructions on covering the heat diffuser plate with aluminium foil. When fat from the meats that you are cooking (mine was chicken) it will cook right there, and is difficult to get off. When you follow instructions, this cooker is a dream come true.

Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.
Thanks for the great information and the research you did. I am a retail store owner in Boise, Idaho area and we sell a pellet grill smoker in our store. I would like to encourage to look at the Sawtooth Pellet Grill. It is made local here and is American Made. It is an excellent grill for the price with an awesome company backing it. You can find their website at sawtoothpelletgrills.com. Again thanks for the information and if you do another publication regarding pellet grills, I would love to see what your opinion of the Sawtooth would be 🙂
I've been wanting a Yoder for the last year and a half. Finally pulled the trigger on a 640 a couple months ago. Absolutely fantastic. I've been a Weber guy forever and this is my first smoker. This defiantly took my food over the top. My 640 has been incredibly accurate with keeping the heat on the grate to the setting I punch in. Just finished my first brisket and it was fantastic. The only way to go!
From boiling brewing frying or whatever the job From boiling brewing frying or whatever the job might be this little stove has the power to get it done. The maximum output high-pressure burner system heats mass amounts of liquid in a hurry and will maintain it at boiling temperatures making it a great cooker for home canning and ...  More + Product Details Close

I’ve seen a lot of pellet smokers over the years, and it’s easy to say that out of every one, the RecTec is without a doubt a beast. It combines exceptional cooking performance with fantastic build quality and a thoughtfulness of design that you just don’t see in other smokers. Or a lot of other products. Not only that, but it’s one of the easiest smokers I’ve ever used, with professional quality cooking literally at the push of a button

Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
I called Traeger to discuss their 10k Commercial smoker. The fellow who answered was polite but not helpful. He said, "You need to call our commercial division. They can answer any question you might have," and gave me the number. This is literally how the conversation went when phone was answered. Me: "Hello I was hoping to talk to someone there about your 10k commercial smoker." Him: "What state you live in?" Me: "Texas." Him: "We don't ship direct to Texas anymore, you will need to call one of our dealers." CLICK. So I am thankful I found out now as there is no way in hell I will spend 10k with Traegar.

Through the years, pellet smokers have gained popularity. The fact that they give you the convenience of being able to hold a barbecue from the comfort of your home is what makes them ideal. However, not all of them will match up to the needs that you have and this is why I put together this guide with reviews. Following this guide, you should be in a position to make a comprehensive decision on the specific model to buy.

Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.
A: As one of the most frequently asked questions, consumers want to know if the grill comes with a grill cover to protect the grill. With that said, most brands do have a grill cover when it comes to the grill. However, it is important to always as the manufacturer if they include a grill cover with the purchase. In most cases, the grill cover is made from some of the best materials in the industry for durability and functionality.

The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
It’s got built in manual controls, but there’s also the option to download an app to your phone so you can control your smoker through your wifi! Honestly, this really impressed me, and I don’t know why other manufacturers aren’t all over this. Apparently there’s a cloud based app coming out soon so you can control your grill anywhere you can get internet, so you could be sitting at your kids football game whilst checking the status of your post-victory feast! The controls are also fully programmable, so you could for example set it to smoke for 5 hours and then cook for 2, finishing just as you pull up onto your drive.

The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!
The first thing we have to understand is the anatomy of a pellet smoker. Check the related section on this page to get the idea. Once we know which part goes where, the bigger battle will be won. Next, we’re going to have to be able to analyze the problem if we are to solve it. What seems to be the issue? Are the pellets not lighting up? Are the pellets getting stuck and not working properly? Weird noises coming out from the hopper? Are foods not cooking well? Let’s take a look at these problems and how to solve them:
Aside from durability, a well-built pellet grill has another significant advantage: It will perform better. High-quality materials and good construction allow the grill to retain heat better, making it more efficient and providing better pellet consumption, even in cold weather. Furthermore, it's unlikely that a brand offering a cheaply made grill invested much time designing it to maximize airflow or engineering a control board that can hold a tight temperature.
Green Mountain pellet smokers offer innovation and good quality as well as relatively low price points. The Daniel Boone model is the midsized version. It boasts an advanced digital touch-pad dual-probe controller and stainless steel grates and drip pan, and, with 13.5 inches of headroom, Daniel Boone can accommodate large turkeys and roasts. Although the WiFi option adds a hundred bucks to the bill, few pellet smokers anywhere near GMG's price range offer WiFi control. Download the GMG app to your smartphone or tablet for a point-to-point connection, enabling you to remotely turn Daniel Boone on and off; monitor and control the internal meat temp, cooking temp, and timer; and even store the time- and temperature-based profiles of your favorite recipes. For example, you can set your Daniel Boone to "Tri-Tip Beef Roast" and have it start out cooking at 225°F (105°C) until the internal meat temp hits 110°F (43°C), then crank to 500°F (260°C) for browning until the meat registers 135° (57°C), then drop the temp to 150°F (65°C) to keep it warm.
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
×