I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
While using and running a pellet grill is child’s play, catching the right offer on pellet grills can be a hassle for consumers who have little to know clue about it can prove a costly bargain. Knowing your facts prior to buying one is always a good a smart idea. My pellet grill review will do the best it can to educate you on the things you need to look out for when purchasing your perfect grill. Here are a few heads-up:

There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂

It's true that even the entry-level models of pellet smokers are a bit pricey. But I've never met an unhappy pellet smoker owner, even if they paid a few hundred bucks more than the cost of their neighbor's grill. And manufacturers are rising to meet increased consumer demand, with more selections, more features, and more competitive pricing. While many folks struggle trying to get cheap offset and bullet smokers to work, with a pellet smoker, it's easy to make the best smoked ribs, brisket, and pulled pork in the neighborhood.


Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.

We all know about Davy Crockett and Daniel Boone, but Traeger is the true pioneer of pellet smoking. This company introduced the first pellet smokers, and it remains the best-known brand, although competition is growing. There's nothing fancy here. Instead of a touch-pad controller, Traeger employs an older-style digital dial controller. No WiFi or meat probes; just no-frills schmokin' from the industry leader.


As far as backyard cookers go, Pellet Grills are the newest products on the market. With their roots in the 1970’s, these versatile outdoor grills combine the capabilities of a traditional grill, with the wood-fired flavor of a smoker, and even the convenience of a modern oven. The “Pellet” in the name refers to the specific variety of fuel used. These are specially made cylinders constructed of compressed sawdust. The grill is powered by electricity and doles out specific amounts of pellets to maximize fuel efficiency. The primary benefit of these types of grills is their versatility. Wood pellets can be burned at all different temperatures and volumes, making it possible to sear, smoke, or slow cook a whole array of meats in an infinite variety of styles.
The smoker does not hold temperature. I called the service dept and they sent a new controller card and it does not hold temp either. When I contacted the service dept they told me that the grills do not hold temp at the 225 degree setting. If you look at all the Traeger literature and cookbook and recipes all say to smoke at 225. As does every other smoking cookbook. So Traeger manufactures and sells a known defective product. DO NOT BUY TRAEGER.
We ended up going with the Memphis Pro. We were fortunate enough to be able to see all of the manufacturers and models I was most interested in, at Sam’s NW BBQ. (Yoder, MAK, Fast Eddy, GMG’s, a few others, and then, the one we ended up with, Memphis.) Sam took a good amount of time, providing us fantastic information about each model. We ended up with the Memphis Pro for the following reasons: 1) The construction, mainly the double-walled construction; 2) the preciseness of temperature, and being able to hold the temperature (due to reason #1); 3) the extreme ease of changing from smoking to grilling without a lot of effort or reconfiguration; 4) the double hoppers; 5) and another BIGGIE, the fact that grilled or baked foods taste like that, and not like smoked cookies, bread, pizza, etc.

I've been wanting a Yoder for the last year and a half. Finally pulled the trigger on a 640 a couple months ago. Absolutely fantastic. I've been a Weber guy forever and this is my first smoker. This defiantly took my food over the top. My 640 has been incredibly accurate with keeping the heat on the grate to the setting I punch in. Just finished my first brisket and it was fantastic. The only way to go!
!function(n,t){function r(e,n){return Object.prototype.hasOwnProperty.call(e,n)}function i(e){return void 0===e}if(n){var o={},s=n.TraceKit,a=[].slice,l="?";o.noConflict=function(){return n.TraceKit=s,o},o.wrap=function(e){function n(){try{return e.apply(this,arguments)}catch(e){throw o.report(e),e}}return n},o.report=function(){function e(e){l(),h.push(e)}function t(e){for(var n=h.length-1;n>=0;--n)h[n]===e&&h.splice(n,1)}function i(e,n){var t=null;if(!n||o.collectWindowErrors){for(var i in h)if(r(h,i))try{h[i].apply(null,[e].concat(a.call(arguments,2)))}catch(e){t=e}if(t)throw t}}function s(e,n,t,r,s){var a=null;if(w)o.computeStackTrace.augmentStackTraceWithInitialElement(w,n,t,e),u();else if(s)a=o.computeStackTrace(s),i(a,!0);else{var l={url:n,line:t,column:r};l.func=o.computeStackTrace.guessFunctionName(l.url,l.line),l.context=o.computeStackTrace.gatherContext(l.url,l.line),a={mode:"onerror",message:e,stack:[l]},i(a,!0)}return!!f&&f.apply(this,arguments)}function l(){!0!==d&&(f=n.onerror,n.onerror=s,d=!0)}function u(){var e=w,n=p;p=null,w=null,m=null,i.apply(null,[e,!1].concat(n))}function c(e){if(w){if(m===e)return;u()}var t=o.computeStackTrace(e);throw w=t,m=e,p=a.call(arguments,1),n.setTimeout(function(){m===e&&u()},t.incomplete?2e3:0),e}var f,d,h=[],p=null,m=null,w=null;return c.subscribe=e,c.unsubscribe=t,c}(),o.computeStackTrace=function(){function e(e){if(!o.remoteFetching)return"";try{var t=function(){try{return new n.XMLHttpRequest}catch(e){return new n.ActiveXObject("Microsoft.XMLHTTP")}},r=t();return r.open("GET",e,!1),r.send(""),r.responseText}catch(e){return""}}function t(t){if("string"!=typeof t)return[];if(!r(j,t)){var i="",o="";try{o=n.document.domain}catch(e){}var s=/(.*)\:\/\/([^:\/]+)([:\d]*)\/{0,1}([\s\S]*)/.exec(t);s&&s[2]===o&&(i=e(t)),j[t]=i?i.split("\n"):[]}return j[t]}function s(e,n){var r,o=/function ([^(]*)\(([^)]*)\)/,s=/['"]?([0-9A-Za-z$_]+)['"]?\s*[:=]\s*(function|eval|new Function)/,a="",u=10,c=t(e);if(!c.length)return l;for(var f=0;f0?s:null}function u(e){return e.replace(/[\-\[\]{}()*+?.,\\\^$|#]/g,"\\$&")}function c(e){return u(e).replace("<","(?:<|<)").replace(">","(?:>|>)").replace("&","(?:&|&)").replace('"','(?:"|")').replace(/\s+/g,"\\s+")}function f(e,n){for(var r,i,o=0,s=n.length;or&&(i=s.exec(o[r]))?i.index:null}function h(e){if(!i(n&&n.document)){for(var t,r,o,s,a=[n.location.href],l=n.document.getElementsByTagName("script"),d=""+e,h=/^function(?:\s+([\w$]+))?\s*\(([\w\s,]*)\)\s*\{\s*(\S[\s\S]*\S)\s*\}\s*$/,p=/^function on([\w$]+)\s*\(event\)\s*\{\s*(\S[\s\S]*\S)\s*\}\s*$/,m=0;m]+)>|([^\)]+))\((.*)\))? in (.*):\s*$/i,o=n.split("\n"),l=[],u=0;u=0&&(g.line=v+x.substring(0,j).split("\n").length)}}}else if(o=d.exec(i[y])){var _=n.location.href.replace(/#.*$/,""),T=new RegExp(c(i[y+1])),E=f(T,[_]);g={url:_,func:"",args:[],line:E?E.line:o[1],column:null}}if(g){g.func||(g.func=s(g.url,g.line));var k=a(g.url,g.line),A=k?k[Math.floor(k.length/2)]:null;k&&A.replace(/^\s*/,"")===i[y+1].replace(/^\s*/,"")?g.context=k:g.context=[i[y+1]],h.push(g)}}return h.length?{mode:"multiline",name:e.name,message:i[0],stack:h}:null}function y(e,n,t,r){var i={url:n,line:t};if(i.url&&i.line){e.incomplete=!1,i.func||(i.func=s(i.url,i.line)),i.context||(i.context=a(i.url,i.line));var o=/ '([^']+)' /.exec(r);if(o&&(i.column=d(o[1],i.url,i.line)),e.stack.length>0&&e.stack[0].url===i.url){if(e.stack[0].line===i.line)return!1;if(!e.stack[0].line&&e.stack[0].func===i.func)return e.stack[0].line=i.line,e.stack[0].context=i.context,!1}return e.stack.unshift(i),e.partial=!0,!0}return e.incomplete=!0,!1}function g(e,n){for(var t,r,i,a=/function\s+([_$a-zA-Z\xA0-\uFFFF][_$a-zA-Z0-9\xA0-\uFFFF]*)?\s*\(/i,u=[],c={},f=!1,p=g.caller;p&&!f;p=p.caller)if(p!==v&&p!==o.report){if(r={url:null,func:l,args:[],line:null,column:null},p.name?r.func=p.name:(t=a.exec(p.toString()))&&(r.func=t[1]),"undefined"==typeof r.func)try{r.func=t.input.substring(0,t.input.indexOf("{"))}catch(e){}if(i=h(p)){r.url=i.url,r.line=i.line,r.func===l&&(r.func=s(r.url,r.line));var m=/ '([^']+)' /.exec(e.message||e.description);m&&(r.column=d(m[1],i.url,i.line))}c[""+p]?f=!0:c[""+p]=!0,u.push(r)}n&&u.splice(0,n);var w={mode:"callers",name:e.name,message:e.message,stack:u};return y(w,e.sourceURL||e.fileName,e.line||e.lineNumber,e.message||e.description),w}function v(e,n){var t=null;n=null==n?0:+n;try{if(t=m(e))return t}catch(e){if(x)throw e}try{if(t=p(e))return t}catch(e){if(x)throw e}try{if(t=w(e))return t}catch(e){if(x)throw e}try{if(t=g(e,n+1))return t}catch(e){if(x)throw e}return{mode:"failed"}}function b(e){e=1+(null==e?0:+e);try{throw new Error}catch(n){return v(n,e+1)}}var x=!1,j={};return v.augmentStackTraceWithInitialElement=y,v.guessFunctionName=s,v.gatherContext=a,v.ofCaller=b,v.getSource=t,v}(),o.extendToAsynchronousCallbacks=function(){var e=function(e){var t=n[e];n[e]=function(){var e=a.call(arguments),n=e[0];return"function"==typeof n&&(e[0]=o.wrap(n)),t.apply?t.apply(this,e):t(e[0],e[1])}};e("setTimeout"),e("setInterval")},o.remoteFetching||(o.remoteFetching=!0),o.collectWindowErrors||(o.collectWindowErrors=!0),(!o.linesOfContext||o.linesOfContext<1)&&(o.linesOfContext=11),void 0!==e&&e.exports&&n.module!==e?e.exports=o:"function"==typeof define&&define.amd?define("TraceKit",[],o):n.TraceKit=o}}("undefined"!=typeof window?window:global)},"./webpack-loaders/expose-loader/index.js?require!./shared/require-global.js":function(e,n,t){(function(n){e.exports=n.require=t("./shared/require-global.js")}).call(n,t("../../../lib/node_modules/webpack/buildin/global.js"))}});
True blooded grill sweethearts out there might value this item. It is a minimized, full-included pellet barbecue that can take care of their grilling needs. You may need the item that accompanies all that you may require. When you have warmed it up, you can anticipate a perfect temperature and warmth in view of what you have chosen. Much the same as when you have found a reasonable latte machine for you, you would feel pleased with yourself for picking an extreme item that stays aware of your needs. Another element you may acknowledge in the item is that can keep the correct temperature all through the barbecuing or cooking process—regardless of whether you burn, grill, smoke or prepare. The cooking instrument is an exact griller that won’t make you stressed over any temperature variance. So whether you are an amateur or a pit ace, you might need to investigate this item that can take your grilling to the following level.
Looking for a pellet grill to do all sorts of cooking with. I am between a Rec Tec, Camp Chef Woodwind, Gorilla and Yoder. Steaks, burgers, chicken, ribs, brisket, vegetables, etc. All in one. And want to have the option to sear meat, veggies as well. Ive seen so many different reviews my head is spinning. My budget is $700-$1,000 but willing to go up if necessary. I hear some can sear, some take too long to heat up, some dont hold the temp consistently. I am a low maintenance so ease of use important. Does not have to be portable.

Camp Chef's Woodwind Pellet Smoker is a quality smoker and super searing grill wrapped up in one. As I mentioned above, though pellet smokers are often referred to as pellet grills, most have a limited grilling capability at best. To fill this gap, in 2017, Camp Chef introduced its optional LP gas Sear Box, which can be added to any of its current SmokePro pellet smokers. Woodwind is a package deal that comes standard with the Sear Box and sells for about $50 less than a SmokePro with the optional Sear Box. As a bonus, Camp Chef is one of the few brands on the market with an ash-removal system that deposits ash in a cup under the smoke box for easy disposal.


Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
This is well worth the money. I'm a Weber charcoal guy for steaks and chicken and only used my old propane for baked potatoes, corn and asada. Fired this thing up and my asada was fast and easy to make. Philly cheesesteak was fast and simple. Large cooking surface lets you do a lot and it heats fast and evenly. Just make sure if you have kiddos around they keep their hands clear of the flat top! As of yet I haven't cooked on the grill grates so can't say anything about that. Putting this together was simple and took me about 20 minutes. On a side note one of the threaded tubes for a wheel broke loose when I put the wheel on and this was due to a very poor tack weld holding it. I contacted camp chef customer service and took a pic of the defective part and within 2 business days replacement part arrived. Excellent customer service. This thing will get a work out this summer! If your looking for a cover for this it can be a pain and I bought a patio furniture coffee table cover that is close to the grill demisions and it fits perfect.
Today, all serious players in the pellet smoker market have switched to digital thermostatic controllers that dictate pellet-feed commands based on a temperature sensor inside the cooking box. Just like with the oven in your kitchen, you set the desired cooking temperature, and the heating system kicks on and off to maintain that set point. An LED display shows your set temp, and most models allow you to toggle between set temp and actual temp readings from the internal thermostat. Actual temperatures will fluctuate a bit as the controller switches on and off to hover around your set temp, but many sophisticated touch-pad controllers can maintain tighter tolerances than your indoor oven. Some pellet controllers also have integrated probes that let you monitor the internal temperature of whatever you're smoking. Wireless remote control and monitoring from your smartphone or tablet are also increasingly common. (You can learn more about pellet smokers on AmazingRibs.com.)
Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.
Even after reading the reviews and watching the videos I was still not prepared for seeing the 640 when it arrived. What a machine! A tank? Yes it is, it makes other brands look cheap and disposable by comparison. I was nervous paying a little more for a Yoder wondering if it was worth it, it was worth every penny. Have only used it a few times for ribs and chicken which turned out great. The wife said 'How much?!' when I ordered it, now she says we should have got one years ago.

The Camp Chef Woodwind Pellet Grill was chosen as our sixth choice because it lacked some features found in our Top 5 picks, especially when it came to cooking flexibility. While it does offer an impressive 6-in-1 cooking experience, it lacks an auto shut-off feature, which makes it less of a “set it an forget it” kind of smoker. The grill is rather heavy, at an overall weight of 146lbs. It’s also more expensive than the rest, even though it offers similar (even less) features. It’s a decent choice if flavor is the only thing you’re looking for.
Accurate Temperature Control: The Davy Crockett has better temperature control that permits us to program a great deal more correct temperatures (one-degree changes possible) using their application (the control board permits us to alter temperatures 5 degrees at any given moment). It uses a PID controller […] controller to expect and fine micromanage the temperature by controlling the wood screw speed and the fan speed.
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!

The wifi functionality displays both the temperature of both the grill and meat probe, using the same on your smartphone app you can tweak it according to your needs. The App also lets you set up profiles which you can configure once and use in the future as well. This adds a great accessibility feature that none of the big smokers have comparatively.


The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
We love recommending and reviewing wood pellet smoker grills, but we also want you to get the most out of them once you purchase. Without proper care and maintenance, even the best pellet smoker is bound to have a shorter lifespan. Therefore, how you use your smoker and how you maintain it after use greatly determines how long it will serve you. A little bit of work will go a long way toward extending the life of your smoker. A thorough cleaning of the smoker should occur at least once a year. If you frequently use it, you should have it done at least three times a year. Buying quality pellets will extend its life as well.
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
Hey DW – I think it’s a good call either way. Reports from users re: customer service are tops for both Rec-Tec Pellet Grills and GMG Pellet Grills. GMG offers a wifi option that now runs on your home network, and will eventually allow you to monitor via a cloud option, meaning monitoring your grill as you are out shopping etc. The extra large hopper size on the Rec-Tec Pellet Grills could be a bonus for you if you plan on doing some really long cooks. Other than that I really think it comes down to things as simple as how the unit looks. I know that sounds silly, but they are both great grills otherwise. So, what’s your gut tell you?
A FOLLOW UP: Traeger has agreed to send me replacement parts for the defective ones and I don't have to return them. However I am not returning the grill. I tried to cook a prime rib and a Boston butt. The grill randomly turned off three times and it had the "mini-explosion" others have talked about where the unit actually has an explosion within the housing lifting off the lid a couple inches and making a loud boom. This is not only a potential safety issue, but the "set and forget" is simply not true. It turned off within an hour after setting the temperature at 225 and leaving it unattended for an hour. This is not what I expected or wanted. Sorry Traeger quality is not what it is cranked up to be and certainly not worth the premium pricing they charge for their name. DON'T BUY THIS IF YOU EXPECT TO GET A GRILL THAT WORKS AS ADVERTIZED.
The popular Traeger Junior Elite is a great smoker for first-time chefs as well as experienced smokers who are short on space. It's versatile and can grill, smoke, bake, roast, braise, and barbecue food. The digital controller is adjustable to +/- 20 degrees and has 300 square inches of grilling space that is large enough for two whole chickens or three racks of ribs.
The argument against bark is that it can cause an inconsistent burn and produce excessive ash. Again, consider a log on a fire. Because they have different compositions, the bark and hardwood burn at different rates and produce different amounts of heat. Furthermore, bark doesn’t burn cleanly, it creates more ash than the hardwood. When that ash builds up, it interferes with your grill’s ability to accurately read the temperature, causing large swings. If too much of that ash builds up in the fire pot, it can cut off the oxygen and snuff out the fire.
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.

I purchased my unit new this last weekend, and had the privilege of working with the owner directly. Extremely polite and informative gentleman who is straightforward and wants you to buy what you think is best. He was not pushy at all and doesn't need to be. The product sells itself. I have a friend who has a Traeger and I have grilled/smoked with him on several occasions. There is a reason this grill weighs significantly more than the Traeger. If you are truly going to invest this amount of money in a grill, please make sure you are completely happy with your investment by purchasing this Yoder grill.

2. The grill does not come back to the set temperature after the lid is opened and closed to place the meat. I start it, close the lid, set the temp (startup procedure has changed to this according to Traeger service tech) and after 15 or 20 minutes it is not at the set temp yet...in fact it is declining. Well I need to cook on it and cannot wait forever so I open the lid quickly, throw the meat on, and close the lid quickly.
Hey Tom! First, thank you so much for commenting on this article. I hope it’s proved useful to you and helping you make your pellet smoker buying decision. I took a look at the smokers you mentioned in your comment, and they appear to be similar in build to those made by Yoder. I can verify that Yoder does exceptionally good work with both the build quality and the heavy gauge steel Construction of their smokers. I don’t know much about the manufacturing practices of the smokers you mentioned. I do like the fact that their controller automatically dropped down to a warming temperature after your food reaches the programmed temperature setting. That’s a feature that I’ve only seen in higher-priced pellet grills like the Memphis Pro Series that I talk about in this article. However, more grills are starting to utilize this in the programming aspect of their controllers. In any case it’s a great feature. To be honest with you I’m not sure that the auger mechanics are going to be all that different between smokers. I’m sure there are differences, but I don’t feel that they are dramatic enough to offer a distinct selling Advantage for the manufacturer. If you haven’t looked at them yet, you might consider taking a look at the Traeger Pro Series pellet grills. You can’t find it on Amazon, but you can find them at different retailers listed on the main Traeger site. A friend of mine has one major competitions using the pro series models.
Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
At present, I am sponsored by and continually use pellets produced by CookinPellets.com. There are two versions of pellets – the Perfect Mix (Hickory, Cherry, Hard Maple, and Apple Woods) and 100 Percent Hickory. In each of these versions, CookinPellets uses all wood, no bark, no filler woods like oak or alder and no flavor oils. Just 100% of what is on the bag. I get consistently great flavor using these two varieties of pellet smoker pellets from CookinPellets.com, and I think you’ll enjoy them very much as well.
×