Have you reviewed at all the Grilla Silverbac? If so, does it not make your list because it isn’t as good a quality as those you have picked? I mean, when I look online for reviews of those who have bought them I haven’t found anyone disappointed with theirs, but perhaps they haven’t been out as long to have a track record? I’m so confused at this point as to which to buy with PID or no PID (some say smoke does better without one), thickness of metal, etc.
I bought a Yoder YS480 three years ago. I still use my cheaper pellet grill for everyday smokes, but I use the Yoder when I want to get serious. It does a beautiful job on baby back ribs (can do up to 8 racks laying flat on the grate) and I have smoked two complete turkeys at a time. The only time I have had a problem after 2 1/2 years of smoking was caused by a failed temperature probe. I got a new probe, installed it in a few minutes, and was back up and smoking again.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.
Hey Tom, first, thank you so much for reading the article and expressing your approval of it. It means a lot to me that the information posted on this site is useful for the people. To your question about pellet grills, yes. You must always use BBQ grilling pellets with these cookers. You cannot use raw wood with them. However, should you find yourself with access too hard woods like Hickory or maple, or fruit woods like apple, cherry, or peach – this is something that could be readily used in a charcoal smoker.
Since wood chips are by-products of carpentry and woodwork, they are not only inexpensive but are also helpful for the environment since you’re using up all the parts of a tree. Its death wouldn’t go in vain! If you’re looking to learn more about the types of available wood chips and what kind of flavors they impart with, feel free to check out our post on that topic.
When reviewing pellet smokers, we’ve gone through over 1000 different user reviews to get an accurate understanding of how useful the products have been to them. With that primary data in hand, we did an extensive online research on 65 products from 17 different brands popular brands. In fact, we even looked into three less known brands as well, but they failed to stand out. We left no stone unturned.
Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
A: This may be considered the million-dollar question for many reasons. When it comes to a pellet grill, individuals have to clean it out a bit different than a regular grill because there are unique elements to clean. Many individuals recommend cleaning a grill after every use depending on the size. However, for larger grills, it is recommended to clean it after four or five bags of wood pellets. Now, what you do is vacuum out the ashtray. Some brands do have an automatic ashtray cleaner. If not, then you have to vacuum it out with a vacuum. Other aspects to clean include removing the grease drain pan, removing the porcelain grills, the heat baffle, and properly washing with warm water and a bit of soap. Most brands will have cleaning instructions in the guidelines.
Pellet cookers usually have an auger or another feed mechanism that pushes the pellets into a burn pot typically about the size of a beer can ripped in half. An igniter rod sits in the bottom of the pot and when you turn on the grill it glows like the element on an electric stove. As the pellets ignite, a fan blows to feed them oxygen, and the igniter shuts off. The Traeger L'il Tex, an inexpensive model, draws 300 watts an hour while the igniter rod is on in the first four minutes, then it drops down to 50 watts an hour for the duration of the cook session, less than a standard light bulb.
Even and fast cooking – this is the common feedback of the new and past users of this pellet grill cooker. Although some of them would say that the temperature is inaccurate, they can still manage to adjust everything well by means of its digital temperature controller. Additionally, you may need to add more pellets if you will set the temperature on a high setting.
All this said, I believe the girls you are looking at already will both provide you with long lasting grilling and smoking satisfaction. Honestly, when you get to a point where are your in the price range that you are in, it’s really hard to choose a bad option with pellet grills. The biggest Advantage you have over the ones you’re looking at and the Yoder models is that they are heavy built giving you excellent heat retention over your Cooks.
First things first, this is not post against the Traeger grill/smoker. I love the foods I have experienced from it. This is strictly about the customer service FROM TRAEGER (not amazon) I have received from them. I purchased a grill for my parents right before Xmas. I was happy to get this for them, but upon putting it together we noticed a huge dent in hopper and the under crate all dented in. Box was in perfect condition(Pics below)
I always encourage consumers to get to know a little bit about a brand and company before purchasing a product from them. What differentiates a smart consumer from a consumer is preparedness. Get to know about the company history, its commitment to consumers, its consumer service, after-sales services and warranty. It is also a great idea if you can go through consumer ratings and reports the company’s pellet grill review before buying it. Do not just fall for intelligent marketing and chic packaging. Get you facts checked; remember it is your hard earned money on the line.
Temperature range is an important factor. What you’ll need will depend on what kind of cooking you want to do. Top pellet grills can hit temperatures between 180 F to 425 F, enough for baking, smoking, roasting, and grilling. On the other hand, ioif you want to sear meat you need something that reaches the 500-550 F range. A functioning thermometer is a must. You’ll need a precise and accurate reading so you’ll know you’re cooking your meat at the right temperature.
In true Yoder fashion the 640 is not a fancy cooker with lots of shiny things, bells and whistles. Don't mistake that for poor craftsmanship, the Yoders are all built to the highest quality standards. They just happen to be more muscle car than sports car. Big, bad ass, built to last American muscle car that will blow the doors off the competition on your back deck or on the comp trail.
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
This exceptional dual-purpose wood fired oven and smoker This exceptional dual-purpose wood fired oven and smoker is the flagship member of our stunning outdoor gourmet group by Alfresco Home. With its handsome vertical design and stylish exterior the Fornetto immediately draws a crowd. When this beauty is fired up and delivering mouth watering meats poultry fish and vegetables ... More + Product Details Close
In addition to providing savings, using an oak base also creates consistency. Different types of wood have different densities, burn at different rates, and produce different amounts of heat and smoke. For instance, cherry burns faster than hickory, so using 100% cherry you’d go through more pellets than if using 100% hickory. The addition of oak allows every flavor to burn at a similar rate and with a similar heat output, providing consistency from cook to cook.
***Update: 11/2014: It's been a year now and I still adore this little grill. I've got a kamado and 3 different kettles and this is by far the most convenient and easy to use. The smoke rings this guy puts on a brisket are amazing and the flavor is the perfect balance of wood flavor without overpowering the meat. I've researched about 15 different pellet grills and I still can't find a better value than what this grill offers
For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
Yoder pellet smokers maintain a very strong reputation for quality and precision. Based out of Hutchinson, KS, the company prides itself on producing a 100 percent Made in America product that is one of the sturdiest and most reliable brands of smokers available. Check out this Yoder Smokers promo video to get an idea of how they are branding themselves.